Professional Documents
Culture Documents
_________________________________________________________________________________________________________________
SecuriFire
B5-EPI-PCM-GS
Partial Indication and Control Map
The SecuriFire B5-EPI-PCM-GS has 16 red or yellow illuminated
LEDs and 8 keys. The function, colour and actuation behaviour
(static or flashing) of each LED as well as the keys are individually
programmed with SecuriFire Studio. The function of the operation
LED (green) is permanently assigned. Further, the partial indication
and map has an internal audible element and a connection for an
external key switch.
Function/Application Interfaces
The B5-EPI-PCM-GS has 16 two-colour LEDs for state display, a X1 EPI bus connection plug
LED for operation state, 8 function keys, a buzzer, a key for the lamp
X2 Jumper indication and control map audible
test, and a connection for an external key switch.
X4 Key switch connection
The functions of the LEDs, function keys, buzzer and the external S1 Rotary switch EPI bus address
key switch are programmed in SecuriFire Studio.
The device has a robust ABS plastic housing with protection type IP
42.
Key features
16 two-colour yellow/red LEDs.
8 function keys
Up to 3 devices per EPI interface can be connected.
Up to 1 m EPI bus total length
Plug type: 8-pin RJ45
Cable type: Patch cable (Cat 5e or better)
ABS plastic map case with IP 42 protection type
Technical data
Information about programming, please refer to the SecuriFire Stu-
Electrical RS485
dio manual T811093.
Coverage max. 1 m
Transmission type Asynchronous serial, 9.6kbit/s The B5-EPI-PCM-GS is supported beginning with SecuriFire Stu-
Direction Bidirectional, half-duplex dio R 1.2.
Mechanical design 8-pin RJ45 plug
Dimensioned drawing
Indication and control map audible (X2) 138 48
Audible switched on
170
136
Terminal Designation
1 Key +
2 Key -
Technical data 5
Electrical potential-free contact
Coverage max. 1 m
Mechanical design Screw terminal, max. 1.0 mm2
87.5
Fig. 3 Dimensioned drawing B5-EPI-PCM-GS
Rotary switch EPI bus address (S1)
Setting the EPI-BUS address (1 to F)
Connection
The connection of the B5-EPI-FPC can take place on the EPI bus of a SecuriFire MIC or on the EPI bus of an MMI device.
Fig. 6 Connection
Technical data
Power supply The power is supplied to the B5-EPI-PCM-GS by the EPI-BUS
Cable type 0.5 m patch cable cat 5e (included)
Supply voltage +3.3 V ± 5 %
Current consumption 5 mA
Contact protection IP 42
Ambient temperature -5 °C to +50 °C
Relative humidity 5 % to 95 %, without condensation
Air pressure 80 kPa, up to 2’000 m above sea level
Dimensions (H x W x D) 170 x 138 x 48 mm
Housing ABS anthracite grey RAL 7016
Weight xxx g