Professional Documents
Culture Documents
Flexible Water proofing Coating Providing High Impact Strength and Aging Resistance
GENERAL DESCRIPTION
The “Water ingress” is an important issue with respect to concrete corrosion & seepage on
building roofs. In general roofs are flate and built on a concrete & Metal re-bar resting side
walls. During Manson or water spillage, water penetrates into Concrete and due to gravity
seeps out in side of building through roof & side walls. And start corrosion in metal re-bar
results structure looses strengths.
Due to its low sensitivity to humidity it can also be used for coatings in thin layers and has a
remarkably high tensile and tear strength.
Application:
As flexible water proofing membrane.
Flexible joints sealing.
Tank base sealing.
Corrosion protection on bolting and flanges.
Water Pumps
Safety
Safety clothing, helmets and goggles should be worn during application.
APPLICATION GUIDELINES
Products:
i) 920 Stangard base coat
ii) 926 Stangard water Seal
iii) 7824 Membranel
Application procedure:
1) Remove all loose material from concrete base.
2) Clean & roughened both the surfaces metal part and concrete base.
3) Inspect the surface…surface should be free from dust, dirt, oil, moisture, loose particles
and other foreign particles.
4) Repair the concrete cracks (if present) by using 750 Stanfloor repair.
5) Apply the 920 Stangard base coat on surface with 4 sqmtr/ltr spreading rate.
6) Wait for 12-16 Hrs So that primer film cured.
STANVAC CHEMICALS (INDIA) LTD.
Corporate Office: 552, Sector-37, Pace City-II, Gurgaon, Haryana – 122001, India
Ph : +91-11-24647252, 24647199, 24638360, 24652337, 24649831 Fax : +91-11-24623826, 24633847
E-mail : sales@stanvac.com Web site : www.stanvac.com
7) Rough the cured film of 920 Stangard with 80 no. emery paper and clean lose dust dirt
by clean cloth or high pressure air jet.
8) Make solution of 926 Stangard by mixing Part-A and Part-B, stir well for 10 min.
9) Apply the 926 Stangard solution with using brush 2.75-3.0 sqmtr/Ltr Spreading rate.
10) Stick 7824 Membrane on wet film of 926 Stangard and apply roller on it, so that
membrane merge into 926 Stangard wet film.
11) Wait for 3-4 hrs.
12) Over coat with 926 Stangard with 1.7-1.8 sqmtr/ltr spreading rate. .
13) Inspect the surface of applied system… if found any pin-hole or ir-regularities; repair the
same with using 926 Stangard. Provide 36-48 Hrs drying time.