Professional Documents
Culture Documents
CONTENTS
FIXED VOLTAGE REGULATORS
LOGIC IC’S 2261 - 2262
SEMICONDUCTORS IC’S 2254 - 2257
DAVID USE PHOTO VOLTAGE REGULATORS 2257 - 2260
SD0010
MK484 RADIO IC
ANALOGUE SWITCHES
SD0010
2253
SQUIRES MODEL & CRAFT TOOLS
SEMICONDUCTOR IC’S HT9170 DTMF RECEIVER the HT9170 dual tone multi frequency
(DTMF) receivers combine digital decoder and bandsplit functions
TRANSISTOR ARRAYS housed in standard DIL packages. in one IC. The IC features supply power-down mode and inhibit
CODE TYPE PRICE mode operations, and uses digital counting techniques to detect
720-889 IC LM3046M Transistor Array 5 Matched (SO14)... £1.50 and decode all the 16 DTMF tone pairs into a 4 bit code output.
720-800 IC ULN2003 Transistor Array 7 Matched (DIL16)... £0.99 Highly accurate switch capacitor filters are employed to divide tone
720-805 IC ULN2004 Transistor Array 7 Matched (DIL16)... £0.99 (DTMF) signals into low and high group signals. A built in dial tone
720-806 IC ULN2803 Transistor Array 8 Darlington (DIL18). £1.25 rejection circuit is provided to eliminate the need for pre-filtering.
720-807 IC ULN2804ATransistr Array 8 Darlington (DIL18). £1.50 Supplies in DIP18 package (HT9170B) ans SOP18 (HT9170D).
Technical Specification
Supply voltage: 3.5V to 16V
LED constant current: 15mA
Technical Specification Sensitivity: 105mV RMS
Supply voltage: 40V max Max. power dissipation: 1100mW
Supply current: 4mA Operating temperature: –25°C to +75°C
VFC non-linearity: ±0.003%
Conversion accuracy scale factor: 1kHz/V CODE TYPE PRICE
Temperature stability of gain: ±30ppm/°C 25-0114 5 LED LIN Meter Driver LB1413........................... £3.99
Rated full scale frequency: 10kHz
Reference voltage: 1.70V L298 DUAL FULL-BRIDGE DRIVER the L298N is an integrated,
CODE TYPE PRICE monolithic circuit which is a high voltage, high current, dual full
25-0446 Prec Volt To Frequency Converter LM331N........ £2.99 bridge driver. Designed to accept standard TTL logic levels, and
drive inductive loads such as relays, solenoids, DC and stepping
LED FLASHING CONTROLLER IC the M34 is a low voltage sin- motors. Two enable inputs are provided to enable or disable the
gle output LED flashing controller IC that can drive several LEDs device independently of the input signal. Supplied in a 15-lead
simultaneously ( max current 25mA). The IC has an in built RC Multiwatt package.
oscillator circuit, so requires minimum external components. M34-
1 designed for a 3V DC supply, and is housed in a T0-92 package.
Technical Specification
Output voltage: 5V
Line regulation: 2mV
Load regulation: 12mV
Output impedance: 24mΩ
CODE TYPE PRICE
Quiescent current: 38mA (Iout = 500mA)
720-550 IC M34-1 LED Flasher Chip (1Hz) TO92.................... £0.75
Output noise voltage: 100µV
720-555 IC M34-2 LED Flasher Chip (2Hz) T092..................... £0.75 Current limit: 0.92A
BARGRAPH DISPLAYS The LM3914 and LM3915 have two CODE TYPE PRICE
modes of operation. In dot mode, the IC will sequentially light 10 25-0120 Dull Full Bridge Driver L298N............................... £7.99
LEDs when a gradually increasing voltage is applied to pin 5.
There is a slight overlap so that at no time are all the LEDs off. In L6210 DUAL SCHOTTKY DIODE BRIDGE the L6210 is a mono-
bar mode all LEDs indicating below the input voltage are on. A lithic IC containing eight Schottky diodes arranged as two separate
brightness control can set the LED current between 2mA and diode bridges. It is a very versatile device for many applications.
30mA. The ICs are stackable, and displays with 100 or more Particularly suitable for bipolar stepper motor applications where
LEDs are possible. The device requires a supply voltage in the 3V high efficiency operation, due to low forward voltage drop and fast
to 18V range. The LM3914 produces linear steps, and the reverse recovery time, is required.
LM3915 produces -3dB steps i.e. logarithmic scale. Supplied in
DIL18 package. The LM3916 will display a Vu scale, ie -10dB, -
7dB, -5dB, -3dB, -1dB, 0dB, 1dB, 2dB and 3dB. Supplied in a
DIL18 package.
Technical Specification
Peak repetitive forward current: 2A max
Peak reverse voltage: 50V max per diode
Ambient operating temp: 70°C
Forward voltage drop: 1V typ @ If =1A
Leakage current: 1mA
RF600T LOW POWER RADIO TRANSCEIVER the RF600T pro- CMOS OP-AMPS A range of CMOS op-amps in single, dual and
vides a simple interface between TTL level asynchronous serial quad versions.
data sources and standard RF modules (transceiver, transmitter or
Technical specification
receiver). The device allows for either broadcast or addressed
Device Description Manuf Package
point-to-point modes of operation and is simple to use with mini- TLC271 Single programmable op amp Texas DIL8
mum interface requirements. Incorporates a 190 byte data buffer. ICL7611DCPA Single low power CMOS Harris DIL8
Housed in a 18-pin PDIP package. ICL7650SCPD Single chopper stabilised CMOS Harris DIL14
LMC662CN Dual CMOS National DIL8
TLC27L4CN Quad precision Texas DIL8
LMC660CN Quad CMOS National T092
CODE TYPE PRICE
750-218 IC TLC271 Op Amplifier (DIL8)....................................... £1.00
750-220 IC LMC660CN Op Amplifier (DIL8)............................... £2.45
750-224 IC LMC662CN Op Amplifier (DIL8).............................. £2.99
CODE TYPE PRICE 750-228 IC ICL7611DCPA Op Amplifier (DIL8)........................ £1.50
25-0140 Low Power Radio Transceiver RF600T................ £8.99 750-236 IC TLC27L4CN Op Amplifier (DIL8)............................ £2.45
Technical Specification
Supply voltage 15V (13V to 16V)
Supply current 1.5mA
Input inhibiting time 100ns
Propagation delay 400ns max CODE TYPE Voltage PRICE
Output drivers Vsod 3V 702-000 Voltage Regulator 100mA 78L05 +5V................ £0.50
Vsid 5V 702-005 Voltage Regulator 100mA 78L12 +12V.............. £0.50
Vdem 2V 702-010 Voltage Regulator 100mA 78L15 +15V.............. £0.50
Pull up resistor 47kΩ 702-015 Voltage Regulator 100mA 79L05 -5V................ £0.60
CODE TYPE PRICE 702-020 Voltage Regulator 100mA 79L12 -12V.............. £0.65
750-304 TD300IN Triple IGBT/MOS Driver............................... £2.45 702-025 Voltage Regulator 100mA 79L15 -15V.............. £0.65
-
CODE TYPE VOLTAGE PRICE VARIABLE VOLTAGE REGULATORS a range of variable voltage
702-040 Voltage Regulator 1A 7805 +5V......................... £0.65 regulators with output current limiting in addition to thermal protec-
721-700 Voltage Regulator 1A 7808 +8V......................... £0.75 tion.
702-045 Voltage Regulator 1A 7812 +12V....................... £0.65
702-050 Voltage Regulator 1A 7815 +15V....................... £0.65
721-702 Voltage Regulator 1A 7818 +18V....................... £0.85
721-704 Voltage Regulator 1A 7824 +24V....................... £0.85
702-055 Voltage Regulator 1A 7905 -5V......................... £0.75
721-706 Voltage Regulator 1A 7908 -8V......................... £0.75
702-060 Voltage Regulator 1A 7912 -12V....................... £0.75
721-710 Voltage Regulator 1A 7924 -24V....................... £0.99
ADJUSTABLE PRECISION SHUNT REGULATOR TL431CLP 1A BUCK VOLTAGE REGULATOR LM2575 a monolithic 1A
The TL431 is a three terminal adjustable shunt regulator with guar- step-down (buck) voltage regulator that is a high efficiency
anteed thermal stability over applicable temperature ranges. The replacement for the more conventional 3-pin linear regulators.
output voltage may be set to any value between VREF (approx. These devices require a minimum number of external components
2.5V) and 36V with two external resistors. The device has a typi- and are simple to use. The design substantially reduces the size
cal output impedance of just 0.2Ω . Active output circuitry provides of heatsink required and in many cases, no thermal management
a very sharp turn on characteristic, making these devices excellent is required as dissipated power is low. Applications for these
replacements for zener diodes in devices include simple high efficiency buck regulator, pre-regula-
many applications. Sink current tion for linear regulators, on-card switching regulators and positive
capability is1mA through to 100mA. to negative conversion (buck-boost). It has an external shutdown
Housed in a T092 style package. facility, low power standby mode and thermal shutdown and cur-
rent limit protection. Guaranteed 1A output and output voltage tol-
CODE TYPE PRICE erance of ±4%. Supplied in a 5-pin TO-220-5 package.
701-410 Adj Prec Shunt Reg TL431CLP............................ £0.50