Langkah Kerja :

1. Persiapan tools dan material

2. Buka Cover manhole casing
3. Membuka Turbine Supervisory
4. Membuka Turning Gear
5. Check Alignment Coupling Turbin / Generator
6. Angkat Front Pedestal
7. Lepas Oil Seal Turning Gear
8. Lepas Cover Bearing No 1 dan 2
9. Lepas Cover Coupling T/G
10. Run Out Check
11. Lepas Baut Coupling T/G
12. Alignment
13. Lepas Baut Casing
14. Pasang Cover Manhole
15. Angkat Upper Casing
16. Membalik Upper Casing
17. Angkat Upper Casing MOP
18. Lepas Seal Ring MOP
19. Angkat Upper Bearing No 1 dan 2
20. Lepas Thrust Bearing
21. Lepas Oil Buffle sisi Gen dan Gov
22. Angkat Rotor
23. Angkat Upper dan Lower Diaphragm
24. Angkat Lower Bearing
25. Cleaning Rotor
26. Cleaning dan NDT Bearing
27. Cleaning dan NDT Thrust Bearing
28. Cleaning lower dan upper casing
29. Cleaning upper dan lower gland seal steam
30. Cleaning baut dan part
31. Pasang Gland seal steam
32. Check cleaning drain catcher
33. Cleaning horizontal face upper dan lower casing
34. Pasang upper dan lower Diaph tk. 1 s/d 6
35. Membalik Upper Casing
36. Pasang lower bearing
37. Check clearance sroud rotor dan packing
38. Install Rotor temporary
39. Angkat kembali rotor dan periksa lead wire
40. Install Rotor
41. Pasang Upper bearing 1 dan 2
42. Check Clearance bearing terhadap rotor
43. Ukur Clearance axial dan radial rotor
 44. Pasang oil buffle
45. Pasan Lead wire
46. Pasang upper casing
47. Angkat kembali casing dan cek lead wire
48. Pasang kembali upper casing
49. Pasang dan kencangkan baut casing
50. Pasang cover bearing 1 dan 2
51. Pasang seal ring dan cek clearance
52. Alignment Coupling Turbine dan Generator
53. Rapatkan coupling dengan 4 baut terpasang
54. Pasang baut coupling sesuai nomor
55. Kencangkan mur dengan cara menyilang
56. Lakukan run out check
57. Pasang cover coupling T/G
58. Pasang Turning Gear
59. Pasang Oil Seal Turning Gear
60. Pasang Front Pedestal
61. Cleaning Area

Tools

- General Tools
- Lifting Tools
- Measurement Tools

Man Power

Teknisi 3 Orang

Astek 8 Orang