Professional Documents
Culture Documents
Description
The second phase of a carrier frequency migration for the TopNET Global D correction service has been scheduled. Action must be
taken to ensure the functionality of the TopNET Global D connection. Phase 1 of the frequency migration was successfully
completed in May 2018. A second phase of frequency migrations will begin mid August 2018.
(Note:) A beam frequency table update can also be performed automatically by continuously powering the TopNET Global D receiver
for a minimum of 4 hours during the transition period. After the 4 hour run time the frequency table will be automatically updated.
The receiver must then be power cycled or have a change in selected region for the changes to be performed.
IMPORTANT NOTE: This targeted service bulletin has been distributed to Topcon Authorized Dealers only. It is the
responsibility of the Topcon Dealer to coordinate with their impacted customers.
2. Navigate to Wrench > System > GPS > Correction to ensure that the
proper Correction source of TopNET Global D is selected.
4. Enter the appropriate frequency from the list below for the desired
beam. Press the Green Check on the number pad to confirm the new
frequency has been entered correctly.
5. Select the Baud Rate option box and select 2438. Press the Green
Check to confirm.
6. Select the Service ID box and edit to read 974C. Press the Green Check
to confirm.
7. Select the Scrambler Vector and edit to read 1D2F. Press the Green
Check to confirm.
8. Exit Setup and Navigate to the GPS Accuracy tab within the GPS
Information Mini-view.
9. Select the TopNET Global D button and verify Satellite Frequency (top of
list) reads the proper frequency. For example, if using the 25E beam
the Satellite Frequency will display 1545825.000 kHz.
TopconCare.com ©2018
Topcon Agriculture SB #18005 TopNET Global D Frequency Migration Phase 2
TopconCare.com ©2018