Professional Documents
Culture Documents
ASSIGNMENT #2
Note:
➢ Complete this assignment and submit by the due date and time.
➢ Late assignments will not be accepted
Page 1 of 6
Engineering Drawing MEB1063 January 2022 Semester
1. DRAWING REQUIREMENTS
A. Using AutoCAD software, draw the required orthographic views of the objects
shown in the attached Figures and save as ID_QNo.dwg. For example, if your ID
is 1234 and you are working on question number 1, save as 1_1234_Q1.dwg.
B. Create proper layout with complete title block and plot on PDF. Save your file as
Group no_ID_QNo.pdf (1_1234_Q1.pdf.)
C. Use indicated projection system. For information on the placement of orthographic
views, refer to the lecture notes on orthographic projection.
D. Centre the required views within the work area. Allow nearly equal space between:
• views
• views & borders.
E. Label the views appropriately. Unlabeled views will not be considered for marking.
F. Fully dimension the views.
G. Use a drawing sheet size, which is appropriate to your drawing - consider the
object dimensions, the drawing SCALE, the space between views and, margins
you want to leave.
H. Drawings should conform to the given SCALE.
I. All drawings should conform to ISO drawing standards.
J. Any construction/projection lines must be turned off in the layer before submitting
the drawings.
K. Written information on drawings:
Page 2 of 6
Engineering Drawing MEB1063 January 2022 Semester
A. The dimensions, as shown in the given figures, are enough to provide complete
size description of the given objects.
B. Correctly indicating the given dimensions on orthographic views would fulfil the
dimensioning requirements for this assignment. All the given sizes must appear on
your drawings. For rules and guidelines, refer to lecture notes on dimensioning
and tolerancing.
4. ASSUMING SIZES
A. Carefully review the given sizes. You don’t need to assume any sizes. Get it
clarified if not sure.
B. If depth is not shown, it will be a through hole.
6. MARKING
A. To get marks for your drawings, the line types, projection system, and drawing
scale must be correct. Incorrect use of any of these items will lead to low marks.
B. Indicating correct and complete dimensions is essential to get more than 25%
marks. The drawings shall demonstrate correct understanding and application of
good dimensioning practices.
C. To gain more than 50% for this assignment, besides being correct, the drawings
must be complete in all aspects and professionally presented.
Page 3 of 6
Engineering Drawing MEB1063 January 2022 Semester
D. A drawing, which includes all views of an object, will attract no marks if it contains
too many errors.
E. Use Third Angle of projection for both drawings.
Page 4 of 6
Engineering Drawing MEB1063 January 2022 Semester
QUESTION - 1:
Draw the necessary views, with a HALF SECTION VIEW for stock guide shown in Figure
Q1.
Figure Q1
Page 5 of 6
Engineering Drawing MEB1063 January 2022 Semester
QUESTION - 2:
Draw necessary orthographic views and a FULL SETION VIEW for the part shown in
Figure Q2.
Figure Q2
Page 6 of 6