Professional Documents
Culture Documents
reviewer4@nptel.iitm.ac.in ▼
How to access 1) The individual gas-phase mass transfer coefficient ky has the same unit as 2 points
the portal
(a) diffusivity
Pre-Requisite
Assignment (b) molar concentration
Week 03: Mass 2) Which one of the following is a probable value of the mass transfer coefficient kL for the 2 points
transfer dissolution of small KCl crystals in water in an agitated vessel?
coefficient and
interface mass (a) 0.005 mm/s
transfer
(b) 0.02 mm/s
Week 04: Mass (c) 2 m/s
Transfer
Coefficient & (d) 5 m/s
Interphase Mass
Transfer No, the answer is incorrect.
Score: 0
Lecture 1:
Mass Transfer Accepted Answers:
Theories (b) 0.02 mm/s
Lecture 2: 3) Absorption of oxygen from air in water is liquid-film resistance controlled. What will happen 2 points
Interphase to the controlling resistance if oxygen from air is absorbed in a strong solution of alkaline pyrogallate?
Mass Transfer The controlling resistance will be offered by
Lecture 3:
Interphase (a) the gas phase
Mass Transfer
© 2014(b)
NPTEL - Privacy
the liquid & Terms - Honor Code - FAQs -
phase
and Material
A project of
Balance for In association with
(c) both the gas and liquid phases
Operating Line
(d) none of the above
Lecture 4:
Number of No, the answer is incorrect. Funded by
Ideal Stages in Score: 0
Quiz :
Assessment 04
Solution:
Assessment 04
Week 05:
Equipment for
Gas-Liquid
Operations
No, the answer is incorrect.
Score: 0
Week 06:
Absorption -I Accepted Answers:
Week 07:
Absorption -II
5) The equilibrium relations for the gas-liquid pairs A-C and B-C (A and B are solutes; C is 0 points
the solvent) follow the Henry’s law: pA = HAxA and pB = HBxB, HA>HB at the same temperature. If the
Week 08:
Distillation -I individual solubilities of the gases at the same temperature and pressure are SA and SB lmol/m3 , then
Interaction
Session
Week 09:
Distillation - II
Week 10:
Distillation - III
No, the answer is incorrect.
Week 11: Score: 0
Distillation - IV
Accepted Answers:
Text Transcripts
Week 12:
Distillation - V 6) For the absorption of a certain gas from an air stream into water the overall mass transfer 5 points
coefficient in the gas phase, KG = 10-3 kmol/(m2 s kPa) and 15% of the total resistance lies in the liquid
phase. Given that: T = 300 K, molecular weight of gas = 36, H = 0.3 kPa m 3/kmol. What is the value of
liquid phase mass transfer coefficient?
7) In a refinery off gas stream it is desired to remove 98% of component A from streams 0 points
containing 10% A. The feed enters in the bottom of A column at a flow rate of 4000 kg/h. The pure
solvent is fed at the top of the column at a rate of 4000 kg/hr. Determine the number of trays required.
The equation relation is linear. Y=1.5X
(a) 23
(b) 33
(c) 43
(d) 53