Professional Documents
Culture Documents
Q.4 (a) In a regulated fly-back converter with a 1:1 turns ratio, Vo=12V, Vin is 12-24 V, Pload is 2.5
6W-60W, and the switching frequency (fs)=200kHz. Calculate the maximum value of the
magnetizing inductance Lm that can be used if the converter is always required to operate
in complete demagnetization (equivalent to dcm) mode.
(b) Determine and sketch all the steady-state 2.5
waveforms for the full-bridge converter of
Fig. Q.4b with the following specifications:
Vin =12 V, Vo = 2 V, (n1/n2) = 5, Po =75 W,
fs = 170 kHz, and L = 0.15 μH.
Fig. Q.4b
Q.5 (a) Draw circuit diagram and design all power circuit components of DSTATCOM OR 4
DVR (Assume suitable data as load rating 60kVA, 0.8 power lagging in case of
DSTATCOM and supply voltage sag and swell 28% with 6% unbalanced in case of DVR)
(b) Explain limitation of IEEE 519 standards. Also give reason of neutral current in case of 3
linear and nonlinear loads.
(c) Write name of any five power quality problems and terms. Also explain their effect in 3
distribution system.
OR
Explain types of current mode controls used in dc/dc converter. Also write main advantage
of this mode
-----------* Best of Luck *-------------