Professional Documents
Culture Documents
a. 1:10
b. 1:20
c. 10:1
d. 20:1
21. For a given rpm. If the diameter of a twist drill increases, then
cutting speed will
a. decrease
b. increase
c. same.
a. cutting speed
b. feed
c. speed
a. same direction
b. opposite direction
c. neither A or B
d. A and B both
24. For grinding materials having low tensile strength which of the
a. aluminium
b. corundum
c. emery
d. silicon carbide
25. the size of grinding wheels is taken from
b. bore size
c. width of face
a. ball center
b. half center
c. female center
d. pipe center
27. when outside diameter of a job is turned in relation to the
internal hole, the job should be ______.
a. between centers
c. on face plate
d. on lathe mandrel
28. What is the included angle of a dead center?
A. 30 °
B. 45 °
C. 60 °
D. 90 °
29. What is the main alloying element in high speed steel?
A. Chromium
B. Tungsten
C. Vanadium
D. Nickel
30. The value of one micron is
A. 1.00 mm
B. 0.01 mm
C. 0.10 mm
D. 0.001 mm
31. For the accurate measurement of bores, the instrument to use
is
B. inside micrometer
C. plug gauge
D. verneir calliper
32. Under sine principle the length of sine bar takes the place of
____________.
A. adjacent
B. height
C. hypotenuse
D. opposite
33. In a hydraulic driven shaper the metal is removed at
A. average speed
B. higher speed
C. lower speed
the crankpin
a. mm / stroke
b. mm / revolution
c. meter / minute
a. form
b. gooseneck
c. round nose
d. V shaped
38. shaper tool bit should not extend in tool holder beyond
a. 5mm
b. 15mm
c. 25mm
d. 50mm
39. the standard ratio of cutting to return stroke in shaper is
a. 3:1
b. 1:3
c. 2:3
d. 3:2
40. A tipped tool is more useful than high speed steel tool because
C. Hydraulic mechanism
A. materials to be cut
B. finish required
A. concave surface
B. comical surface
C. convex surface
D. flat surface
45. The clamp block used in a slotter to support the end of the trap
is made of
C. lead
D. wood
46. The table of slotter has feeding requirements which is
A. longitudinal
B. cross
C. rotary
A. one table
B. one housing
C. two tables
D. two housing
48. In a planer the feed is provided
A. at forward stroke
B. at return stroke
C. depth of cut