You are on page 1of 6

TUTORIAL SHEET 2

Q1. Using Superposition Theorem, find the current I in 3Ω resistance.

Q2. Obtain the Thevenin and Norton equivalent circuits at terminals a-b of the circuit.

Q3. Obtain the Thevenin and Norton equivalent circuits at terminals a-b of the circuit.
Q4. Use the superposition principle to find io and vo in the circuit.

Q5. Find the node voltages in the circuit.

Q6. For the given circuit, find the Thevenin equivalent across the terminal A and B
Q7. Find the Thevenin equivalent of the circuit at terminals a-b.

Q8. Determine V0 in the circuit shown

Q9. Determine the effective value of the waveform of Figure

Q10. The impedance looking into nodes 1 and 2 in the given circuit using Thevenin Theorem
Q11. Solve for the currents through R2 and R3 in the circuit of following figure:

Q12. Determine the nodal voltages for the circuit shown in Figure:

Q13. Find the Thevenin equivalent circuit of the indicated area in the given Figure. Using the equivalent circuit,
determine the current through the load resistor when RL  0, RL  2 K  , and RL  5KΩ .

Q14. Using nodal analysis, find and in the circuit of the following Fig.
Q15. Find the Thevenin equivalent between terminals of the circuit in the following Fig.

Q16. Use mesh analysis to find the current I0 in the circuit

Q17. If VA +VB = 6V then VC –VD is

Q18. Find i for the given circuit


Q19. Find the voltage Vx in the given circuit

You might also like