Professional Documents
Culture Documents
REFERENCE
SERVI
MAIN
SUB
ITEM DESCRIBTION
HANDBOOK CHAPTER.SECTION TABLE/CHART/FIGURE PAGE IN PDF HANDBOOK
Buildings Classifications 2018 NFPA 101 / Life Safety Code A.3.3.196 … 391-393
2004 CIBSE-Guide G / Public Health Engineering 2.4.4 … 16
GENERAL
Occupancy / # Of People In Buildings/Spaces
2016 ASHRAE 62.1 CH.06 Table 6.2.2.1 15-18
2018 NFPA 101 / Life Safety Code 7.3.1 Table 7.3.1.2 84
2006 SMACNA-Duct Design A … 362-364
EQUATIONS (SI) Air, Fan, Pump, Hydronic Equations 2013 ASHRAE Pocket Guide CH.26 … 319
Carrier-Part1 / Load Estimating INDEX … 162, 163
2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
HVAC Design Strategy CH.02 Fig.2.1 / Table 2.1 79, 80
Refrigerating
HVAC SYSTEM SELECTION / DESIGN STRATEGY HVAC System Selection By ASHRAE 2016 ASHRAE System & Equipment CH.01 … 6-14
HVAC System Selection By SMACNA 1987 SMACNA - HVAC Applications 1.3 Table 1-1 17
HVAC System Selection By Carrier Carrier-Part9 / System And Applications CH.01 Table 2 757
2010 ASHRAE 90.1 A-D Table B3 145
2017 ASHRAE Fundamental CH.14 … 345 (UAE)
Outdoor Conditions (Climate Data)
2006 CIBSE-Guide A / Environmental Design 2.6 Table 2.26 60-63
Carrier-Part1 / Load Estimating CH.02 Table 1 12-19
2017 ASHRAE Fundamental 1.8, 1.9 Fig.1 15, 16
Psychometric Chart/Proccess/Equations (Sensible/Latent Cooling, Sensible/Latent Heating, 2016 ASHRAE System & Equipment 4.1 Fig.2-Fig.7 41, 42
Humidification, De-Humidification, Evaporating Cooling, Chemical De-Humidification) 2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
2.4, A2 Fig 2.35 / Table 2.A2.1 163, 219, 220
Refrigerating
2017 ASHRAE Fundamental 18.6 Table 18 506
2017 ASHRAE Fundamental 25.2 … 716
Construction U-Value (Wall, Roof, Partition)
2006 CIBSE-Guide A / Environmental Design 3.3, 3.4 Table 3.1 97, 100
Carrier-Part1 / Load Estimating CH.05 Table 34 77-80
2017 ASHRAE Fundamental 15.3 Table 4, 10 355, 356, 368-375
2017 ASHRAE Fundamental 18.4 … 485
Glazing U, SC Values
2006 CIBSE-Guide A / Environmental Design 3.6 Table 3.23 - Table 3.31 112-116
HVAC DESIGN
2006 CIBSE-Guide A / Environmental Design 6.3 Table 6.2, 6.3 268, 269
Internal Heat Gain (People/Occupants)
Carrier-Part1 / Load Estimating CH.07 Table 48 100
2018 NFPA 101 7.3.1 Table 7.3.1.2 84
2017 ASHRAE Fundamental 18.2.2 Table 2, 3 474, 475
COOLING & HEATING LOAD ESTIMATION Internal Heat Gain (Light) 2006 CIBSE-Guide A / Environmental Design 6.4 Table 6.2, 6.4, 6.5 269, 270
Carrier-Part1 / Load Estimating CH.07 Table 49 101
2017 ASHRAE Fundamental 18.2.3, 18.2.4 Table 4 - Table 12 476-483
Internal Heat Gain (Equipment/Appliances) 2006 CIBSE-Guide A / Environmental Design 6.5-6.8 Table 6.2, Table 6.6 - Table 6.16 269, 271-278
Carrier-Part1 / Load Estimating CH.07 Table 50 - Table 53 101-105
Internal Heat Gain (Pipes, Ducts, Tanks, AC Motors) Carrier-Part1 / Load Estimating CH.07 Table 54 - Table 60 107-113
2017 ASHRAE Fundamental 18.3 … 483, 484
2017 ASHRAE Fundamental 16.11, 16.13 Table 10, 11 441, 445
2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
Infiltration 1.3 Table 1.5 14
Refrigerating
2006 CIBSE-Guide A / Environmental Design 4.7 Table 4.13 - Table 4.17 160, 161
Carrier-Part1 / Load Estimating CH.06 Table 43, 44 94-96
2011 ASHRAE Application CH.01-CH.33 Design Tables 12-460
Indoor Design Conditions Such As / System Selection, Design Temperature, OA/EX Air
2006 CIBSE-Guide A / Environmental Design 1.4 Table 1.5 13-15
Recirculated, +/- Pressure, Minimum ACH, Humidity, Filtration-MERV, Noise Level / For
(Residential, Hotels, Commercial, Industrial, Educational, Retails, Health Care, Clean 2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
2.3 … 89-124
Rooms, Laboratories, Data Centers, Indoor Swimming Pools/Spa) Refrigerating
Carrier-Part1 / Load Estimating CH.02 Table 5 24, 25
2006 CIBSE-Guide A / Environmental Design 5.10 Table 5.18 201
Diversity Factor
Carrier-Part1 / Load Estimating CH.03 Table 14 40, 41
Carrier-Part5 / Water Conditioning CH.01 CH.01-CH.03 459
Fouling Factor
Carrier-Part5 / Water Conditioning CH.05 Table 11 485
REFERENCE
SERVI
MAIN
SUB
ITEM DESCRIBTION
HANDBOOK CHAPTER.SECTION TABLE/CHART/FIGURE PAGE IN PDF HANDBOOK
Ventilation General Schematic, Equations 2016 ASHRAE 62.1 CH.03, A Table E-1 / Fig.3.1, A1, E1, E2 6, 26, 44, 45
2016 ASHRAE 62.1 CH.05 Table 5.16.1 11
Air Classifications
2006 CIBSE-Guide A / Environmental Design 4.2 Table 4.1 149
Air Intake Minimum Separation Distance 2016 ASHRAE 62.1 CH.05 Table 5.5.1 8
2017 ASHRAE Fundamental 11.4 Table 13 261
Indoor Air Quality / Air Contaminants 2016 ASHRAE 62.1 A Table C1, C2, C3 35-41
2006 CIBSE-Guide A / Environmental Design 4.2, 8.4 Table 4.2, Table 8.2 150, 302
2016 ASHRAE 62.1 CH.06 Table 6.2.2.1 15-18
2016 ASHRAE 62.2 CH.04 Table 4.1 5
Carrier-Part1 / Load Estimating CH.06 Table 45 97
Outdoor Air Ventilation By (Rate)
2006 CIBSE-Guide A / Environmental Design 1.4 Table 1.5 13-15
2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
1.2, 2.3 Table 1.2, 2.9 11, 90
Refrigerating
2017 ASHRAE 170 CH.07, CH.08, CH.09 Table 7.1, 8.1, 9.1 9-13, 17-21, 25-29
Outdoor Air Ventilation By (ACH) 2006 CIBSE-Guide A / Environmental Design 1.4 Table 1.5 13-15
2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
2.3 Table 2.9 90
Refrigerating
2016 ASHRAE 62.1 CH.06 Table 6.5 22
Exhaust Air Ventilation By (Rate) 2016 ASHRAE 62.2 CH.05 Table 5.1, 5.2 7
Carrier-Part1 / Load Estimating CH.06 Table 45 97
2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
Exhaust Air Ventilation By (ACH) 2.3 Table 2.9 90
Refrigerating
VENTILATION RATES (OA, EA, SMOKE) 2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
Tobacco / Smoking Area Ventilation Rates 2.3 Table 2.11 92
Refrigerating
2011 ASHRAE Application CH.33 Table 2 - Table 4 440-442
2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
Commercial Kitchen Ventilation Rates (Hood/Canopy, Ceiling Extract/MakeUp) 2.3.6 … 100, 101
Refrigerating
2017 Veterans Affairs CH.06 … 176
2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
2.3 Table 2.9 90, 123
Car Parking Extract Ventilation Rate Refrigerating
HVAC DESIGN
SUB
ITEM DESCRIBTION
HANDBOOK CHAPTER.SECTION TABLE/CHART/FIGURE PAGE IN PDF HANDBOOK
2017 ASHRAE Fundamental 21.6.1 Fig 19 615
Exhaust, Fresh air & Sand trap Louvers Sizing
2006 SMACNA-Duct Design 8.2.6 Fig 8-27 / Table 8-8 262, 263
Carrier-Part2 / Air Distribuation CH.03 Table 20 235
2011 ASHRAE Application 57.1 Table 1 971
Outlet sizing By Velocity
2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
AIR OUTLET DESIGN 3.3.2 Table 3.5 230
Refrigerating
Exhaust, Fresh air & Sand trap Louvers Friction Loss 2006 SMACNA-Duct Design 8.2.6 Fig 8-27 / Table 8-8 262, 263
Grills And Diffusers Friction Loss Carrier-Part2 / Air Distribuation CH.03 Table 21 242-249
SUB
ITEM DESCRIBTION
HANDBOOK CHAPTER.SECTION TABLE/CHART/FIGURE PAGE IN PDF HANDBOOK
Central Hydronic Primary Constant flow (Air Cooled Chillers) 2016 ASHRAE System & Equipment 13.2.8 Fig.35 279
Central Hydronic Primary Variable flow (Air Cooled Chillers) 2016 ASHRAE System & Equipment 3.2 Fig.1, Fig.2 29
Central Hydronic Primary/Secondary Variable Flow (Air Cooled Chillers) 2016 ASHRAE System & Equipment 13.2.8 Fig.36 279
Central Hydronic Primary/Secondary Variable flow With Expansion Tank And Air
2016 ASHRAE System & Equipment 3.2 Fig.4 30
Separator (Boiler)
District Cooling With Building Pump (Direct) 2016 ASHRAE System & Equipment 12.4.1 Fig.25 249
HYDRONIC SCHEMATIC/LOOP AND HOOK-UP
District Cooling Without Building Pump (Direct) 2016 ASHRAE System & Equipment 12.4.1 Fig.26 250
District Cooling (In-Direct) 2016 ASHRAE System & Equipment 12.4.2 Fig.28 251
Central Hydronic Circuit Types 2016 ASHRAE System & Equipment 13.2.4 Fig.17-Fig.20 272
Central Hydronic Direct And Reverse Return 2016 ASHRAE System & Equipment 13.2.4 Fig.21 273
Central Hydronic Decoupler / ByPass Line For Primary/Secondary 2016 ASHRAE System & Equipment 13.2.3 Fig.10 268
Central Hydronic Decoupler / ByPass Line For Variable Primary 2016 ASHRAE System & Equipment 3.2 Fig.1, Fig.2 29
Central Hydronic Expansion Tank 2016 ASHRAE System & Equipment 13.2.3 Fig.15, Fig.16 271
HVAC DESIGN
Central Hydronic Make Up Water And Expansion Tank 2016 ASHRAE System & Equipment 13.2.9 Fig.40 281
HVAC
Central Hydronic Control Valves 2016 ASHRAE System & Equipment 13.2.5 Fig.22, Fig.24 273, 274
Chilled Water Pump Hook-Up (End-Suction, In-Line) 2016 ASHRAE System & Equipment 44.16 Fig.51, Fig.52 762
Cooling Tower Hook-Up 2016 ASHRAE System & Equipment 40.5 Fig.22-Fig.24 704
Manual Chemical Dosing Pot Hook Up
Automatic Chemical Dosing Pump Hook Up
DX Split Unit Schematic 2016 ASHRAE System & Equipment 49.1 Fig.3 821
DX Window Unit Schematic 2016 ASHRAE System & Equipment 50.1 Fig.1 835
DX SCHEMATIC/LOOP AND HOOK-UP DX Package Unit Schematic 2016 ASHRAE System & Equipment 49.2 Fig.4-Fig.10 823, 824
DX VRF Schematic 2016 ASHRAE System & Equipment CH.18 Fig.2-Fig.4 316-317
Heat Pump Schematic 2016 ASHRAE System & Equipment 49.5, 49.6 Fig.12, Fig.14-Fig.17 829, 830-832
Ventilation General Schematic, Equations 2016 ASHRAE 62.1 CH.03, A Table E-1 / Fig.3.1, A1, E1, E2 6, 26, 44, 45
AHU Ducting Schematic (Constant Flow) 2016 ASHRAE System & Equipment 4.2.1 Fig.9 47
AHU Ducting Schematic (Variable Flow) 2016 ASHRAE System & Equipment 4.2.1 Fig.10 47
AHU Ducting Schematic (Multi Zones) 2016 ASHRAE System & Equipment 4.2.2 Fig.13 49
2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
FAHU With HRW Ducting Schematic 2.4.10 Fig.2.34 162
DUCTING SCHEMATIC/LOOP AND HOOK-UP Refrigerating
Energy Recovery (Heat/Enthalpy/Desiccant Wheel, Heat Exhanger, Heat Pipe) 2016 ASHRAE System & Equipment 26.6 Fig.14-Fig.19 443, 444
AHU Ducting Schematic (Primary/Secondary, Under Floor, Wetted Coil) 2016 ASHRAE System & Equipment 4.2.4 Fig.14-Fig.16 50, 51
PACU Ducting Schematic 2016 ASHRAE System & Equipment 2.5 Fig.1-Fig.3 20, 21
Kitchen Ventilation Ducting Schematic
Corridor/Lift Lobby Extract/Pressurization With SMFD Schematic 2011 ASHRAE Application CH 53 Fig.11 910
2011 ASHRAE Application CH 53 Fig.12-Fig.16 911-913
Staircase/Lift Pressurization Schematic (Single Inject, Multi Inject, ByPass, Relief Vent) 2000 NFPA 92A / Practise Smoke Control System CH 02 Fig.2.3.2.2.1-Fig.2.3.5.2.1b 43386
SMOKE MANAGEMENT SCHEMATIC/LOOP AND 1998 BS 5588-4 9.1.6 Fig.7a, Fig.7b 36-39
HOOK- UP 2011 ASHRAE Application CH 53 Fig.25, Fig.26 919
Atrium Extract/Pressurization Schematic 2009 NFPA 92B / Smoke Control System In Mall, Artia, Large Fig.5.5.1, Fig.5.5.2, Fig.A.3.3.12.1-
CH.05, A 13, 14, 20, 21
Areas Fig.A.3.3.12.3
2011 ASHRAE Application CH.15 Fig.3, Fig.4 180, 181
Car Parking Extract/MakeUp Schematic
2006 BS 7346-7 CH.07 Fig.1 19
2006 SMACNA-Duct Design A Table A.20 367, 368
Noise Level Limitations 2011 ASHRAE Application CH.48 Table 1 765
2006 CIBSE-Guide A / Environmental Design 1.8 Table 1.15 33
Recommended Air Velocities For NC 2011 ASHRAE Application CH.48 Table 8,9 776
ACOUSTIC, NOISE LEVELS, VIBRATION
Acoustic Design Recommendations 2011 ASHRAE Application CH.48 … 770
ISOLATING
Acoustic Duct Liner Recommendations 2011 ASHRAE Application CH.48 … 783
Air Outlet Noise Recommendation 2011 ASHRAE Application CH.48 … 777
Sound Attenuator Components, Selection, P.D, V 2011 ASHRAE Application CH.48 Fig.20,21 / Table 27 785-787
Equipment Vibration Isolator Design & Selections 2011 ASHRAE Application CH.48 Table 47 807-810
REFERENCE
SERVI
MAIN
SUB
ITEM DESCRIBTION
HANDBOOK CHAPTER.SECTION TABLE/CHART/FIGURE PAGE IN PDF HANDBOOK
2006 SMACNA-Duct Design 4.6 Table 4-1 85
Duct Pressure Classification
2005 SMACNA-Duct Construction 1.5.5 Fig.1-1 33
2006 SMACNA-Duct Design CH.11 Table 11-1 298-300
Duct Material, Physical Properties, Third Party Test Certificates (Normal, Industrial, 2016 ASHRAE System & Equipment 19.7-19.13 … 339-342
Kitchen, Smoke/Fire Rated, AntiBiotical, Rigid Plastic, Outdoor)
2000 NFPA 92A / Practise Smoke Control System
Duct Support 2005 SMACNA-Duct Construction 5.2.11 Table 5-1M, 5-2 / Fig.5-5,5-7,5-9M 234, 236, 241, 245
Typical Duct Fittings Installation 2005 SMACNA-Duct Construction 4.1 Fig.4-1 213
2005 SMACNA-Duct Construction 4.1 Fig.4-2,4-3, Chart.4-1M 214, 215, 216, 223
Duct Elbows / Splitter Vanes 2006 SMACNA-Duct Design 5.15, A Fig.5-12, Table A-7 118, 119, 322, 323
EN 1505 … … …
Duct Tee, Elbow branch 2005 SMACNA-Duct Construction 4.1 Fig.4-5 218
Duct Branches, TakeOffs 2005 SMACNA-Duct Construction 4.1 Fig.4-6 219
Duct Transitions, OffSet, Bell Mouth 2005 SMACNA-Duct Construction 4.1 Fig.4-7 220
Duct Obstructions 2005 SMACNA-Duct Construction 4.1 Fig.4-8 221
AIR DUCT
Duct Aspect Ratio Allowance Range 2016 ASHRAE System & Equipment 21.6.1 … 616
HVAC
Volume Control Damper (VCD)) 2005 SMACNA-Duct Construction CH.07 Fig.7-4, 7-5 266, 267
2005 SMACNA-Duct Construction CH.07, CH.08 Fig.7-14, 8-1 279, 283
Fire Damper (FD) 2017 ASHRAE Fundamental 6.1 … 615
1999 NFPA 90A / Installation Of HVAC 3.3, A Fig.A.3.3 13, 14, 18
1999 NFPA 90A / Installation Of HVAC 3.3, A Fig.A.3.3 13, 14, 18
Smoke Damper (SD)
2017 ASHRAE Fundamental 6.1 … 615
1999 NFPA 90A / Installation Of HVAC 3.3, A Fig.A.3.3 13, 14, 18
Combination Fire And Smoke Damper (MSFD)
2017 ASHRAE Fundamental 6.1 … 615
DUCT ACCESSORIES
Relief Damper Carrier-Part2 / Air Distribuation CH.01 Fig.5 172
Back Draft Damper / Non Return Damper (NRD)
2005 SMACNA-Duct Construction CH.07 Fig.7-2M, 7-3 263, 264
Duct Access Doors 2005 CIBSE-Guide B / Heating, Ventilating, Air Conditioning &
3.3.10 … 239, 240
Refrigerating
Flexible Duct Connector 2005 SMACNA-Duct Construction CH.07 Fig.7-8, 7-9, 7-10 270-272
Flexible Duct 2005 SMACNA-Duct Construction 3.7 Fig.3-8,3-9,3-10,3-11 203-208
Acoustic Lining 2005 SMACNA-Duct Construction CH.07 Fig.7-8, 7-9, 7-10 270-272
Minimum R Values 2017 ASHRAE Fundamental 23.1 Table 1 671
2017 ASHRAE Fundamental 23.2 Table 8 679
Insulation Physical Properties
2017 ASHRAE Fundamental 26.4.1 Table 1 735-739
2017 ASHRAE Fundamental 23.1 Table 4 672
2017 ASHRAE Fundamental 23.3 Fig.7,8 686
DUCT INSULATION Condensation Prevention / Thickness / Control Insulation Surface Temperature
2017 ASHRAE Fundamental 23.4 … 687, 688
2006 CIBSE-Guide A / Environmental Design 7.6-7.9 … 282-293
Insulation Heat/Energy Loss/Gain 2017 ASHRAE Fundamental 23.4 … 687
Weather Barriers / Jacketing 2017 ASHRAE Fundamental 23.2 … 680
Pre-Insulated Duct (Phenolic) 2016 ASHRAE System & Equipment 19.6 … 338
REFERENCE
SERVI
MAIN
SUB
ITEM DESCRIBTION
HANDBOOK CHAPTER.SECTION TABLE/CHART/FIGURE PAGE IN PDF HANDBOOK
2017 ASHRAE Fundamental 22.1.3 Table 1 632
Hydronic Pipes (Material, Thermal Expansion, T, P, Wall Thickness, Weight, Conductivity,
2017 ASHRAE Fundamental 22.1.8 Table 13 643
Density, Third Party Test Certificates)
2017 ASHRAE Fundamental 22.2.1 Table 16-Fig.18 646-648
2017 ASHRAE Fundamental 22.1.3 Table 1 632
Hydronic Fittings
2017 ASHRAE Fundamental 22.2.3 Table 19 649
HYDRONIC PIPES MATERIAL / INSTALLATION
2017 ASHRAE Fundamental 22.1.3 Table 1 632
Hydronic Pipe Joints 2017 ASHRAE Fundamental 22.2.1 Table 16 646
HYDRONIC PIPE
Centrifugal Pump (Components And Types) 2016 ASHRAE System & Equipment 44.1, 44.2, 44.3 Fig.1-Fig.12 747-750
Centrifugal Pump (Performance, Hydronic System Curves, Third Party Test Certificate) 2016 ASHRAE System & Equipment 44.4, 44.5, 44.6 Fig.13-Fig.22 750-753
Centrifugal Pump (Power, Efficiency, Radial Thrust, Affinity Laws) 2016 ASHRAE System & Equipment 44.7, 44.8, 44.9, 44.10 Fig.23-Fig.31 753-756
HVAC PUMPS Centrifugal Pump Net Positive Suction Head (NPSH) 2016 ASHRAE System & Equipment 44.11 Fig.32-Fig.34 756, 757
Centrifugal Pump Arrangments (Parallel, Series, Stand-By, Primary-Secondary, VFD, DPT,
2016 ASHRAE System & Equipment 44.13, 44.14, 44.15, 44.16 Fig.36-Fig.52 758-762
Installation)
Centrifugal Pump (Components And Types, Performance, Hydronic System Curves, Third
Carrier-Part8 / Auxiliary Equipment CH.01, 02 … 656-706
Party Test Certificate, Selection, Power, Efficiency, Motors)
HEAT EXCHANGERS Heat Exchangers (Design, Types, Selection, Components) 2016 ASHRAE System & Equipment CH.43 … 735-745
Boilers (Residential, Commercial, P, T, Construction Material, Draft Type, Condensing Or
2016 ASHRAE System & Equipment 32.1, 32.2 Fig.1-Fig.6 542-546
Non- Condensing, Selection)
BOILERS
Boilers (Efficiency, Performance, Third Party Test Certificate, Sizing, Selection, Burner 2016 ASHRAE System & Equipment 32.3-32.8 Fig.7, Fig.8 547-549
Type, Control) Carrier-Part8 / Auxiliary Equipment CH.03 … 707-716
REFERENCE
SERVI
MAIN
SUB
ITEM DESCRIBTION
HANDBOOK CHAPTER.SECTION TABLE/CHART/FIGURE PAGE IN PDF HANDBOOK
Valves (Fundamental, Material, Water Hammer, Noise, Flow, Pressure Drop, Cavitation,
2016 ASHRAE System & Equipment 47.1 Fig.1, Fig.2 799-800
Third Party Test Certificate)
Manual Valves (Types, Components, Selection) 2016 ASHRAE System & Equipment 47.2 Fig.3-Fig.7 800-802
Control Valves (Types, Actuator Types, Flow, Sizing) 2016 ASHRAE System & Equipment 47.3 Fig.8-Fig.19 802-808
HYDRONIC VALVES & ACCESSORIES
Balancing Valves (Manual, Automatic Flow Limiting, Selection) 2016 ASHRAE System & Equipment 47.4 Fig.20-Fig.22 808, 809
Multi-Purpose Valve, Safety Valve, Self Contained Temp Control Valve, PRV, Make Up
2016 ASHRAE System & Equipment 47.5-47.11 Fig.23-Fig.29 809-812
Water Valve, Check Valve, Stop Check Valve, Back Flow Preventer, Steam Traps)
2016 ASHRAE System & Equipment 49.1, 49.2 Table 1,2 / Fig.1-Fig.10 820-825
DX Units (Configrations, Installation, Types, Selection, Third Party Test Certificates)
Carrier-Part6 / Air Handling Equipment CH.03 … 554-557
UNITARY AC UNITS (DX UNITS) Air Source Heat Pump 2016 ASHRAE System & Equipment 49.5 Fig.12,13 828-830
Water Source Heat Pump 2016 ASHRAE System & Equipment 49.6 Table 3 / Fig.14-Fig.17 830-833
VRF Heat Pump 2016 ASHRAE System & Equipment 49.7 … 833
VRF (Types, Applications, Third Party Test Certificates, Control) 2016 ASHRAE System & Equipment 18.1, 18.2 Table 1 / Fig.1-Fig.6 316-320
VARIABLE REFRIGERANT FLOW (VRF) VRF (Typical Refrigerant, Typical P-v Curve, Heat Recovery Types) 2016 ASHRAE System & Equipment 18.3 Table 2 / Fig.7-Fig.10 321, 322
VRF Design Consideration 2016 ASHRAE System & Equipment 18.5, 18.6, 18.7 Table 4, Table 5 / Fig.13-Fig.17 324-329
AHU (Advantages, Disadvantages, Zoning, Air T Vs Air Quality, Energy) 2016 ASHRAE System & Equipment CH.04 … 37-39
AHU (Psychometric Proccess, Dampers, Plenum, Filters, Fans, Coils, Humidifiers, De-
2016 ASHRAE System & Equipment 4.1 Fig.1-Fig.8 39-46
humidifier)
AIR HANDLING UNIT (AHU)
AHU Distribuation System (Constant Flow, VAV, Single Duct, Dual Duct, Single Zone,
Multi Zone, Primary/Secondary, Dedicated OA, Under Floor, Supersaturated, Low T, 2016 ASHRAE System & Equipment 4.2 Fig.9-Fig.16 47-54
Smoke Control, Terminal Units, Control)
2016 ASHRAE System & Equipment 5.2, 4.16 Fig.1, Fig.10 59, 60, 70
FAN COIL UINT (FCU) FCU (Types, Damper, Filtration, Coil, Fan, Ducting, Control, Selection, Third Party Test
2016 ASHRAE System & Equipment 20.2.3 Fig.6-Fig.8 354-356
Certificate)
Carrier-Part6 / Air Handling Equipment CH.02 … 528-540
HVAC
AIR CURTAIN Air Curtain (Types, Effeciency, Selection, Design, Control) 2016 ASHRAE System & Equipment 20.2.3 Fig.9, Fig.10 356-358
Fans (Types, Components, Impeller Design, Housing Design, Performance Curve, Third
2016 ASHRAE System & Equipment 21.1-21.4 Table 1 / Fig.1,2 360-364
Party Test Certificate)
Fans (Fan Laws, P, Q, Ducting, System Effect) 2016 ASHRAE System & Equipment 21.5-21.9 Table 2 / Fig.3-Fig.11 360-364
2016 ASHRAE System & Equipment 21.6-21.16 Table 3-Table 6 / Fig.12-Fig.18 368-372
FANS Fans (Selection, Parallel, Series, Noise, Vibration, Arrangment, Control)
Carrier-Part6 / Air Handling Equipment CH.01 … 520, 521
Fans (Types, Applications, Third Party Test Certificate, Designation, Performance,
Carrier-Part6 / Air Handling Equipment CH.01 … 510-524
Selection, Accessories, Control, Locations, Multiple Installation)
2017 ASHRAE 52.2
2017 ASHRAE 52.2
ECOLOGY UNIT (EU)
2017 ASHRAE 52.2
2017 ASHRAE 52.2
2017 AHRI 1361 / Computer And Data Processing Room Air
Definitions CH.03 … 5-8
Conditioners
Classification Of Computer And Data Processing Room Air Conditioners (Designation, 2017 AHRI 1361 / Computer And Data Processing Room Air
CH.04 Table 1 9
AHRI Type, Arrangement-Indoor/ID, Arrangement-Outdoor/OD) Conditioners
CLOSED CONTROL UNIT/COMPUTER ROOM AIR Rating Requirements (Indoor Return Air Temperature Standard Rating Conditions, Heat
Rejection / Cooling Fluid Standard Rating Conditions, Minimum External Static Pressure 2017 AHRI 1361 / Computer And Data Processing Room Air
CONDITIONER (CCU/CRAC) CH.06, CH.07 Table 2 - Table 6 11-15
Standard Rating Conditions, Uncertainty Allowances, Minimum Data Requirements For Conditioners
Published Rating)
Grill & Diffusers (Types, Mixing, Temperature, Selection Procedure, Third Party Test
2016 ASHRAE System & Equipment 20.1 Table 1 / Fig.1,2 345-348
Certificate)
AIR OUTLETS Grill & Diffusers (Types, Special Feature, Installation, Accessories) 2016 ASHRAE System & Equipment 20.2.1, 20.2.2 Table 2 / Fig.3,4 348-351
Grill & Diffusers (Types, Application, Selection, Friction Loss) Carrier-Part2 / Air Distribuation CH.03 Table 20,21 / Fig.62-Fig.93 229-249
REFERENCE
SERVI
MAIN
SUB
ITEM DESCRIBTION
HANDBOOK CHAPTER.SECTION TABLE/CHART/FIGURE PAGE IN PDF HANDBOOK
Energy Conservation / Cost Saving 2001 CIBSE-Guide H / Building Control System 1.5 … 12, 13
Sensors, Actuators, Valves, Dampers, Motors, Pumps, Fans & Control 2001 CIBSE-Guide H / Building Control System 3.1-3.7 … 30-53
CONCEPTS & FUNDAMENTAL Control Safety (Alarm, Interlocks) 2001 CIBSE-Guide H / Building Control System 5.1 … 76-78
BMS Benefits 2001 CIBSE-Guide H / Building Control System 1.8 Table 1.4 14
Heat Pump Control 2001 CIBSE-Guide H / Building Control System 5.13 … 126-128
Natural Ventilation Control 2001 CIBSE-Guide H / Building Control System 5.14 … 128-131
2011 ASHRAE Application CH.47 Fig.1-Fig.8 741-743
Boiler Control
2001 CIBSE-Guide H / Building Control System 5.2 … 78-82
BSRIA/CIBSE Air Balancing (Tolerance %, Air Flow Equations, Site Test Instruments,
Flow Measurements, Traverse, Commissioning Procedure, Commissioning Method Of 2013 BSRIA Guide (BG 49/2013) / Commissioning Air System 2.6, CH.05, 6.1, CH.09 … 17, 50, 33-78
Statement, Reports)
Follow us at:
https://www.facebook.com/coursesmep