Professional Documents
Culture Documents
[Meaning] When E/L speed, during high-speed running, exceeds 120% of rated [Actions to take]
speed because of abnormally increased 1st frequency command.
This abnormal increasing is chiefly caused by Speed CPU error.
(This error is detected before governor operation.) 1. Check E/L speed
Measure E/L speed by means of a tachometer.
[Explanation] 1) At normal, the speed is [Rated Speed]± value.
2) At abnormal, replace DOC-200 PCB.
[Meaning] When E/L speed continues to be as 1.4 times as the rated speed for [Actions to take]
160 msec. during low-speed running or to be 20m/min or more for 160m
sec. during ALP running. (The velocity of low-speed running is specified in
SPEC.)
1. Check E/L speed.
[Explanation] 1). Measure E/L speed by means of a tachometer.(All by 15 m/min)
2). Check the speed obtained from Run CPU and Speed CPU by
inputing ‘A87E’ on ANN.
3). If any error is detected though item 1) is normal, speed detection circuit
FAST_RUN_ PCC_LOW- is judged to be failed.
OS_C1BR COMMAND SPEED PCC_ATPE RUNNING
-Check the speed detection circuit of R/E,DOC-200 PCB.
-Check the pulse counter circuit of R/E,DOC-200 PCB.
530DH 5590H 5822H 58A3H 558FH If item 1) and 2) are judged to be normal, speed control circuit is
judged to be inferior.
- Check DPC-1XX, DPP-XXX, and DOC-200 PCB.
- Check IGBT.
PCC_ALP_RUN_ *ALP_Defeat & ALP_ - Check DOC-200 PCB SPEC ROM DATA.
ZAINV PERMIT OVER_SPEED_ERR
SLOW-OVER_V_DETECT 2. Check R/E pulse
1).Check ØA and ØB of R/E with oscilloscope.
5601H 5862 15E4H & 10H 31E0H - ØA:40T1/22~40T1/21
- ØB:40T1/20~40T1/19
2) No pulse error and oscillation permitted.
3) Pulse should be produced at a certain interval during low-speed running.
JJH_Velocity>=L_OVER_SPEED_V)
SLOW-OVER_V_DETECT
TCD166
31E1H
※ L-OVER-SPEED=(Control_Spec.Slow_Speed/60*1.4)