Professional Documents
Culture Documents
Keyboard case Plate Plate foam WT75-C PCB Daughter board Contact Pad
(Top/Bottom/Weight/Logo)
X1 X1 X1 X1 X1 X1
JST Cable Microfibre Cloth Gaskets Bumpons 6U stabiliser wire Hex/Phillips key
X1 X1 X2 X1 X1 X1
(28 per sheet) (6 per sheet)
7V BUILD GUIDE
ver 1.2 April 2021 1
BEFORE
YOU START
Please test the PCB by connecting it to your computer.
Download the VIA programming software from https://caniusevia.com/
When you start VIA, it should automatically detect the PCB as WT-75-C.
PCB
Break off the panelisation frame from the main PCB.
From there, go to the Key Tester and bridge each of the pads with a pair of tweezers.
Be careful not to damage the leaf-spring legs in the process.
You should see the key registering in VIA
WARNING!
Check connector head
orientation before inserting.
The female connector pins
are fragile and bent pins may
prevent the PCB from working.
7V BUILD GUIDE
ver 1.2 April 2021 2
BUMPONS
Add the bumpons to the recesses in the 4 corners
(2 on the weight and 2 on the aluminium bottom)
CASE SCREWS
x4
M3 x 25mm
pre-installed
bumpons
x4
M3 x 8mm
x4
pre-installed
7V BUILD GUIDE
ver 1.2 April 2021 3
CONTACT PAD
Unscrew the M4 x 8mm Hex countersunk-head screws and place the contact pad onto
the weight as shown in the diagram below. Reassemble the bottom and weight when done.
DAUGHTER BOARD
Screw the daughter board onto the weight. The screws will be in a separate bag.
M2 x 4mm
x4
7V BUILD GUIDE
ver 1.2 April 2021 4
GASKETS
Peel off the gasket from the sheet and place them on top case in the locations illustrated below.
Using tweezers will make application much easier.
LAYOUT
Keybindings can be programmed through VIA.
Download from https://caniusevia.com/
or
standard
or
WARNING!
The gaskets should only be applied to the top, not the bottom
Gaskets
x 26 stepped
or
7V BUILD GUIDE
ver 1.2 April 2021 5
ASSEMBLY
Install the stabilisers onto the PCB first before adding everything else.
If the foam layer has shrunk, you can stretch it out by adding the switches to the corners first.
Note that it is possible to build this keyboard without the foam layer and plate.
ASSEMBLY
Once you have finished soldering, test the PCB again to ensure that everything is working.
WARNING!
Check connector head
orientation before inserting.
The female connector pins
are fragile and bent pins may
prevent the PCB from working.
Plate foam
7V BUILD GUIDE
ver 1.2 April 2021 6
ASSEMBLY
Once you are sure that everything is in good working order, you can place the PCB onto the bottom part.
The leaf-springs from the PCB should line up with the recesses on the bottom part.
7V BUILD GUIDE
ver 1.2 April 2021 7