Professional Documents
Culture Documents
SERVICE TOOL
Labor Saver – Tool A single Bushing Service Tool fits the following
removes worn-out bushings and Holland suspensions:
installs new bushings with only
• NS, RL, and RLU Series Trailer Suspensions
minimal dis-assembly of the suspension.
• AD and ADL Series Truck Suspensions
(except Axle Adapter Pivot Bushings on
Lower Maintenance Cost – It is no longer AD-126/252/378/ and AD-130/260/390
necessary to do complete tear-downs when Suspensions)
replacing bushings. The Bushing Service Tool is
• ART and NL Series Auxiliary Suspensions
easy to use and requires only a readily available
socket and air impact or hand wrench. • ER-2250 Trailer Rubber Ride Suspensions
Order Part No. 505 44 012 from your authorized
Holland distributor.
E n g i n e e r i n g Yo u r R o a d t o S u c c e s s
BUSHING SERVICE TOOL INSTRUCTIONS
1. Drive Adapter Plate 12. Thread rod into receiver tube assembly (Figure 3). Using
proper wrench as indicated in Step 1, apply torque to drive
6. Threaded Rod nut and force new rubber bushing into beam receptacle.
New bushing must be centered in bushing receptacle after
4. Receiver Tube
force has been removed.
Assembly 13. Remove the threaded rod from the new bushing and
re-assemble the suspension.
3. Bushing Adapter 14. Make sure all connections have been re-torqued to the
9. Steel Sleeve proper specification. Refer to appropriate suspension
7. Silicone maintenance manual for proper torque procedures and
8. Drive Nut Lubricant
Figure 1 specifications.
15. Remove trailer from jack stands.
E n g i n e e r i n g Yo u r R o a d t o S u c c e s s
Copyright © February 2008-SAF-HOLLAND, Inc. All information contained in this document was correct at time of copyright, and is subject to change without notice. All rights reserved.