Professional Documents
Culture Documents
Bulletin # : KSB2012018
2013.10.28
Issued by Daedong Industrial Co, Ltd
1. Problem: Old gear pump can be broken under heavy load, especially with backhoe application.
2. Solution: The gear pump is improved by adding some lubrication grooves
as shown in the chart below.
Old New
Gear pump
T2350-76102 T2350-76103
Drill lub. hole
Lub hole
in the housing
No lub. hole
Plate
(or Bush Block) Milling extra grooves
Not enough groove on the side block
-1-
4. Service tip
1) When replacing the gear pump with new one, be sure to check if the flow control valve
(T2360-38302) is contaminated with the metal chips from damaged gear pump.
2) Disassemble the main relief spool and flow control spool to clean the debris stuck
in the flow control valve.
3) Check if the spool is moving through the sleeve easily.
4) If necessary, replace the flow control valve assembly(T2360-38302).
Gear pump
Main relief spool
-2-