Professional Documents
Culture Documents
Established as State Private University under Govt. of Maharashtra. Act No XL, 2017 EXM/P/09/01
Year and Program:2022-23 School of Technology Department of Civil Engineering
OR
a) A water channel is V-shaped with each side making an angle of 45° to 07 L2 CO1
the vertical. Calculate the discharge when the depth of water in the
channel is 0.3 m. and the bed slopes of channel is 1 in 500. Take
Chezy’s constant C = 50. What will be depth of water in the channel to
pass twice the above said discharge if bed slope and what of C is same.
OR
b) Discuss stepwise procedure of direct step method with illustrative 08 L2 CO1
example.
Q.2 Answer/Solve the following
a) Explain the errors in the measurement of discharge in notches. 07 L3 CO2
OR
a) Show that, the rate of discharge over 60° V notch may be expressed by 07 L3 CO2
equation Q = K H(5/2), with Cd = 0.588.
b) Determine efficiency of series of flat plates normal to jet mounted on 08 L3 CO2
periphery of wheel.
OR
b) Water at a pressure of 300 kPa flows through a tapering pipe. The inlet 08 L3 CO2
Page 1 of 2
diameter of the pipe is 100 mm and the outlet diameter is 50 mm. If the
entering velocity is 4 m/s, calculate the axial fore on the pipe assuming
no loss of energy.
Q.3 Answer/Solve any Two
a) Explain classification of Turbines in detail. 08 L2 CO1
b) Explain of centrifugal pump in detail. 08 L2 CO1
c) Write a short note on net positive suction head (NPHS). 08 L2 CO2
d) Discuss advantages of hydro-electric power plant. Also, explain the 08 L2 CO2
typical components of hydro-electric power plant.
*****
Page 2 of 2