Professional Documents
Culture Documents
Bank - 02 44%
#
1. Answer 15 m
Given
1. Correct 15 m
Answer
3. Question Faucet fitted with nozzle curving downward used as a draw-o tap:
5. Question Liquid sewage that has been treated in a septic tank or sewage
- 44%
treatment plant.
5. Correct e uent
Answer
6. Correct sump
Answer
7. Question What property is used to distinguish between potable and sanitary uPVC
pipes?
7. Answer color
Given
7. Correct color
Answer
9. Question A tee shaped pipe fitting for making a three - way joint?
9. Answer X11.4
Given
- 44%
9. Correct X11.4
Answer
10. A piece of pipe threaded outside all through out to connect short runs
Question of two pipe fittings.
11. A valve that supplies a fixed quantity of water to fixtures for flushing
Question purposes when actuated by direct water pressure.
12. Where traps are used to prevent foul odor from coming out., Which of
Question the following does not have a water trap?
14. In RNPCP - it is the lowest portion of the interior part of any pipe or
Question conduit that is not vertical.
- 44%
14. Answer invert
Given
15. In plumbing system, if pipes are electrical wires, what are the equivalent
Question of switches?
16. A suitable and economical type of water pump for a 200 ft driven wall
Question to deliver 10 gpm against 200 ft. The develop height (TDH) where the
motor and pump is located at the surface.
17. Answer A
Given
17. Correct A
Answer
- 44%
19. The minimum soil pipe size for a water closet:
Question
20. Water from laundries, wash basins, sinks, shower, and bathtub.
Question
- 44%
24. Minimum fixture drain size for a bathtub.
Question
25. In RNPCP, is the top edge of receptacle from where water overflows
Question
26. A plumbing device designed to intercept most greases and solids before
Question they enter a wastewater disposal system., except for one;
27. In RNPCP, a tank located above or integral with water closet, urinal or
Question similar fixtures for flushing or removing excrements in the fixture.
28. Sediment that settles out of sewage, forming a semi-solid mass on the
Question bottom of a septic tank.
- 44%
28. Correct sludge
Answer
29. Where would you locate water distribution pipe farthest from?
Question
32. The sewage treatment process that involves the use of hydrochloride to
Question kill pathogenic bacteria.
32. Answer 38 mm
Given
33. Assuming the waste pipe of a fixture is 50 mm, what should be the size
Question of its vent pipe?
- 44%
33. Answer cPVC
Given
33. Correct 32 mm
Answer
34. A rigid type of pipe known to have a good chemical resistance, excellent
Question impact strength, especially at low temperatures and maintains rigidity at
high temperatures. (black/ gray pipe)
35. The vertical supply pipe which extends upward from one floor to the
Question next is called a ________.
37. The minimum distance (in meters) of a streams from a seepage pit or
Question cesspool?
- 44%
38. A female G.I. threaded pipe reducer fitting use to connect a reducing
Question branch pipe at an angle.
39. There is a septic tank installed on top of a rock by the seashore. The
Question tank is exposed on low tide and covered in sea water during high tide.
Which of the following would be an appropriate water proofing for it?
40. A female G.I. pipe reducer fitting used in a straight pipe connection
Question where the fitting's both ends are threaded inside
- 44%
42. Answer wye
Given
43. A pipe fitting to change in one single direction (course) the following of
Question water:
44. These are fixtures that are installed in janitor's closets and building
Question maintenance areas for use by the building maintenance personnel.
45. What do you call a liquid waste (without urine/ industrial waste)
Question discharges into the sewer?
46. A cross fitting having a slight curve in each of the 90 degree transition
Question to channel the flow from branch pipes in the direction of the main
- 44%
47. The part of a vent line which connects directly with an individual trap
Question underneath or behind the fixture and extends to the branch or main
pipe and point higher than the fixture trap:
47. Answer 1%
Given
48. Solder and fluxes used in piping systems conveying potable water are
Question prohibited when lead content exceeds _______.
49. How could you di erentiate between a soil and waste pipe when laid
Question side by side?
50. How could you di erentiate between a soil and waste pipe when laid
Question side by side?
51. A coupling device for connecting 2 pipes neither of which can be turned,
Question consisting of two internally threaded end piece which are tightened
around the pipes ends to be joined, and externally threaded center
- 44%
piece, which draws the two end pieces together as it is rotated.
51. Answer B
Given
53. Base on the figure below, which of the following is a 1/8 bend fitting?
Question
53. Correct B
Answer
54. A type of sewage disposal that has a vault constructed or concrete for
Question the collection of raw sewage and a wooden shelter.
55. In RNPCP, a pipe connected from the building gutter to the downspout
Question or conductor.
- 44%
55. Correct leader
Answer
56. What is the most e cient tools for cutting cast iron pipe?
Question
58. A female G.I. threaded pipe reducer fitting use to connect a reducing
Question branch from a main water distribution
59. The clear vertical distance between the spout of a faucet or other supply
Question pipe and the flood level of a receptacle.
60. A flexible type of pipe known to have the only flexible plastic tubing
- 44%
Question suitable for use with hot and color water pressure system and it is also
known as an excellent chemical resistance to acids and alkalis but is not
suited for fuel oil, gasoline or kerosene distribution system. (blue or gray
pipe).
63. A piece of pipe lesser than 12" length and threaded on both sides.
Question
- 44%
64. A type of coupling or joining device having internal screw threads or
Question nuts with opposite screws at the end. By turning the internal screws, it is
possible to connect two metal rods and regulate the length and tension
of this rods.
65. A term used to describe pumps that are interconnected with each other.
Question
- 44%
68. Correct bichlor
Answer
69. There are several reasons why soil stacks are not allowed in columns.
Question Which is not a reason?
69. Answer drill a hole of the beam, enough diameter that a pipe could go in and
Given pass through. Just make sure that the hole is precisely in the middle to
avoid bars to be hit in.
70. A flange that closed the end of pipe. There is no opening for the
Question passage of water.
71. During site inspection, the architect notices that a soil pipe will cross a
Question beam, what's the best advice he can do?
72. IN RNPCP, individual vent is pipe installed to vent a fixture trap & which
Question connects with the vent system above the fixture served or terminates in
the open air. A term I.P.S. means _________.
- 44%
73. It is the line in a single line diagram that runs from the fuses to the
Question home run.
74. Water well yield is a factor considered to determine the size of?
Question
75. Water is distributed from the normal water pressure coming from the
Question public water main, for low rise buildings.
76. A term used for a pipe extension of not more than 2 feet in length,
Question installed at any stack or branch of a plumbing rough-in for the purpose
of future tap.
77. The length of pipeline measured along the center line of the pipe and
Question pipe fittings.
- 44%
77. Answer elbow
Given
78. A flexible type pipe that is excellent in chemical and crush resistance has
Question impact strength and flexibility and good low temperature performance.
(black-bluish pipe).
- 44%
82. An outlet, pipe, or receptacle for excess liquid.
Question
84. A reservoir, tank or vessel for storing or holding water or other liquids.
Question
85. The minimum distance (in meters) of streams from a disposal field?
Question
86. Correct 15 m
Answer
- 44%
87. Minimum clearance from the floor of pipes for AC units when crossing a
Question hallway or corridor.
90. The minimum distance (in meters) of well from a septic tank.
Question
91. A device used to control an incoming high water pressure into the water
Question distribution system by mechanical means so as to bring it to a working
pressure of 80 psi.
- 44%
91. Correct pressure reducing valve
Answer
92. One of the first steps in the selection of a suitable water supply source
Question is:
93. The septic tank has a total volume of 6.48 cum, what should be the
Question required volume of its leaching chamber?
94. A general term used for any vertical line of soil, waste, or vent piping.
Question
94. Answer D
Given
95. A pipe that conveys the discharge of water closets or fixtures having
Question similar functions with or without the discharges from other fixtures?
- 44%
96. Answer ball cock
Given
96. Correct D
Answer
98. A device for regulating the supply of water in a flush tank by means of
Question hallow floating ball which by its rise or fall shuts or opens a supply
valve.
99. The minimum distance (in meters) of a water supply well from a
Question disposal field
100. The reference in measuring the depth of a trap seal of the the trap:
Question
- 44%