Professional Documents
Culture Documents
(sir rey, based po sa mga naalala ko sana makatulong,wala po choices all of the above tsaka
po marame typo error pero un ung tama sagot. No drawings illustrated in the morning just
purely identifications. 100 items 8 pages)
Prepared by: P. B. R.
PRPRAC
1. What particular Rule in the 2004 revised IRR of PD1096 that deals regulates and
determine window openings? (sir marami po ganitong tanong dif. Sections pati sa RA 9266
lalo na po nun day 2 Design)
a. Section 808 b. Section 709 c. Section 802
2. An Act providing for more responsive and comprehensive regulation for the registration,
licensing and practice of architecture, "An act to regulate the practice of Architecture in the
Philippines.”
a. The Architecture Act of 2006 b. The Architecture Act of 2004
5. This is not a reason for refusal of registration and removal of name from roster of
Architects
a. Immoral and dishonorable conduct
b. Convicted of a criminal offense
c. Conviction of political offense
8. Are defined as passageways or access roads that allow fire apparatuses to pass through.
They are not intended for normal vehicle traffic?
a. Fire lane b. Truck lane
9.A door with a fire-resistance rating(sometimes referred to as a fire protection
rating for closures)used as part of a passive fire protection system to reduce the spread of
fire or smoke between compartments and to enable safe egress from a building or
structure?
a. Fire Exit b. Fire door
10. Group A dwelling shall occupy not more than __% inside lot?
a. 80% b. 90%
18. Who adopts the Land use plan after the HLURB approves it?
a. Mayors office b. Sangguniang Panlunsod
19. Under NBC,every rooms for habitable use shall be provided with windows with a total
free area openings equal to atleast__% of the floor area of the room?
a. 15% b. 10%
20. As per BP344, centerline heights of the topmost control buttons or switches shall be
how much from the floor so as they are within reach of a person seated on a wheelchair?
a. 0.80-1.00 b.0.90-1.20
22. It is the most common method of compensation which is also fair to both client and
Architect?
a. percentage fee method b. Lump sum
23. Which of the following is the local (LGU) law that governs the site planning and design of
the project?
a. Zoning Ordinance b. CLUP
24. Government agency responsible to help and empower the farming and fishing
communities and the private sector to produce enough, accessible and affordable food for
every Filipino and a decent income for all.
a. NFA(National Food Authority)
b. DOA (Department of Agriculture)
c. DFA (Department of foreign Affairs)
BUILDING MATERIALS
(sir nagtanong po sila sa mornin ng 2 items about bags of cement and installation ng tiles)
26. What is the standard cement of bags for “CLASS A” concrete mixture
a. 9 bags b. 8 bags
HISTORY
28. A long colonnaded building used around public places and as shelters and religious
shrines is?
a. exedrae b. stoa
32. tomb houses that were made to take the body at full length?
a. columbaria b. mastaba
33. Mesopotamian structure with four corners oriented towards cardinal points?
a. Ziggurat b. temple of marduk c. hanging garden
34. what is rose window?
a. circular window with stained glass
b. circular window divided into segment
41. What is a niche, direction of mecca which people must face when praying?
a. Riwaq b. Mihrab c. Iwan
42. Opening in a battlement between the two raised solid portions or merlons of the
castle?
a. Crenels b. donjon c. keep
46. Famous stained glass window cathedral?(sir typo error sila pero yan ang tama sagot)
a. Notre Dame Cathedral b. Chartresss Cathedral
55. An art school in Germany that combined crafts and the fine arts, and was famous for the
approach to design that it publicized and taught. literally "house of construction"—was
understood as meaning "School of Building"
a. Taliesin West b. Bauhaus
PLANNING
58. What is the meaning of skycrapper?
a. touching the sky b. almost in heaven c. unlimited to ground
67. To be good in environment work place with (sir out of place na tanong pati sinusuot na
damet sa trabaho tinanong din)
a. Business Attire b. Casual Wear c. Shirts and Pants
DAY 1 AFTERNOON (sir wala po computations sa hapon puro definition of terms and
illustrations ng building materials and isometric drawing, ung definition of terms naka
category sya for example Painting Preparations puro paint questions 1-10, then Concrete
and Masonry 11-20,15 pages 150 items. sir lahat ng estimates computations nasa DAY 2)
1. Which of the following Methods of Glass production has fewer defects such as distortion?
a. tempered glass b. float glass
3. A strip of rubber, metal, or other material used to seal the edges of a door or window
against the cold?
a. Weather strip b. trimmer
4. a generic term for a material with high plasticity, similar in texture to clay or
dough, typically used in domestic construction and repair as a sealant or filler
a. Glazing putty b. Sealant
5. Glass is usually made by taking thick glass and creating an angled surface cut around the
entire periphery.
a. Chamfer b. bevel cut glass
Identify Parts of Window (sir may illustration ng window identify mo lng sya)
12. A mixture consisting of vehicles or binders, with or without coloring pigments, adjusted
and diluted with correct amounts and types of additives and thinners, which when applied
on a surface, forms an adherent continuous film which provides protection, decoration,
sanitation, identification and other functional properties
a. paint b. lacquer
13. For spreading the color particles over large surfaces, the ground oil stain color is thinned
with what material?
a. thinner b. lacquer thinner
14. A high quality surface conditioner to be diluted with water to neutralize lime activity in
new interior and exterior masonry surface. It promotes good adhesion and durability
a. Putty b. Concrete Neutralizer
Wood Joints (sir lumabas lahat yan joints na yan identify lang)
Finger joints
Miter joints
Rabbet joints
Dado joints
Miter joint with
spline
Types of Roof
Hip Roof
Dutch Hip Roof
Hip Roof with Dormer
Hip Roof with Shed
Dormer
Parts of Elevator
Elevator Buffer
Car Guide Rail
Counterweight
Hoistway
Shaft Hook
Sanitary and Electrical Fittings (sir ung mga binigay na illustrations sobrang dilim
nun figure)
Elbow
Coupling
Junction Box
Outlet Box
Isometric Plan (identify the ff. Sir sobra liit di po visible kelangan magdala ng magnifying
glass sa liit)
P-trap
Shower Drain
Vent Stack
Vent Line
Catch Basin
Vent Stack
Thru Roof
Parts of T-runner Installation
Main tee
Cross tee
Wall angle tee
Hanger wire
58. Is the coefficient of elasticity for a shearing force. It is defined as "the ratio of shear
stress to the displacement per unit sample length (shear strain)"
a. Modulus of rigidity b. Modulus of Shear
59. What protects the wall from damage at its base? It could be made of wood, plastic,
metal or any other composite material attached at the lower portion of the wall?
a. Baseboard b. Cornice
60. Which paint can be used on both primed concrete and wood surface? Paint of this type
is usually odorless and water based substance so that priming can be done using water
instead of paint or laquer thinner?
a. Acrylic Paint b. Latex Paint
64. Is the process of supporting a building, vessel, structure, or trench with shores when in
danger of collapse or during repairs or alterations
a. Underpinning b. Shoring
65. A shallow trough fixed beneath the edge of a roof for carrying off rainwater
a. Valley b. Gutter
66. When a large aggregate of more than 6mm (1/4”) in size is added to cement, water and
fine aggregate the product is
a. Concrete b. Reinforced Concrete
68. What usually happens to steel in a slab or reinforced concrete beam if such member is
about to collapse?
a. Rupture b. Yield
69. What do you call 2 or more materials that are combined together?
a. Composite b. Chemical Compound
70. Is a structural piece of stone, wood or metal jutting from a wall , whereas a console is a
piece applied to the structure
a. Corbel b. Dentil
71. Glass that transmits light but does not allow a view of objects on the other side, such as
ground glass or frosted glass
a. Obsecure Glass b. Float Glass
72. All the building products made of wood that are produced in a planning mill, such as
moldings, door and window frames, doors, windows, blinds, and stairs
a. Torno b. Millwork
73. A concrete beam that connects individual pile caps or spread footings
a. Tie beam b. Wall Footing
75. A unit of power equal to the power dissipated in an electric circuit in which a
potential difference of 1 volt causes a current flow of 1 ampere
a. Watts b. Volts
99. T-joist
100. Sheet metal forming
(Definitions of terms based again sa book, meron po sir tinanong sections 9266 pero di ko
po maalala)
9. What is USA?
a. 1.20
b. 1.70
7. Defined Off-RROW
a. Equipment Evaluation
b. Forensic Architecture
c. Value Management
9. Under the NBCP, what is the maximum width (in meters) of an exit door leaf)
10. Under the NBCP, what is the minimum sizes of rooms for Human Habitations
a. 6m b. 5m c. 3m
Prepared by: P. B. R.
Q. Maximum Simplicity?
ANS. Marcel Breuer
Q. Architect makes decisions on all claims of the Owner and Contractors on all matters
relating to the execution and progress of work or the interpretation of the Contract
Documents. The last phase of service?
ANS. Construction phase
ANS. chord