Professional Documents
Culture Documents
Design Half Wave Verification of all the Some minute errors Partial verification of With no or minimal
Rectifier with necessary results. in results’ its functionality results.
Inductive Load (04) verification
Analyze Effect of Verification of all the Some minute errors Partial verification of With no or minimal
freewheeling diode necessary results. in results’ its functionality results.
(03) verification
*CLO-02 (PLO-09)
Safety, Equipment Full attention to relevant Required attention Some attention and Did Not follow
and Material (1) safety procedures & and returned all had to be reminded directions and safety
directions. materials to clean up area and precautions. Had to
Returned all materials appropriately. equipment; and to be asked again and
appropriately and return materials. again to return
responsibly. materials
*CLO-01(PLO-04)
Lab Report (5) Write precisely and Write about 80% of Write about 50% of Cannot write or less
correctly about waveform waveform & review waveform & review than 50 %.
& answers all review questions. questions.
questions.
*CLO-01(PLO-04)
Viva (5) The related questions are Student partially Student partially able Does not answer any
fully answered. able to answer to answer simple questions.
complex/difficult question(s).
question(s).
Experiment No. 01
Single Phase Diode Rectifier with Inductive Loads
Pre Lab Reading
Chapter 3 of Power Electronics: Circuits, Devices and Applications, by M. H. Rashid (4e).
Objectives
Analyze the working and performance of a single phase rectifier on Multisim.
Observe the effect of inductive load on working of a rectifier.
Observe the effect of freewheeling diode on working of a rectifier.
Theory
When a single rectifier diode unit is placed in series with the load across an ac supply, it converts
alternating voltage into uni-directional pulsating voltage, using one half cycle of the applied voltage, the
other half cycle being suppressed because it conducts only in one direction. This is called half-wave
rectification.
Observations:
Using the waveforms displayed on oscilloscope draw the following with
proper scaling of both axes (Draw at least two cycles).
Input Voltage Waveform
Observations:
Observations:
Lab Report
Review Questions
2. How can we reduce the ripple content in waveform? Explain the purpose of free wheeling
diode.