The document contains a 20 question multiple choice quiz about engineering concepts. The questions cover topics like manufacturing processes, material properties, stress and strain, failure theories, joints, bolts and rivets. The questions have 4 possible answer choices labeled a, b, c, or d.
The document contains a 20 question multiple choice quiz about engineering concepts. The questions cover topics like manufacturing processes, material properties, stress and strain, failure theories, joints, bolts and rivets. The questions have 4 possible answer choices labeled a, b, c, or d.
The document contains a 20 question multiple choice quiz about engineering concepts. The questions cover topics like manufacturing processes, material properties, stress and strain, failure theories, joints, bolts and rivets. The questions have 4 possible answer choices labeled a, b, c, or d.
Global College of Engineering & Technology (SET 1)
Mid:1 Sub:DMM Time:30 Marks:20
1. The parts of circular cross-section which are symmetrical about the axis of rotation are made by ( ) a).hot forging b).hot spinning c).hot extrusion d).hot drawing 2. The cold working of metal is carried out……..the recrystallisation temperature ( ) a).above b).below c).centre d).side 3. According to Indian Standards, total number of tolerances grades are ( ) a).8 b).12 c).18 d).20 4. The factor of safety for steel and for steady load is ( ) a).2 b).4 c).6 d).8 5. The poisson’s ratio for steel various from ( ) a).0.21 to 0.25 b).0.25 to 0.33 c).0.33 to 0.38 d).0.38 to 0.45 6. When the material is loaded within elastic limit, then the stress is …….. to strain ( ) a).eqal b).directly praportional c).inversely praportional 7. The max bending stress, in curved beam having symmetrical section, always Occurs, at the ( ) a).centroidal axis b).neutral axis c).inside fiber d).out fiber 8. Rankine’s theory is used for ( ) a).brittle material b).ductile material c).elastic material d).plastic material 9. Guest’s theory is used for ( ) a).brittle material b).ductile material c).elastic material d).plastic material 10. Failure of material is called fatigue when its fail ( ) a).at the elastic limit b).below the elastic limit c).at the yield point d).below the yield point 11. The yield point in static loading is ……… as compared to fatigue loading ( ) a).higher b).lower c).same 12. The surface finish factor for a mirror polished material is ( ) a).0.45 b).0.65 c).0.85 d).1 13. A rivet is specified by ( ) a).shank dia b).length of rivet c).type of head d).length of tail 14. The diameter of the rivet hole is usually ……….. the nominal diameter of the rivet ( ) a).equal to b).less than c).more than d).none 15. The rivet head used for boiler plate riveting is usually ( ) a).snap head b).pan head c).counter sunk head d).conical head 16. A lap jiont is always in ……….. shear ( ) a).single b).double c).multiple d).above all 17. The process extensively used for making bolts and nuts is ( ) a).hot forging b).hot spinning c).hot extrusion d).hot drawing 18. Hook’s law holds upto ( ) a).yield point b).elastic limit c).plastic limit d).breaking point 19. At the neutral axis of a beam, the shear stress is ( ) a).zero b).maximum c).minimum d).none of the above 20. The centre to centre of rivets and parallel to the edge of the plane is known as ( ) a).back pitch b).marginal pitch c).gauge line d).pitch line