Professional Documents
Culture Documents
1. A rivet is specified by
(a) shank diameter (b) length of rivet
(c) type of head (d) length of tail
2. The diameter of the rivet hole is usually ___ the nominal diameter of the rivet.
(a) equal to (b) less than (c) more than
3. The rivet head used for the boiler plate riveting is usually
(a) Snap head (b) pan head
(c) counter sunk head (d) conical head
4. According to UnWin’s formula, the relation between diameter of rivet hole (d) and thickness
of plate (t) is given by (units in mm)
(a) d = t (b) d =1.6t
(c) d = 2t (d) d = 6t
5. A line joining the centres of rivets and parallel to the edge of the plate is known as
(a) back pitch (b) marginal pitch (c) gauge line (d) pitch line
6. The centre to centre distance between two consecutive rivets in a row, is called .
(a) margin (b) pitch (c) back pitch (d ) diagonal pitch
7. A lap joint is always in ____ shear
(a) single (b) double
8. A double strap butt joint (with equal straps) is
(a) always in single shear (b) always in double shear
(c) either in single shear or double shear (d) any one of these
tan tan
(a) tan (b) tan
tan tan
(c) tan (d) tan
20. A screw jack has square threads and the lead angle of the thread is on. The screw jack will be
self-locking when the coefficient of friction () is
24. While designing a screw in a screw jack against buckling failure, the end conditions for the
screw are taken as
(a) both ends fixed (b) both ends hinged
(c) one end fixed and other and hinged (d) one end fixed and other end free
25. The load cup of a screw jack is made separate from the head of the spindle to
(a) enhance the load carrying capacity of the jack
(b) reduce the effort needed for lifting the working load
(c) reduce the value of frictional torque required to be countered for lifting the load
(d) prevent the rotation of load being lifted