Professional Documents
Culture Documents
Check radio connections. Refer to StarFire 3000 receiver diagnostics if that unit is present, for all others, use the RTK diagnostics.
iTC 003141.14 Receiver To Base Station Authorization Problem
The GPS receiver is not authorized on this RTK network. Refer to Operator's manual.
iTC 003141.31 GPS Corrections License Expired
GPS corrections license has expired.
iTC 003144.13 Receiver Frequency Calibration Problem
Receiver can not link to StarFire network on the alternate frequency. Change frequency to Default.
iTC 522338.13 Receiver Not Receiving On Alternate Frequency
Frequency has been changed from default. Change frequency to default.
iTC 522339.31 GPS Corrections License Expired
Call your local GreenStar support number for license renewal.
iTC 522394.13 TCM not Calibrated
Calibrate TCM
iTC 522552.11 STARFIRE Network Fault
John Deere corrections network is not working. Wait for signal to become available again.
iTC 523187.02 Invalid License Activation received from StarFire Satellite
Invalid license code received.
iTC 523274.02 GPS Position Not Available
GPS signal is totally lost.
iTC 523309.07 Yaw Sensor Out Of Range
Vehicle course is not being corrected. Replace STARFIRE iTC receiver.
iTC 523309.16 Yaw Sensor Not Responding
Vehicle course is not being corrected. Replace STARFIRE iTC receiver.
iTC 523310.02 Memory Fault
StarFire memory error.
iTC 523319.18 Low Switched Voltage
Switched voltage below 8 VDC.
iTC 523348.07 TCM communication Failure
Inertial measurement unit communication failure
iTC 523348.12 TCM Sensor Failure
TCM sensor failure
iTC 523348.16 TCM Temperature out of Range
Reported IMU temperature is out of its calibrated range.
iTC 523441.31 No STARFIRE Height Dimension
Set height in TCM setup.
iTC 523442.31 No STARFIRE Fore/Aft Set
Set fore/aft in TCM setup or check SSU status.
iTC 523572.31 Power Shutdown Fault
Settings not saved from last shutdown. Check unswitched voltage.
iTC 523773.03 Vehicle CAN High Line Voltage High
Voltage above 4 VDC.
iTC 523773.04 Vehicle CAN High Line Voltage Low
Voltage below 1 VDC.
iTC 523774.03 Vehicle CAN Low Line Voltage High
Voltage above 4 VDC.
iTC 523774.04 Vehicle CAN Low Line Voltage Low
Voltage below 1 VDC.
iTC 523792.18 Low Unswitched Voltage
Unswitched voltage below 8 VDC.
iTC 524209.16 RTK Rover Too Far From Base Station
Indicates distance is over 16.9 km (10.5 miles) from base station.
iTC 524210.16 RTK Base Station Not Using Visible Satellites
RTK base station not using visible satellites.
iTC 524257.14 RTK Base Station Position Survey In Progress
Wait until survey is complete.
iTC 524257.16 RTK Base Station Relocation
Indicates base station moved greater than 20 meters.
LCR 523310.02 Memory Fault
Replace STARFIRE iTC receiver.