Professional Documents
Culture Documents
Tower 3 Daily Monitoring Progress
Tower 3 Daily Monitoring Progress
楼层日常工作检查表
编号: 编号:Ref No:
楼层: 作业班组: 编制日期:
Floor:Tower 3 Work team:PT. SKI Date:6 July 2021
安全情况 1. 现场防护:
Security 1. Site protection: No lamp at lift lobby
situation 2. 人员安全防护:
2. Personnel safety Safety shoes, Safety helmet, mask, and fest.
protection:
3. 工完场清:
3. Completed site
clearance:
1. 龙骨、吊筋、饰面板安装符合设计及规范要求,安装必须牢固,整体完好;
1. Keel, suspended bar, veneer installation must meet the design and specification requirements, and the installation must be firm and intact;
2. 饰面板表面平整洁净、色泽一致,吊顶无开裂、破损、翘曲、污垢等情况;
2. The surface of the veneer is smooth and clean, consistent color, and the ceiling is free from cracks, breakage, warpage, dirt, etc.
3. 饰面板上的灯具、烟感器、喷淋头、风口篦子等设备,位置合理、美观,套割尺寸准确、边缘整齐,与饰面板的交接应吻合、严密;
3. The lamps, smoke detectors, sprinklers, vent grates and other equipment on the veneer must be installed in right position, beautiful in appearance, accurate
cutting size, and with neat edges. The intersection with the veneer should be consistent and tight;
吊顶质量标准:
4. 金属吊杆、龙骨的接缝均匀一致,角缝吻合,表面平整,无翘曲、锤印。木质吊杆、龙骨顺直,无劈裂、变形;
Quality standard: 4. The seams of metal suspended rod and keels must the same, the angular joints are consistent, the surface is flat, and there is no warping or hammering. The wooden
boom and keel are straight and straight, without cracking and deformation;
5. 允许偏差:吊顶表面平整度3mm,接缝直线度3mm,接缝高低差1mm。
5. Allowable deviation: ceiling surface flatness deviation allowed is 3mm, deviation of the seams straightness is 3mm, and the height difference of the seams allowed
is 1mm.
现场作业
照片 Site
construct
i on
photos