Professional Documents
Culture Documents
API 510 Question Bank - 1 (API 510 QB001) (Closed Book) : A. B. C. D. 2. A. B. C. D
API 510 Question Bank - 1 (API 510 QB001) (Closed Book) : A. B. C. D. 2. A. B. C. D
(Closed Book)
4. In thickness formula for internal pressure for shell, term ‘E’ refers to:
a. Modules of Elasticity of material
b. Thermal Expansion
c. Joint efficiency of the weld
d. None of above
d. None of above
11. ASME Sec VIII Div. 1 specifies different acceptance level for weld reinforcement,
which of the following statements are true in your opinion?
a. Permitted reinforcement for long. seems is higher than
circ. seems
b. Permitted reinforcement for long. seems is lower than circ.
seems
c. Permitted reinforcement for long. seems is same as circ.
seems
d. Permitted reinforcement does not depend on location of
seems.
14. A Pressure Vessel is designed for 0.85 joint efficiency with full
penetration welds. RT requirement will be:
a. Nil
b. Spot
c. 100 %
d. T-joints radiography
16. If there is a conflict between ASME VIII & API 510 Code,
for vessels in-service:
a. ASME will precedent
b. API will precedent
c. ASNT will precedent
d. Owner user will decide
17. Two head to shell joints, one joining a seamless Hemisph, head to
shell was radiographed for full length and the other joint joining
seamless std. torisph. head to shell was spot radiographed, The
weld joint efficiency for each of these heads respectively will be:
a. 1, 0.85
b. 1, 1
c. 0.85, 1
d. 0.85, 0.85
18. ASME Sec. VIII Div. 1 recommends use of U.T. in place of R.T. (for a
fully radiographed vessel) for:
a. All butt welds in vessel
b. All butt and fillet welds in vessel
c. For closing seams only
d. The code does not permit use of U.T. at all
19. Vessel MAWP for tall vertical vessel will normally be:
a. Greater than vessel part MAWPs
b. Lower than Vessel part MAWPs
c. May be (a) or (b) depending on Vessel height
d. Is always same as vessel design pressure
ANSWER KEY
Q.
ANSWER REFERENCE
NO.
1 B ASME VIII, UW – 3 (a)
2 D ASME VIII, UG – 98 (a)
3 B ASME VIII, UG – 27 (a), UG -16 (e)
4 C ASME VIII, UG – 27 (a)
5 C Body of Knowledge, 3 (a), Page 2
6 C API 510, 3.2
7 A API 510, 1.1
8 D ASME VIII, UW – 3 (a) (1)
9 A ASME VIII, UG – 32, d, e, f
10 A ASME VIII, Fig. UW - 9
11 B ASME VIII, UW - 35
12 A ASME VIII, UG – 98 (a)
13 D General Knowledge
14 B ASME VIII, Table UW - 12
15 C ASME VIII, UW – 32 (j)
16 B API 510, 3.2
17 B ASME VIII, UW – 12 (d)
18 C ASME VIII, UW – 11 (a) - 7
19 B ASME VIII, 98 (a)
20 C ASME VIII, UG – 116 (e)