Professional Documents
Culture Documents
Generator (6HK1)
Specifications
Charging Circuit
B
3 4 5
L
2 L
R R
E 6
1
7
E
WSHK0091
Name
1. Field Coil 5. Key Switch
2. Stator Coil 6. Battery 24 V
3. Diode Trio 7. IC Regulator
4. Charging Lamp 8. Generator
Charging circuit and internal circuit are shown in the illustration above.
Charging system consists of IC regulator built-in generator, battery, charging lamp and wires to connect them.
1D-44 Engine Electrical
Structure
5 6
4
7
8
1
9
10
WSHK0092
Name
1. Rear Bracket 6. Rotor
2. IC Regulator 7. Bearing
3. Bearing 8. Pulley
4. Rectifier 9. Front Bracket
5. Stator 10. Coil Assembly (Field Coil)
This generator has no brush. terminal (for direct current output), L terminal and R
Main parts are a rotor, stator, rectifier assembly, front terminal.
bracket, rear bracket, IC regulator, bearing, pulley and The L terminal is connected to field coil. Therefore, as
so on. well as R terminal, it becomes input terminal for
Moving parts are a rotor and pulley. A field coil is initiating excitation current until the generator starts to
secured to rear bracket. generate electric power.
Six main diodes and two additional diodes are used to It also provides function as output terminal. (Current
convert three-phase alternating current, generated in capacity is 1 A.)
stator coil, into direct current. Among six main diodes, The charging lamp will be off if the voltage on L
there are three positive diodes and three negative terminal reaches battery voltage.
diodes. Both bearings are sealed, therefore periodic lubricant is
In addition, three tiny diodes, called trio diode, are used not necessary.
to supply field current. IC regulator cannot be disassembled. Handle it as
This generator has three terminals, which are B assembly.