All Buildings - NYUAD: (ALL NYU CAMPUSS LOCATIONS) Company: MVP TECH Task No: PTW:4369 Method Statement Submitted: Yes Permit Validity Information Risk Assessment Undertaken and Submitted: Yes Issued Date and Time: 10/31/2021 12:16 PM Other Precautions and Safety Adherence Required Start Date: 11/1/2021 End Date: 1/31/2022 The permit holder is responsible for supervising the work undertaken in accordance with OSHAD regulations, Supplier Code of Conduct and all UAE laws. No one is allowed to work Authorized to work from : 8:30:00 AM To : 6:30:00 AM within the NYUAD campus unless they have undertaken a health and safety induction. Please note the following shall be adhered to at all times: 1. Serco and NYUAD grants access to approved contractors only. Authorized By: Authorized Date: 2. All works shall be undertaken in a safe manner and where applicable signage and barriers must be provided. NYUAD PTW FM Sunday, October 31, 2021 3. All working areas shall be left in the same condition they were found once the work is NYUAD PTW EHS Monday, November 1, 2021 completed. 4. No access is permitted to any system or utility without permission from Serco. Where required you are to ensure that the relevant isolation, working at height, confined space and/or other related permits are applied for and approved by Serco. 5. Permit holders are to ensure a competent person is available to supervise the works at all times. Work Source or Manager Responsible for the Work : 6. Communication facilities are to be available in the work area, in order to summon assistance in the event of an emergency. e.g. telephone or portable radio. NYUAD 7. Remove all waste generated at completion of work for the day IMPORTANT PTW Summery: No staff member should work longer than 8 hours per day. Over time should be voluntary and not exceed 2 hours per day. This project intends to install a new IP Surveillance, Video Management system and Failure to comply with these rules will result in the permit being suspended or cancelled Storage Archiver as per the specification provided by NYUAD and as per ADMCC guideline. The scope is to replace existing old cameras with IP cameras on campus, to Use below link to access NYUAD Supplier Code of Conduct install new IP cameras and Server and Storage installation in the designated https://nyuad.nyu.edu/content/dam/nyuad/about/social-responsibility/ Datacenters which shall be identified by the Client during the preliminary meetings nyuad-project-supplier-code-of-conduct.pdf – as outlined on the approved design drawings following the ADMCC s. Ext. of PTW 4200
Published: Sunday, October 31, 2021 12:16 PM Page 1 of 1