Professional Documents
Culture Documents
Page 1|6
M.M. Murtada sabih Soil Mechanics Laboratory
7. Procedure
7.1 Place the specimen in the loading device so that it is centered on the bottom
platen. Adjust the loading device carefully so that the upper platen just makes contact
with the specimen. Zero the deformation indicator. Apply the load so as to produce
an axial strain at a rate of 1⁄2 to 2 %/min. Record load, deformation, and time
values at sufficient intervals to define the shape of the stress-strain curve (usually
10 to 15 points are sufficient). The rate of strain should be chosen so that the time to
failure does not exceed about 15 min (Note 7). Continue loading until the load
values decrease with increasing strain, or until 15 % strain is reached. Indicate
the rate of strain in the report of the test data, as required in 9.1.7. Determine the
water content of the test specimen using the entire specimen, unless representative
trimmings are obtained for this purpose, as in the case of undisturbed specimens.
Indicate on the test report whether the water content sample was obtained before or
after the shear test, as required in 9.1.2
7.2 Make a sketch, or take a photo, of the test specimen at failure showing the
slope angle of the failure surface if the angle is measurable.
Page 2|6
M.M. Murtada sabih Soil Mechanics Laboratory
Page 3|6
M.M. Murtada sabih Soil Mechanics Laboratory
ملخص التجربة:
-1الهدف من التجربة ايجاد مقاومة االنظغاط للتربة وتماسك التربة
-2نوع الفحص هو مقاومة انظغاط للتربة بحيث تكون عينة التربة غير مقيدة
-3التربة في هذة الحالة التحتوي على ظغط ماء النها غير مقيدة
-4يتم اخذ عينة اسطوانية (تربة طينية رطبة) الشكل من الموقع ثم تحول الى اسطوانة صغيرة ناخذ قطرها
وطولها.
-5يتم تثبيت العينة بجهاز الفحص ثم يصفر عداد قراءة التغير بالطول.
-6يتم تسجيل الزمن لكل تغير بالطول او يتم تثبيت قراءات الجهاز بالجدول مسبقا ويتم تسجيل الحمل لكل
قراءة مسجلة.
-7في المثال ادناه تم تثبيت القراءة كل 25مثال اول قراءة 25والثانية 75والثالثة 100ثم نضرب كل رقم
بثابت الجهاز 0.01اي 25ضرب 0.01يساوي 0.25ملم وهذا الرقم 0.25ملم هو التغير بطول العينة.
-8نسجل من الجهاز الحمل مقابل كل تغير بالطول ونحسب ايضا االنفعال ونحسب مساحة العينة المصححة
ثم نحسب االجهاد.
-9نرسم عالقة بين االنفعال كنسبة مئوية حسب ماذكر بالمواصفة االمريكية اعاله الفقرة الثامنة ونحسب من
المخطط اكبر اجهاد او الذي يقابل %15انفعال ايهما يقع اوال.
-10يتم ايجاد كثافة التربة الرطبة بقسمة الوزن على حجم العينة (التي في الجهاز) ويتم اخذ المحتوى المائي
لحساب الكثافة الجافة.
Page 4|6
M.M. Murtada sabih Soil Mechanics Laboratory
the relationship
between compressive stress (ordinate) and axial strain
1.20
1.00
Axial Stress kg/cm2
0.80
0.60
0.40
0.20
0.00
0.00 1.00 2.00 3.00 4.00 5.00 6.00 7.00 8.00 9.00 10.00 11.00 12.00 13.00
Axial Strain (%)
l=7.5cm
d=3.75 cm Ac=11.04cm2
dial reading deformation �𝜀=ΔL/L % Ac=A/1-(𝜀/100) (cm2) axial load kg compressive stress kg/cm2
25.00 0.25 0.33 11.08 0.64 0.06
50.00 0.50 0.67 11.11 1.28 0.12
75.00 0.75 1.00 11.15 1.86 0.17
100.00 1.00 1.33 11.19 2.32 0.21
125.00 1.25 1.67 11.23 2.84 0.25
150.00 1.50 2.00 11.27 3.26 0.29
175.00 1.75 2.33 11.30 3.78 0.33
200.00 2.00 2.67 11.34 4.00 0.35
225.00 2.25 3.00 11.38 4.28 0.38
250.00 2.50 3.33 11.42 4.66 0.41
275.00 2.75 3.67 11.46 5.08 0.44
300.00 3.00 4.00 11.50 5.52 0.48
325.00 3.25 4.33 11.54 5.88 0.51
350.00 3.50 4.67 11.58 6.30 0.54
375.00 3.75 5.00 11.62 6.72 0.58
400.00 4.00 5.33 11.66 7.10 0.61
425.00 4.25 5.67 11.70 7.56 0.65
450.00 4.50 6.00 11.74 8.00 0.68
475.00 4.75 6.33 11.79 8.52 0.72
500.00 5.00 6.67 11.83 8.86 0.75
525.00 5.25 7.00 11.87 9.12 0.77
550.00 5.50 7.33 11.91 9.48 0.80
575.00 5.75 7.67 11.96 9.72 0.81
600.00 6.00 8.00 12.00 10.00 0.83
625.00 6.25 8.33 12.04 10.30 0.86
650.00 6.50 8.67 12.09 10.52 0.87
675.00 6.75 9.00 12.13 10.80 0.89
700.00 7.00 9.33 12.18 11.00 0.90
725.00 7.25 9.67 12.22 11.32 0.93
750.00 7.50 10.00 12.27 11.58 0.94
775.00 7.75 10.33 12.31 11.84 0.96
800.00 8.00 10.67 12.36 12.16 0.98
825.00 8.25 11.00 12.40 12.50 1.01
850.00 8.50 11.33 12.45 12.82 1.03
875.00 8.75 11.67 12.50 13.12 1.05
900.00 9.00 12.00 12.55 13.34 1.06
Page 5|6
M.M. Murtada sabih Soil Mechanics Laboratory
Page 6|6