Professional Documents
Culture Documents
HINT:
· Use the same procedure for the RH and LH sides.
· The procedure listed below is for the LH side.
· Use the same procedure for RHD and LHD vehicles.
· The procedures listed below are for LHD vehicles.
· A bolt without a torque specification is shown in the standard bolt chart.
Click hereGeneral>SPECIFICATIONS>STANDARD BOLT>SPECIFIED TORQUE FOR STANDARD BOLTS
PROCEDURE
NOTICE:
· When reusing a removed front door lock assembly LH, replace the door lock wiring harness seal with a new
one.
· Do not allow grease or dust to adhere to the door lock wiring harness seal installation surface.
· Reusing a door lock wiring harness seal or using a damaged door lock wiring harness seal may cause water
ingress. This may result in a malfunction of the front door lock assembly LH.
https://toyotamanuals.com.au/docs/hilux-service-repair-manual-jul-15-current/N00148/manual/repair/contents/RM100000000TMY3.html Page 1 of 6
12/3/17, 12(09 am
https://toyotamanuals.com.au/docs/hilux-service-repair-manual-jul-15-current/N00148/manual/repair/contents/RM100000000TMY3.html Page 2 of 6
12/3/17, 12(09 am
4.INSTALL FRONT DOOR LOCK COVER SUB-ASSEMBLY LH (w/o Double Locking 69036A
System)
a. Attach the clamp and claw to install the front door lock cover sub-assembly LH.
https://toyotamanuals.com.au/docs/hilux-service-repair-manual-jul-15-current/N00148/manual/repair/contents/RM100000000TMY3.html Page 3 of 6
12/3/17, 12(09 am
a. Apply MP grease to the sliding parts of the front door lock assembly LH.
c. Using a T30 "TORX" socket wrench, install the front door lock assembly LH with the 3 screws.
Torque:
5.0 N*m (51 kgf*cm, 44 in.*lbf)
https://toyotamanuals.com.au/docs/hilux-service-repair-manual-jul-15-current/N00148/manual/repair/contents/RM100000000TMY3.html Page 4 of 6
12/3/17, 12(09 am
"Torx" Screw
Connector
6.INSTALL FRONT DOOR OUTSIDE HANDLE COVER WITH LOCK CYLINDER ASSEMBLY (for Driver
Side)
https://toyotamanuals.com.au/docs/hilux-service-repair-manual-jul-15-current/N00148/manual/repair/contents/RM100000000TMY3.html Page 5 of 6
12/3/17, 12(09 am
13.INSTALL POWER WINDOW REGULATOR MASTER SWITCH ASSEMBLY WITH FRONT DOOR
ARMREST BASE PANEL (for Driver Side, w/ Power Window)
14.INSTALL POWER WINDOW REGULATOR SWITCH ASSEMBLY WITH FRONT DOOR ARMREST BASE
PANEL (for Front Passenger Side, w/ Power Window)
NOTICE:
When disconnecting the cable, some systems need to be initialized after the cable is reconnected.
Click hereGeneral>INTRODUCTION>REPAIR INSTRUCTION>INITIALIZATION
https://toyotamanuals.com.au/docs/hilux-service-repair-manual-jul-15-current/N00148/manual/repair/contents/RM100000000TMY3.html Page 6 of 6