Professional Documents
Culture Documents
Print Exit
DESCRIPTION
While depressing the clutch pedal, the clutch switch sends a signal to terminal D of the ECM. The ECM cancels
cruise control when terminal D receives the signal.
WIRING DIAGRAM
NOTICE:
Inspect the fuses for circuits related to this system before performing the following inspection procedure.
PROCEDURE
Result:
Proceed to
OK
NG
https://toyotamanuals.com.au/docs/hilux-service-repair-manu…/RM100000000KZR8.html?PUB_TYPE=RM&MODE=3#RM100000000KZR8_04 Page 1 of 3
Inspection Procedure - Toyota Service Information 11/3/17, 6(58 pm
OK
NG
a.
Result:
Proceed to
OK
NG
OK
NG
https://toyotamanuals.com.au/docs/hilux-service-repair-manu…/RM100000000KZR8.html?PUB_TYPE=RM&MODE=3#RM100000000KZR8_04 Page 2 of 3
Inspection Procedure - Toyota Service Information 11/3/17, 6(58 pm
iii. Measure the resistance according to the value(s) in the table below.
Standard Resistance:
Tester Specified
Condition
Connection Condition
B1-2 - C57-14
Always Below 1 Ω
(D)
B1-2 or C57-
10 kΩ or
14 (D) - Body Always
higher
ground
b. for 2TR-FE
i. Disconnect the B1 clutch switch assembly connector.
iii. Measure the resistance according to the value(s) in the table below.
Standard Resistance:
Tester Specified
Condition
Connection Condition
B1-2 - G45-18
Always Below 1 Ω
(D)
B1-2 or G45-
10 kΩ or
18 (D) - Body Always
higher
ground
Result:
Proceed to
OK
NG
OK
REPLACE ECM
NG
https://toyotamanuals.com.au/docs/hilux-service-repair-manu…/RM100000000KZR8.html?PUB_TYPE=RM&MODE=3#RM100000000KZR8_04 Page 3 of 3