Professional Documents
Culture Documents
Audio, Visual & Telephone System: Section
Audio, Visual & Telephone System: Section
K ELECTRICAL
E
CONTENTS
PRECAUTIONS .......................................................... 2 AUDIO UNIT .......................................................... 9 F
Precautions for Supplemental Restraint System ANTENNA ............................................................. 9
(SRS) “AIR BAG” and “SEAT BELT PRE-TEN- Removal and Installation of Audio Unit ................... 10
SIONER” .................................................................. 2 REMOVAL ........................................................... 10 G
Wiring Diagrams and Trouble Diagnosis .................. 2 INSTALLATION ................................................... 10
PREPARATION ........................................................... 3 Removal and Installation of Speakers .................... 10
Commercial Service Tools ........................................ 3 REMOVAL ........................................................... 10
H
AUDIO ......................................................................... 4 INSTALLATION ................................................... 10
System Description .................................................. 4 Removal and Installation of Tweeters ..................... 11
Wiring Diagram —AUDIO— ..................................... 5 REMOVAL ........................................................... 11
Terminals and Reference Value for Audio Unit ......... 7 INSTALLATION ................................................... 11 I
Trouble Diagnoses ................................................... 8 AUDIO ANTENNA .................................................... 12
AUDIO UNIT ......................................................... 8 Antenna Route ........................................................ 12
Inspection ................................................................. 9 Removal and Installation of Roof Antenna ............. 12 J
AV
PRECAUTIONS PFP:00011
Precautions for Supplemental Restraint System (SRS) “AIR BAG” and “SEAT
BELT PRE-TENSIONER” AKS00BEC
The Supplemental Restraint System such as “AIR BAG” and “SEAT BELT PRE-TENSIONER”, used along
with a front seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. Information necessary to service the system safely is included in the SRS and SB section of
this Service Manual.
WARNING:
● To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death
in the event of a collision which would result in air bag inflation, all maintenance must be per-
formed by an authorized NISSAN/INFINITI dealer.
● Improper maintenance, including incorrect removal and installation of the SRS, can lead to per-
sonal injury caused by unintentional activation of the system. For removal of Spiral Cable and Air
Bag Module, see the SRS section.
● Do not use electrical test equipment on any circuit related to the SRS unless instructed to in this
Service Manual. SRS wiring harnesses can be identified by yellow and/or orange harnesses or
harness connectors.
Wiring Diagrams and Trouble Diagnosis AKS00BED
PREPARATION PFP:00002
A
Commercial Service Tools AKS00BVB
Power tool C
PBIC0191E D
AV
AUDIO PFP:28111
AV
TKWB0200E
TKWB0201E
A
Terminal
Condition
(Wire color) Signal
Example of symp-
Item input/ Igni- Reference value
tom B
(+) (–) output tion Operation
switch
C
No sound from
2 1 Audio sound Receive audio
Output ON front door speaker
(L) (B/W) signal front LH signal
and tweeter LH. D
SKIA0177E
SKIA0177E
G
Receiving status of
5 Antenna Radio switch is
Ground Output ACC Approx. 12V radio broadcast
(Y/R) signal ON
becomes bad.
H
6 Battery power System does not
Ground Input OFF – Battery voltage
(Y/G) supply work properly.
Illumination con-
7 Audio unit illumina- I
trol switch is
(B/L) Illumination Changes between approx. 0V and tion does not func-
Ground Input OFF operated by light-
or control signal approx. 12V tion when lighting
ing switch in 1st
(B/OR) switch is ON.
position.
J
Lighting switch Audio unit illumina-
Approx. 12V
8 Lighting ON tion does not func-
Ground Input ON
(R/L) switch signal Lighting switch tion when lighting
Approx. 0V switch is ON.
AV
OFF
10 ACC power System does not
Ground Input ACC – Battery voltage
(GY/L) supply work properly.
L
No sound from
14 13 Audio sound Receive audio M
Output ON rear door speaker
(LG) (B/Y) signal rear LH signal
LH.
SKIA0177E
No sound from
16 15 Audio sound Receive audio
Output ON rear door speaker
(OR) (B/P) signal rear RH signal
RH.
SKIA0177E
AUDIO UNIT
Symptom Possible causes Repair order
Audio unit is inoperative (no digital display 1. 10A fuse 1. Check 10A fuse [No. 4, located
and no sound from speakers). 2. 15A fuse in fuse block (J/B)]. Turn ignition
switch ON and verify that battery
3. Poor audio unit case ground
positive voltage is present at ter-
4. Audio unit minal 10 of audio unit.
2. Check 15A fuse (No.32, located
in the fuse and fusible link box)
and verify that battery positive
voltage is present at terminal 6
of audio unit.
3. Check audio unit case ground.
4. Remove audio unit for repair.
Individual rear speaker is noisy or inopera- 1. Each speaker 1. Check speaker.
tive. 2. Output circuit to each speaker 2. Check the output circuits to each
speaker between audio unit and
each speaker.
AM/FM stations are weak or noisy. 1. Roof antenna 1. Check roof antenna.
2. Audio unit ground 2. Check audio unit case ground.
3. Audio unit 3. Remove audio unit for repair.
Audio unit generates noise in AM and FM 1. Poor audio unit ground 1. Check audio unit case ground.
modes with engine running. 2. Loose or missing ground bonding straps 2. Check ground bonding straps.
3. Ignition condenser or rear window defogger 3. Replace ignition condenser or
noise suppressor condenser rear window defogger noise sup-
4. Ignition coil pressor condenser.
Inspection AKS00BEJ
AUDIO UNIT A
All voltage inspections are made with:
● Ignition switch ON or ACC
B
● Audio unit ON
● Audio unit connected (If audio unit is removed for inspection, supply a ground to the case using a jumper
wire.)
C
ANTENNA
Using a jumper wire, clip an auxiliary ground between antenna and body.
● If reception improves, check antenna ground (at body surface). D
● If reception does not improve, check main feeder cable for short circuit or open circuit.
AV
REMOVAL
1. Remove instrument cluster lid C. Refer to IP-10, "INSTRUMENT PANEL ASSEMBLY" .
2. Remove screws (4) and disconnect connector, and remove
audio unit.
SKIA9194E
SKIA9195E
INSTALLATION
Install in the reverse order of removal.
Removal and Installation of Speakers AKS00BEM
REMOVAL
1. Remove door finisher. Refer to EI-32, "DOOR FINISHER" .
2. Remove speakers.
SKIA0001E
INSTALLATION
Install in the reverse order of remove.
REMOVAL A
1. Remove front speaker grille. Refer to IP-12, "Front Speaker Grille (LH/RH)" .
2. Remove tweeters.
B
SKIA0002E
E
INSTALLATION
Install in the reverse order of remove.
F
AV
SKIB0669E
1. Remove headlining.
● Refer to EI-40, "HEADLINING" in “Exterior/Interior (EI)” sec-
tion.
2. Remove roof antenna mounting nuts, antenna plug, and discon-
nect power connector. Then remove roof antenna.
SKIA9663E
SKIA4165E