You are on page 1of 13

Classification of well completion

? What is the basic cratira for well completions

INTERFACE BETWEEN MODE OF NUMBER OF ZONES


RESERVOIR/WELLBORE PRODUCTION COMPLETED

? What is the rule of completion engineer

meet
the safety and
targeted respect for manage
completion
of the operating
engineer
costs.
producti environmen
on/injecti t;
on rates;
Classification of wells due to the INTERFACE BETWEEN
? RESERVOIR/WELLBORE

VERTICAL OR
HIGHLY
DEVIATED WELLS

HORIZONTAL
WELLS

Type of well completion in VERTICAL OR HIGHLY


? DEVIATED WELLS

PERFORATED uncemented PERFORATED


PROD CASING liner PROD LINER open hole
? What is open hole completion
A well completion that has no casing or liner set across
the reservoir formation, allowing the produced fluids to flow directly into the
wellbore

? What is the advantages and dis advantages of open hole completion

Diameter productive largest of the


well
Able control
to properties The possibility of deepening the
well easily
of drilling mud
The possibility to change this type
to reduce the to other types of completion
degree of
There is not extra cost because
damage of cementing , casing and
perforated.

Disadvantages
? Types UNCEMENTED LINER completion

Wire Pre-
Slotted Gravel
Wrapped packed
Liner Pack
Screen Screen

Where liner type of completion is primarily applied for


?completion of the well
Liner Completions are designed for production in an area that contains a large amount of
 .loose sand

? What is the slotted liner completion


a liner with a short length of slotted is hung in the open hole interval to minimize  
sloughing of the formation into the well bore The slots or wire wrapped pipe prevents
.sand from entering the well bore

? What is the gravel pack


.A sand-control method used to prevent production of formation sand
PERFORATED CEMENTED LINER COMPLETIONS ? what is
In perforated cemented liner completions, the casing is set above the intended
productive interval, and the latter then drilled. A liner is cemented in place which is
subsequently punctured (perforated)
? Classification Of Completions By Mode Of Production

FLOWING
SINGLE STRING

ARTIFICIAL LIFT

? Classification of FLOWING SINGLE STRING by mode of production

Tubingless
Low
Pressure,
Temporary
High
Pressure,
Long Term
High Rate
Liner
Internal Casing Gravel packs ? what is
in case of Internal Casing Gravel Packs, the fluid should
absolutely enter inside the formation to fill up the gravel perforation tunnels
.and make them efficient

? What Is The Different Type Of Packer

Permanent Packers
Permanent / Retrievable
(Permatrieve ) Packers
Retrievable Packers

What is the Retrievable Packer


? Wireline Nipple
It is a packer which, after setting, can be retrieved

? What is no – go nipple
no-go landing nipple is run at bottom of wellbore typically to hang
gauges.

Lock mandrel passes through selective landing nipple but will stop in
no-go landing nipple since lock mandrel has larger OD than no-go
.landing nipple’s ID
? What is the type of artificial lift

ESP
GAS LIFT
PLUNER LIFT
HYDRAULIC PUMP
ROD PUMP

?Classification Of Completion By Number Of Zone

single zone

A single tubing string is run in hole and a single packer is fixed at the end ofstring, just
on top of the productive zone,

multiple zone

Designed to selectively produce from more than one producing formation

dual completion

Designed to selectively produce from more than one producing formation


The Process Of Making A Well Ready For Production (Or
Injection) Is Called
A) Well Completion
B) Workover
C) Well Stimulation
D) None Of The Above

Well Completion Depends On


A) Well Production Strategy
B) Interface Between Wellbore And Reservoir
,C) Number Of Tubing Strings
D) All Of The Above

Which Of The Completion Has Less Degree Of Control


? Over Desired Productive interval
A) Open Hole Completion
B) Cased Hole Completion
C) Both (A) And (B)
D) None Of The Above
Which Completion Cannot Be Completed In Layered
Formation Of Separate Reservoirs With Incompatible
?Fluid Properties

A) Open Hole Completions


B) Perforated Casing Completions
C) Both (A) And (B)

Which Of The Following Is Most Suitable For A Low


Pressure Reservoir With Unconsolidated Heavy Oil
?Sand
A) Open Hole Completion
B) Perforated Casing Completion
C) Uncemented Liner Completion
D) None Of The Above
Which Of The Following Advantages Are Associated
?With Uncemented Liner Completion

A) Less Formation Damage


B) Log Interpretation Is Less Complicated
C) Deepening The Well Can Easily Be Carried Out
D) All Of The Above

?Which Of The Following Is True About Packer


A) It Provides A Seal Between The Tubing And The Tubing Casing
Annulus
B) It Protect Casing As Well As Prevent Excessive Tubing Movement
C) It Isolates The Producing Intervals
D) All Of The Above
Which Of The Following Statement Is True About The Advantages Of
Perforated
?Casing Completion
A) Gas Or Water Production Can Be Controlled Easily
B) Can Be Selectively Stimulated
C) Adaptable To Multiple Completion Techniques
D) All Of The Above

?Which Of The Following Is True About Monobore Completion


A) It Can Be Used For Smaller And Marginal Field Development
B) It Is Difficult To Achieve A Good Cementing Job
C) It Can Lead To Corrosion Of Casing Due To Fluids Being Exposed
To The Casing
D) All Of The Above

What Are The Limitations Of Single String - Multiple


?Packers Multiple-Zone Completion

A) Monitoring Flow From Individual Zones Is Difficult


B) Difficulty Of Treating Or Re-Perforating Individual Zone Unless
Well Is Killed And Tubing Is Pulled
C) Both (A) And (B)
D) None Of The Above
Which Of The Following Is True About Horizontal And
?Multilateral Well Completion
A) These Completions Can Be Suitable In Improving The Productivity
From The Thin
.Reservoirs
B) These Completions Improve Recovery In Tight Low Permeability
Zones
C) Both (A) And (B)
D) None Of The Above

You might also like