Professional Documents
Culture Documents
Diodes: Principles VI Characteristics and applications of rectifier diode, zener diode, LED, photodiode
SCR V-I characteristics, UJT triggering circuits, Turning-off of a SCR (preliminary discussion), Basics
of Gate Turn Off (GTO ), Structure and V-I characteristics of Triac (modes of operation not needed) and
Diac , Applications of Triac-Diac circuit, Characteristics and principle of Power BJT, power MOSFET,
IGBT, comparison of SCR, Triac, Power BJT, Power MOSFET, IGBT.
Full wave controlled rectifier using SCR’s(semi controlled, fully controlled) with R load only. Derivation
of output voltage, Block diagram of closed loop speed control of DC motors, Necessity of inner current
control loop, Basic principle of single phase and three phase bridge inverters , block diagrams including
rectifier and inverter for speed control of AC motors(frequency control only)
Q.1. Draw and explain single phase full bridge controlled or semi controlled (Asymmetric or
Symmetric) rectifier with the help of waveforms for R-load, Derive the output voltage equation.
and calculate firing angle at which fully controlled full wave rectifier is to be operated to get output
DC voltage of 110V from input voltage of 230V, 50Hz.
[07, M2014] [04, M 2015] [07, M2015] [05, D2016] [07, M2016] [04, M2014] [05, D2014]
[05, D2015] [06, D2015] [06, M2016] [06, D2016] [05, M2017] [07, D2017] [07, M2018]
[07, D2018] [07, M2019]
Q.2. With neat circuit diagram and waveforms, explain 180 mode of conduction for a 3 phase bridge
o
inverter circuit.
[07, D2017][07, M2017][07, M2014][07, M2018][07, D2018] [07, M2019]
Q.3. Explain frequency control scheme of 3-phase induction motor with the help of block diagram.
[07, D2014][07, M2016][07, M2014] [07, D2015][07, D2016]
Q.4. Explain closed loop speed control of DC motor. What is the necessity of inner current loop?
[07, M2015][06, M2014] [07, D2015][07, D2014][07, M2017][06, D2017][07, D2016]
[07, D2018]
Q.5. What is the principle of operation of bridge inverter? Classify them on the basis of applied input.
[06, D2014][05, D2016][07, M2015][05, D2015][05, M2016][07, M2017][07, M2018][05, D2018]
Q.6. Draw and explain speed-torque characteristics of DC shunt and series motor. Also state the
application of each.
[06, M2017] [07, D2017]
Q.7. Analyze torque-speed characteristics of induction motor. State various methods of speed control of
induction motors.
[06, M2017] [07, D2017]
Q.8. Enlist applications of inverter?
[05, D2017]
Operational amplifier circuits, Ideal OPAMP behavior , common OPAMP ICs, Basic OPAMP circuits-
Inverting amplifier, Noninverting amplifier ,Voltage follower (Buffer), Instrumentation Amplifier,
Active first order filter: Low pass and high pass filter, Power Op Amps, Optical Isolation amplifier, 555
timer-Operating modes: monostable, astable multivibrator
Q.1. Draw the circuit diagram, wave form and write the output voltage equation of inverting amplifier
and summing amplifier.
[07, M2017] [06, M2014] [05, M2018] [07, M2019]
Q.1. Explain with block diagram IC555 timer as astable multivibratior or monostable multivibratior.
[07, M2014] [05, D2014] [06, D2014] [04, M2015] [07, M2015] [07, D2015] [07, D2016]
[07, M2017] [06, D2017] [07, M2018] [06, D2018] [07, M2019]
Q.2. What is an instrumentation amplifier? Explain it with block diagram & enlist its applications,
advantages and disadvantage.
[06, D2017] [07, D2014] [07, M2018] [05, D2018] [06, M2019]
Q.3. What are the advantages of active over passive filter? Draw a circuit diagram and characteristics of
active low pass filter using opamp.
[07, M2015] [07, D2014]
Q.4. State important features of Op-Amp.
[04, M2015] [05, D2015] [05, D2016] [05, M2017]
Q.5. Draw the circuit diagram of differentiator and integrator? Write the output equation of each.
[07, D2016] [07, D2015]
Q.6. Explain the operation of voltage follower (Buffer amplifier) circuit?
[05, M2016] [05, D2018]
Q.7. Explain in detail first order low pass active filter.
[06, D2017] [07, M2016] [06, D2018]
Digital signals, combinational and sequential logic circuits, clock signals, Boolean algebra and logic gates
Integrated circuits and logic families: Logic Levels, Noise Immunity, Fan Out, Power Dissipation,
Propagation Delay, TTL logic family, The CMOS family, comparison with TTL family Flip flops: Set
Reset(SR), Trigger(T), clocked D F/Fs; Buffer and drivers Registers, decoders and encoders, Multiplexer and
Demultiplexer applications
Review and comparison of Torque–speed characteristics of DC motors and AC induction motors. Basic
principles of speed control of AC induction motors, Basics of BLDC motor, Linear Actuator motor, Servo
Motor, Motor specifications, Suitability of each motor for various industrial applications, Selection and sizing
of motors for different applications. Applications for pumps, conveyors, machine tools, Microcontroller based
speed controller for Induction Motor.
Q.1. What is a servo motor? Explain applications of servomotor. What are the requirements of a good
servomotor?
[07, D2014] [05, M2016] [04, J2014] [07, M2019]
Q.2. What is a brushless DC motor? Explain applications of BLDC motor. State its advantages.
[05, M2016] [04, J2014] [05, M2018] [07, M2019]
Q.3. What is linear actuator motor? Give two applications.
[05, M2017] [05, D2014]
Q.4. Select motors for medium power pump, conveyor and machine tools applications.
[07, M2016] [07, D2015] [07, D2016] [07, J2014] [07, D2014] [06, M2018] [07, D2018]
Q.5. Explain suitability of different electric motors for various industrial applications.
[07, M2015]
Q.6. Explain back EMF in DC motor.
[04, M2015]
Q.7. Draw and explain torque-speed characteristics of DC series and DC shunt motor, Also state
application of each.
[05, D2016] [07, M2016] [05, D2015] [06, M2015]
Q.8. Discuss speed torque characteristics of DC motor. Classify types of loads on the basis of time
duration.
[06, M2016]
Q.9. Analyze torque-speed characteristics of (1ɸ/3ɸ) induction motor. State various methods of speed
control of induction motor.
[05, D2016] [05, D2015] [06, M2015] [07, D2018]
Q.10.Compare BLDC motor, DC motor and Induction motor.
[04, J2014] [07, D2016] [07, D2015]
Q.11.How does driver circuit work? Illustrate with an example.
[06, M2016]
Q.12.Explain procedure to select a motor for an application and describe with the speed torque
characteristics.
[07, D2017]
Q.13.Compare AD & DC motors.
[06, M2018] [05, D2018] [05, M2019]