Professional Documents
Culture Documents
SESI 1: 2021/2022
INSTRUCTION:
This paper consists of TWO (2) structured questions. Answer ALL questions.
ARAHAN:
Kertas ini mengandungi DUA (2) soalan berstruktur. Jawab SEMUA soalan.
QUESTION 1
SOALAN 1
CLO 1
C2
Figure 1a / Gambarajah 1a
(a) Based on the Figure 1a, determine
i. the reading on the ammeter
ii. the value of resistor, R2
iii. the circuit power
[4 marks]
Merujuk kepada Gambarajah 1a, tentukan
i. Bacaan bagi meter ampere
ii. Nilai bagi perintang R2
iii. Kuasa bagi litar
[4 markah]
2 SULIT
SULIT DJJ20053: ELECTRICAL TECHNOLOGY
Figure 2b / Gambarajah 2b
(b) Refer to the Figure 2b, using the Ohm’s Law, and Current Division
calculate:
i. Total resistance
3 SULIT
SULIT DJJ20053: ELECTRICAL TECHNOLOGY
CLO2
C3
250V 50Hz
Merujuk kepada litar RLC pada Rajah 3(a), dapatkan nilai-nilai berikut.
i. Galangan litar
ii. Arus litar
iii. Voltan susut pada VR, VL dan VC
iv. Sudut fasa
v. Faktor kuasa
.
[13 markah]
4 SULIT
SULIT DJJ20053: ELECTRICAL TECHNOLOGY
QUESTION 2
SOALAN 2
(a) Draw the auto transformer;
i. Step up
CLO1 ii. Step down
C2
[6 marks]
(b) A mild steel ring has a radius of 60mm and a cross sectional area of 500mm².
A current of 0.3A flows in a coil wound uniformly around the ring and the
CLO2
C2 flux produced is 0.01mWb. If the relative permeability is 300. Calculate
i. Flux density, B
ii. Reluctance of the mild steel,S
iii. Number of turns on the coil, N
[7 marks]
Gelang keluli lembut mempunyai jejari 60mm dan luas keratan rentas
500mm². Arus 0.3A mengalir dalam gegelung dililit secara seragam di
sekeliling cincin dan fluks yang dihasilkan ialah 0.01mWb. Jika
kebolehtelapan nisbi alah 300. Kira
i. Ketumpatan fluks, B
ii. Keengganan keluli lembut,S
iii. Bilangan lilitan pada gegelung, N
[7 markah]
5 SULIT
SULIT DJJ20053: ELECTRICAL TECHNOLOGY
(c1) A single phase transformer has a voltage ratio of 6:1 and high voltage
winding is supplied at 540V. The secondary winding provides a full load
CLO2 current of 30 A. Neglecting losses, determine:
C3
[6 marks]
Pengubah fasa tunggal mempunyai nisbah voltan 6:1 dan lilitan voltan tinggi
dibekalkan pada 540V. Lilitan sekunder menyedikan arus beban penuh30A.
Abaikan kehilangan, Kirakan:
i) Voltan sekunder, V2
ii) Kuasa pada beban, P2
iii) Arus primer, I1
iv) Terangkan jenis pengubah
[6 markah]
(c2) The frequency of the supply to the stator of 8-poles induction motor is 50 Hz
and the Rotor frequency is 3 Hz. Determine;
CLO2
C3
i) Synchronous speed. Ns
ii) Percent of slip, %s
iii) Rotor speed, Nr
[6 marks]
6 SULIT
SULIT DJJ20053: ELECTRICAL TECHNOLOGY
[6 markah]
SOALAN TAMAT
7 SULIT