Professional Documents
Culture Documents
Engine Room R/B: (a) Remove the EFI relay from the engine room R/B.
(b) Disconnect the M1 mass air flow sensor connector.
(c) Check the resistance between the wire harness side con-
nectors.
Standard (Check for open):
Tester Connection Specified Condition
EFI Relay +B (M1–1) – EFI relay (3) Below 1 Ω
Standard (Check for short):
A65750 Tester Connection Specified Condition
+B (M1–1) or EFI relay (3) – Body ground 10 kΩ or higher
Wire Harness Side: (d) Reconnect the mass air flow sensor connector.
M1 (e) Reinstall the EFI relay.
+B
Mass Air Flow Sensor Connector NG REPAIR OR REPLACE HARNESS OR
A54396 CONNECTOR
OK
EVG
ECM Connector A18294 NG REPLACE ECM (See page 10–11)
OK