Professional Documents
Culture Documents
Basis composition Expanded graphite and a Sheet size 1000 x 1000 mm, 2000 x 1000 mm
plain glued stainless steel insert. Per request also available as roll.
Color Grey Thickness 0.6 mm, 0.8 mm, 1.0 mm, 1.5 mm,
2.0 mm, 3.0 mm
Certificates Fire Safe acc. to DIN EN ISO 10497,
BAM tested Tolerances
Thickness: ±5%
Length: ± 5 mm
Width: ± 5 mm
Industry
General industry / Chemical / Oil & Gas / Energy / Pulp & Paper / Marine / Automotive
120
100
3 In area three, do not install the gasket without a
80
technical evaluation.
60
Always confirm the chemical resistance of the
40
gasket to the media.
20
0
-200 -150 -100 -50 0°C 50 100 150 200 250 300 350 400 450
Temperature (˚C)
Tightness performance
The tightness performance graph
1.00E+00
The graph shows the required stress at
Leakage rate (mg/(s x m))
1.00E-01
p = 40 bar
assembling to seal a certain tightness class.
1.00E-02
T = 23 °C
He
The determination of the graph is based on
1.00E-03
EN13555 test procedure which applies 40bar
Helium at room temperature. The sloping curve
1.00E-04
indicates the ability of the gasket to increase
1.00E-05
tightness with raising gasket stress.
1.00E-06
0 20 40 60 80 100
KLINGER® SLS Multi Plus A: small or no attack B: weak till moderate attack C: strong attack
Chlorinated
Paraffinic Motor Motor Mineral Acid Base
Aromates hydrocarbon Alcohol Ketone Ester Water
hydrocarbon fuel oil lubricants (diluted) (diluted)
fluids
A A A A A A A A A A B B
All information is based on years of experience in production and operation of sealing elements. However, in view of the wide variety of possible installation and operating
conditions one cannot draw final conclusions in all application cases regarding the behaviour in gasket joint. The data may not, therefore, be used to support any warranty
claims. This edition cancels all previous issues. Subject to change without notice.
Klinger AG Egliswil
Webereistrasse 1, CH–5704 Egliswil www.klinger-ag.ch
Status: January 2020