Professional Documents
Culture Documents
Expriment 7
181916070
spring 2022
1
Objectives :-
simplifying a resistive bridge network by using delta and
wye transformation.
EQUIPMENT REQUIRED:-
2
INTRODUCTION :-
In many circuit applications, we encounter
components connected together in one of two
ways to form a three-terminal network: the “Delta,”
or Δ (also known as the “Pi,” or π) configuration,
and the “Y” (also known as the “T”) configuration.
3
It is possible to calculate the proper values of
resistors necessary to form one kind of network (Δ
or Y) that behaves identically to the other kind, as
analyzed from the terminal connections alone.
That is, if we had two separate resistor networks,
one Δ and one Y, each with its resistors hidden
from view, with nothing but the three terminals (A,
B, and C) exposed for testing, the resistors could
be sized for the two networks so that there would
be no way to electrically determine one network
apart from the other. In other words, equivalent Δ
and Y networks behave identically.
4
1-Tee/Wye and Pi/delta Networks.
5
3-CM 15 is activated to increase the value of R2 (Y
network ) to 2050 Ohm.
which terminal pairs of the T and Y Networks differ?
c- A/D,B/D and C/D.
6
-All, in the delta or Pi network, all the resistance are
connected together Therefore a change in one resistor
affects the resistance of all terminal pairs.
7
3- use your measured wye resistor values to calculate
the values required for an equivalent delta network
DRB=2730 ohm
DRA=4401 ohm
DRC=4005 ohm
8
5- Use your ohmmeter to compare the terminal
resistance between the Y network and the delta
network.
is the delta network equivalent to the wye network?
-yes,the networks are equivalent .
Discussion :-
-In Pi and Delta Networks any change in one
resistor affects the values of other resistors in the
network.