Professional Documents
Culture Documents
Topic
s210
Selections
S210 - Select CTO Node Activity: Installation and Setup Guide
REPORT PROBLEMS
If you find any errors in this procedure or have comments regarding this application, send email to
SolVeFeedback@emc.com
Contents
General Information for Removing and Installing FRUs.........................................................3
Avoiding Electrostatic Discharge (ESD) damage......................................................................................... 3
Emergency procedures (without an ESD kit).......................................................................................... 3
Removing, installing, or storing FRUs..................................................................................................... 4
S210 Installation Guide...........................................................................................................5
MPORTANT: These procedures are not a substitute for the use of an ESD kit. You should follow them
only in the event of an emergency.
Before touching any FRU, touch a bare (unpainted) metal surface of the enclosure.
Before removing any FRU from its antistatic bag, place one hand firmly on a bare metal surface of the
enclosure, and at the same time, pick up the FRU while it is still sealed in the antistatic bag. Once you
have done this, do not move around the room or contact other furnishings, personnel, or surfaces
until you have installed the FRU.
When you remove a FRU from the antistatic bag, avoid touching any electronic components and
circuits on it.
If you must move around the room or touch other surfaces before installing a FRU, first place the
FRU back in the antistatic bag. When you are ready again to install the FRU, repeat these
procedures.
MPORTANT: This is a link to a PDF document. Print this PDF separately from this procedure by double-
clicking the image to open it.