• Log based saturation is used in the absence of Capillary Pressure Curves or in the absence of transition zone. • This is not SWATINIT, as SWATINIT scales the Capillary pressure curves when the end point changes • The following workflow shows the use of log based saturation. • This method uses end point scaling, here the initial and critical water saturations have the same values. Critical Water Saturation
Connate Water Saturation
Residual Water and Gas Saturation
Connate and Critical Gas Saturation
• This will have an array of end points at each cell and then it will use the relative permeability curves, for the dynamic flow. • The SOWCR and SOGCR in this case is calculated by SOWCR=(1-SUWI)*.30 and SOGCR=SOWCR • The SGU is calculated as SGU=1-SUWI-SOWCR • SWU can be 1 or 0.9 and the critical gas and connate gas will be equal to 0