Professional Documents
Culture Documents
FINAL TEST
50 Marks Date-13.1.2020
Chapter 1 Introduction
(1) The design process have two categories : functional design and --------------design .
(2) The designer need to consider the structure to be safe, economical, -------- and maximum efficiency.
(3) The designer need to consider the design based on calculation and -------------.
(A) His engineering judgement (B) His experience (C) His knowledge (1 mark)
(11) When Temperature reach ........ ‘C ,steel members have lowest strength.
(13) For thin plate member with bolt holes near edge, ................ may be controlled failure mode.
(14) ‘U’ is the reduction factor in tension member design, that is due to --------condition.
(15) As per AISC specification B7, l/r for tension member is-----.
(16) If shear plane is in Bolts thread portion, shear strength of bolts reduce ----------------- %.
(20) The minimum spacing of bolts in a line is preferably (LRFD-J3.3) -----------bolt diameters.
(21) The bolt minimum end distances must be at least ---------- diameters.
Chapter 5 Welding
(A) Field weld (B) Shop weld (C) Weld all around (1 mark)
(A) Field weld (B) Shop weld (C) Weld all around (1 mark)
(A) groove weld (B) Shop weld (C) fillet weld (1 mark)
(25) For thin plates connection, only one edge weld may lead----------------------------.
(30) The member that has large slenderness ratio is ------------------ under axial compression forces.,
(33) Goteik Viaduct tower legs are lattice column design and it can carry over -----------tons.
(34) For a flexural member, sectional properties ---------------is the most important.
(A) Area (B) Section modulus (C) Polar moment of inertia. (1 mark)
(37) The short span and heavy load beams ------------does control.
(A) Beam flange thickness (B) Beam Web thickness (C) Flange width (1 mark)
(A) Beam web (B) Bearing length (C) Beam flange (1 mark)
(41) For torsion control members, such as mono-pole billboard,-----------sections are optimum.
(42) Beams failures modes are flange failure, web failure and ---------------------.
(A) Shear failure (B) Compression failure (C) Lateral torsional buckling of beam (1 mark)
(A) Web stiffeners (B) Flange stiffeners (C) Lateral support (1 mark)
(44) Freely Long span structures such as Crane girder,---------------should be increase for Lateral torsional
buckling.
(A) Cross sectional area (B) Polar moment of inertia (C) Shear area (1 mark)
(46) For extended end plate connections, bolts numbers, bolts size and bolts ------------can be adjusted for
optimum design results.
(50) For the welded connections, welding size, welding grade and welding--------can be adjusted for
design.
-------------------------------------------------------------------------------------------------------------------------------