Professional Documents
Culture Documents
Practical
Code: CS-116
Credit hours: 0+1
Recommended Book:
1. A Textbook of Engineering Drawing: Along with an Introduction to AutoCAD (2015) by Roop Lal, Ramakant Rana
CLO1: Acquire the basic knowledge of drawing skills and CAD drawings by understanding the concept of basic
drawing techniques and use them efficiently (PLO 5).
CLO2: Demonstrate individually the drawing of plan, elevation and cross sections of buildings and machine parts
(PLO 3).
Laboratory Resources: The relevant laboratory is equipped with workbenches and components to facilitate the
experiments outlined in the lab handbook(s) that are periodically updated. A current list of the 16 lab experiments
performed in this course is also attached. The list of software and equipment available is also posted in all labs
and is managed by staff dedicated for this purpose.
CLO2
CLO3
CLO4
Activity Plan
Practical
Course Title: Computer Aided Engineering Drawing
Instructor’s Name: Engr. Nashitah Alwaz
Designation: Lab Engineer
Week Title (s) of Experiment (s) Title (s) of Experiment (s) Course Reason for
No. scheduled performed Learning Incomplete
Outcomes activity (If Any)
1 To understand the brief Covered
introduction of AutoCAD CLO 1 No
software
2 To understand the use of Covered
relative and polar CLO 1 No
coordinates and use of
direct distance with ortho
mode and polar tracking
3 To complete pipe section Covered
using grid and snap
command and to draw CLO 1 No
mounting bracket by using
end point, mid-point and
center object snap
4 To complete a drawing Covered
using From Command CLO 1 No
5 To draw a sink using Covered
rectangle and polygon CLO 1 No
commands
6 To draw a face using Covered
rectangle and circle CLO 1 No
command and polygon
command
NFC Institute of Engineering & Technology, Multan
Department of Electrical Engineering
Attendance/
Unannounced
Viva’s Lab work/note Assignment Project
Quiz
book
2 2 Min 85% 1 1
25 25 50