Professional Documents
Culture Documents
DB-15 Diagnostic Connector 8" Touch Screen If it is the first time you have used this tool, you need to make some
(To connect to vehicle's DLC (Data system settings and keep the diagnostic software synchronized with
Link Connector) via diagnostic cable.) Selection Buttons the latest version.
Follow the steps below to proceed.
5V Charging Port Power/Screen
Lock Button
(To connect to external DC Tap “Start” on Welcome screen
power for charging the tool.) HOME Button
1. Turn the ignition off. AutoDetect and manual diagnosis are supported. If the AutoDetect
fails, you can choose to input the VIN manually or exit the AutoDetect
2. Locate vehicle's DLC: It
session to switch to manual diagnosis mode.
provides standard 16 pins
and is generally located on *Note: If "Automatic detection on connect" in "Settings" is set as ON, this
driver's side, about 12 step can be ignored.
inches away from the
Diagnostic Flowchart Manual Diagnosis Flowchart
center of dashboard. See
Figure DLC Location. If *If you are fresh to vehicle
DLC is not equipped under Tap “Diagnose”* diagnostics, you are suggested
dashboard, a label to use "DEMO" to get familiar
indicating its position will with the diagnostic process.
be given.
Start decoding vehicle VIN
In case no DLC is found, please refer to Automobile Repair Manual. Select vehicle manufacturer
Decoding OK Decoding failed
3. Plug one end of the diagnostic cable into the DB-15 connector of
the tool, and tighten the captive screws. Connect the other end to Double check vehicle info.
the vehicle's DLC. Select vehicle make
Vehicle Input the VIN, and tap "OK", the system will automatically identify the
Display Tablet vehicle model. If the vehicle VIN is successfully decoded, it will perform
auto-diagnosis until a diagnostic report is automatically output.
*Note: The tool ONLY works with the 12V passenger cars equipped with *Note: The most recognizable location for VIN is in the top left corner on the
standard OBD-II diagnostic socket. vehicle's dashboard. Other locations include the driver's door or post, and the
4. Turn the ignition key on. firewall under the hood.
正面
制作要求: