Professional Documents
Culture Documents
Duct S
Type DUCT S DUCT S
Model AM012KNHPKH/AZ AM018KNHPKH/AZ
Power Supply Φ , #, V, Hz 1,2,220-240,50/60 1,2,220-240,50/60
Mode - HP/HR HP/HR
kW 3.60 5.60
Cooling
Capacity Btu/h 12,300 19,100
Performance
(Nominal) kW 4.00 6.30
Heating
Btu/h 13,600 21,500
Panel model - - -
NOTE
1) Mode : HP(Heat Pump), HR(Heat Recovery)
2) Nominal Cooling : Indoor temperature 27ºCDB / 19ºCWB, Outdoor temperature 35ºCDB/24ºCWB, Refrigerant pipe length 7.5m, Level difference 0m.
3) Nominal Heating : Indoor temperature 20ºCDB / 15ºCWB, Outdoor temperature 7ºCDB / 6ºCWB, Refrigerant pipe length 7.5m, Level difference 0m.
4) Sound level was acquired in an anechoic room. Thus actual noise level may be different depending on the installation conditions.
5) These products contain R410A which is fluorinated greenhouse gas.
6) Specifications may be subject to change without prior notice.
1 Specifications
Duct S
Type DUCT S DUCT S
Model AM024KNHPKH/AZ AM030KNHPKH/AZ
Power Supply Φ , #, V, Hz 1,2,220-240,50/60 1,2,220-240,50/60
Mode - HP/HR HP/HR
kW 7.10 9.00
Cooling
Capacity Btu/h 24,200 30,700
Performance
(Nominal) kW 8.00 10.00
Heating
Btu/h 27,300 34,100
Panel model - - -
NOTE
1) Mode : HP(Heat Pump), HR(Heat Recovery)
2) Nominal Cooling : Indoor temperature 27ºCDB / 19ºCWB, Outdoor temperature 35ºCDB/24ºCWB, Refrigerant pipe length 7.5m, Level difference 0m.
3) Nominal Heating : Indoor temperature 20ºCDB / 15ºCWB, Outdoor temperature 7ºCDB / 6ºCWB, Refrigerant pipe length 7.5m, Level difference 0m.
4) Sound level was acquired in an anechoic room. Thus actual noise level may be different depending on the installation conditions.
5) These products contain R410A which is fluorinated greenhouse gas.
6) Specifications may be subject to change without prior notice.
1 Specifications
Duct S
Type DUCT S DUCT S DUCT S
Model AM036KNHPKH/AZ AM042KNHPKH/AZ AM048KNHPKH/AZ
Power Supply Φ , #, V, Hz 1,2,220-240,50/60 1,2,220-240,50/60 1,2,220-240,50/60
Mode - HP/HR HP/HR HP/HR
Drain pump - Drain Pump Included Drain Pump Included Drain Pump Included
Additional Drain pump
Max. lifting Height mm - - -
Accessories
Air Filter - - - -
NOTE
1) Mode : HP(Heat Pump), HR(Heat Recovery)
2) Nominal Cooling : Indoor temperature 27ºCDB / 19ºCWB, Outdoor temperature 35ºCDB/24ºCWB, Refrigerant pipe length 7.5m, Level difference 0m.
3) Nominal Heating : Indoor temperature 20ºCDB / 15ºCWB, Outdoor temperature 7ºCDB / 6ºCWB, Refrigerant pipe length 7.5m, Level difference 0m.
4) Sound level was acquired in an anechoic room. Thus actual noise level may be different depending on the installation conditions.
5) These products contain R410A which is fluorinated greenhouse gas.
6) Specifications may be subject to change without prior notice.
2 Capacity Table
Duct S
Cooling TC : Total Capacity, SHC : Sensible Heat Capacity
Indoor temperature (ºC, DB / WB)
Outdoor temperature 20 / 14 23 / 16 26 / 18 27 / 19 28 / 20 30 / 22 32 / 24
Model (ºC, DB) TC SHC TC SHC TC SHC TC SHC TC SHC TC SHC TC SHC
kW kW kW kW kW kW kW kW kW kW kW kW kW kW
10 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.30 2.50
12 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.30 2.50
14 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.30 2.50
16 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.30 2.50
18 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.20 2.50
20 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.20 2.50
21 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.20 2.50
23 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.20 2.50
012
25 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.20 2.50
27 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.20 2.50
29 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.20 2.50
31 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.20 2.50
33 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.20 2.50
35 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 4.00 2.60 4.20 2.50
37 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 3.90 2.60 4.20 2.50
39 2.50 2.00 2.90 2.30 3.40 2.60 3.60 2.60 3.70 2.60 3.90 2.60 4.10 2.50
10 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.30 4.20 6.70 4.10
12 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.30 4.20 6.70 4.10
14 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.70 4.10
16 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.60 4.10
18 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.60 4.10
20 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.60 4.10
21 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.60 4.10
23 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.60 4.10
018
25 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.60 4.10
27 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.60 4.10
29 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.60 4.10
31 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.60 4.10
33 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.60 4.10
35 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.20 4.20 6.60 4.10
37 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.10 4.20 6.50 4.10
39 3.90 3.40 4.60 3.90 5.30 4.10 5.60 4.20 5.80 4.20 6.10 4.20 6.40 4.10
10 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 8.00 5.60 8.50 5.30
12 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.50 5.30
14 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.50 5.30
16 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.40 5.30
18 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.40 5.30
20 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.40 5.30
21 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.40 5.30
23 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.40 5.30
024
25 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.40 5.30
27 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.40 5.30
29 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.40 5.30
31 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.40 5.30
33 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.40 5.30
35 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.90 5.60 8.40 5.30
37 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.80 5.60 8.20 5.20
39 4.90 4.30 5.80 5.00 6.70 5.20 7.10 5.40 7.40 5.60 7.70 5.60 8.10 5.20
10 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.40 7.20 10.10 7.20 10.80 7.00
12 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.40 7.20 10.10 7.20 10.80 7.00
14 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.70 7.00
16 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.70 7.00
18 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.60 7.00
20 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.60 7.00
21 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.60 7.00
23 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.60 7.00
030
25 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.60 7.00
27 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.60 7.00
29 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.60 7.00
31 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.60 7.00
33 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.60 7.00
35 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 10.00 7.20 10.60 7.00
37 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.30 7.20 9.90 7.20 10.40 7.00
39 6.20 5.70 7.30 6.50 8.40 6.90 9.00 7.10 9.20 7.20 9.70 7.10 10.20 7.00
10 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.50 8.60 13.40 8.40
12 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.50 8.60 13.40 8.40
14 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.50 8.60 13.30 8.40
16 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.50 8.60 13.30 8.40
18 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.40 8.60 13.20 8.40
20 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.40 8.60 13.20 8.40
21 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.40 8.60 13.20 8.40
23 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.40 8.60 13.20 8.40
036
25 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.40 8.60 13.20 8.40
27 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.40 8.60 13.20 8.40
29 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.40 8.60 13.20 8.40
31 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.40 8.60 13.20 8.40
33 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.40 8.60 13.20 8.40
35 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.40 8.60 13.20 8.40
37 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.60 8.80 12.30 8.60 13.00 8.40
39 7.70 6.80 9.10 7.80 10.50 8.30 11.20 8.60 11.50 8.80 12.10 8.50 12.70 8.30
2 Capacity Table
Duct S
Cooling TC : Total Capacity, SHC : Sensible Heat Capacity
Indoor temperature (ºC, DB / WB)
Outdoor temperature 20 / 14 23 / 16 26 / 18 27 / 19 28 / 20 30 / 22 32 / 24
Model (ºC, DB) TC SHC TC SHC TC SHC TC SHC TC SHC TC SHC TC SHC
kW kW kW kW kW kW kW kW kW kW kW kW kW kW
10 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.30 10.00 15.40 9.90
12 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.30 10.00 15.30 9.90
14 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.30 10.00 15.30 9.90
16 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.20 10.00 15.20 9.90
18 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.20 10.00 15.10 9.90
20 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.20 10.00 15.10 9.90
21 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.20 10.00 15.10 9.90
23 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.20 10.00 15.10 9.90
042
25 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.20 10.00 15.10 9.90
27 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.20 10.00 15.10 9.90
29 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.20 10.00 15.10 9.90
31 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.20 10.00 15.10 9.90
33 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.20 10.00 15.10 9.90
35 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.30 10.10 14.20 10.00 15.10 9.90
37 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.20 10.10 14.00 10.00 14.90 9.90
39 8.80 7.80 10.40 8.90 12.00 9.50 12.80 9.90 13.10 10.10 13.80 10.00 14.50 9.80
10 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.60 11.00 15.70 11.00 16.80 11.00
12 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.60 11.00 16.70 11.00
14 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.60 11.00 16.70 11.00
16 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.60 11.00 16.60 11.00
18 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.50 11.00 16.60 11.00
20 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.50 11.00 16.50 11.00
21 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.50 11.00 16.50 11.00
23 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.50 11.00 16.50 11.00
048
25 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.50 11.00 16.50 11.00
27 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.50 11.00 16.50 11.00
29 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.50 11.00 16.50 11.00
31 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.50 11.00 16.50 11.00
33 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.50 11.00 16.50 11.00
35 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.50 11.00 16.50 11.00
37 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.50 11.00 15.40 11.00 16.30 11.00
39 9.70 8.60 11.40 9.60 13.10 10.40 14.00 10.80 14.40 11.00 15.10 10.90 15.90 10.90
2 Capacity Table
Duct S
Heating TC : Total Capacity
Indoor temperature (ºC, DB)
Outdoor temperature (ºC) 16.0 18.0 20.0 22.0 24.0
Model
TC TC TC TC TC
DB WB kW kW kW kW kW
-20 -21 2.40 2.40 2.30 2.30 2.30
-17 -18 2.60 2.50 2.40 2.40 2.30
-15 -16 2.70 2.60 2.50 2.50 2.40
-12 -13 2.80 2.70 2.70 2.60 2.60
-10 -11 2.90 2.90 2.90 2.80 2.80
-7 -8 3.10 3.10 3.00 3.00 2.90
-5 -6 3.30 3.20 3.20 3.10 3.00
-3 -4 3.40 3.40 3.30 3.20 3.10
012
0 -1 3.60 3.60 3.50 3.40 3.20
3 2 3.80 3.70 3.70 3.50 3.40
5 4 3.90 3.90 3.80 3.60 3.40
7 6 4.10 4.10 4.00 3.70 3.40
9 8 4.20 4.10 4.00 3.70 3.40
11 10 4.40 4.20 4.00 3.70 3.40
13 12 4.50 4.20 4.00 3.70 3.40
15 14 4.60 4.30 4.00 3.70 3.40
-20 -21 3.90 3.80 3.80 3.70 3.70
-17 -18 4.00 4.00 3.90 3.80 3.80
-15 -16 4.20 4.10 4.00 3.90 3.80
-12 -13 4.40 4.30 4.20 4.20 4.10
-10 -11 4.60 4.60 4.50 4.40 4.40
-7 -8 4.90 4.80 4.80 4.70 4.50
-5 -6 5.20 5.10 5.00 4.90 4.70
-3 -4 5.40 5.30 5.30 5.10 4.90
018
0 -1 5.70 5.60 5.50 5.30 5.00
3 2 5.90 5.90 5.80 5.60 5.30
5 4 6.20 6.10 6.00 5.70 5.30
7 6 6.50 6.40 6.30 5.80 5.30
9 8 6.70 6.50 6.30 5.80 5.30
11 10 6.90 6.60 6.30 5.80 5.30
13 12 7.10 6.70 6.30 5.80 5.30
15 14 7.30 6.80 6.30 5.80 5.30
-20 -21 4.90 4.90 4.80 4.70 4.70
-17 -18 5.10 5.00 4.90 4.80 4.80
-15 -16 5.30 5.20 5.10 4.90 4.80
-12 -13 5.60 5.50 5.40 5.30 5.20
-10 -11 5.90 5.80 5.70 5.60 5.60
-7 -8 6.20 6.10 6.00 5.90 5.80
-5 -6 6.50 6.50 6.40 6.20 6.00
-3 -4 6.90 6.80 6.70 6.40 6.20
024
0 -1 7.20 7.10 7.00 6.70 6.40
3 2 7.60 7.50 7.30 7.10 6.80
5 4 7.90 7.80 7.70 7.20 6.80
7 6 8.20 8.10 8.00 7.40 6.80
9 8 8.50 8.20 8.00 7.40 6.80
11 10 8.70 8.40 8.00 7.40 6.80
13 12 9.00 8.50 8.00 7.40 6.80
15 14 9.20 8.60 8.00 7.40 6.80
-20 -21 6.00 6.00 5.90 5.80 5.80
-17 -18 6.30 6.30 6.10 6.00 5.90
-15 -16 6.70 6.50 6.30 6.10 6.00
-12 -13 7.00 6.90 6.70 6.60 6.50
-10 -11 7.30 7.20 7.10 7.00 7.00
-7 -8 7.80 7.70 7.60 7.40 7.20
-5 -6 8.20 8.10 8.00 7.70 7.50
-3 -4 8.60 8.50 8.40 8.10 7.70
030
0 -1 9.00 8.90 8.80 8.40 8.00
3 2 9.40 9.30 9.20 8.80 8.40
5 4 9.90 9.70 9.60 9.00 8.40
7 6 10.30 10.10 10.00 9.20 8.40
9 8 10.60 10.30 10.00 9.20 8.40
11 10 10.90 10.50 10.00 9.20 8.40
13 12 11.20 10.60 10.00 9.20 8.40
15 14 11.60 10.80 10.00 9.20 8.40
-20 -21 7.40 7.40 7.30 7.30 7.30
-17 -18 8.00 7.80 7.60 7.50 7.40
-15 -16 8.40 8.10 7.90 7.70 7.50
-12 -13 8.80 8.60 8.40 8.20 8.10
-10 -11 9.20 9.00 8.90 8.80 8.70
-7 -8 9.70 9.60 9.40 9.20 9.00
-5 -6 10.20 10.10 9.90 9.60 9.30
-3 -4 10.70 10.60 10.50 10.10 9.70
036
0 -1 11.30 11.10 11.10 10.50 10.00
3 2 11.80 11.60 11.50 11.00 10.60
5 4 12.30 12.20 12.00 11.30 10.60
7 6 12.90 12.70 12.50 11.50 10.60
9 8 13.30 12.90 12.50 11.50 10.60
11 10 13.70 13.10 12.50 11.50 10.60
13 12 14.00 13.30 12.50 11.50 10.60
15 14 14.40 13.50 12.50 11.50 10.60
2 Capacity Table
Duct S
Heating TC : Total Capacity
Indoor temperature (ºC, DB)
Outdoor temperature (ºC) 16.0 18.0 20.0 22.0 24.0
Model
TC TC TC TC TC
DB WB kW kW kW kW kW
-20 -21 8.10 8.10 8.00 8.00 8.00
-17 -18 8.70 8.50 8.40 8.30 8.10
-15 -16 9.20 9.00 8.70 8.50 8.20
-12 -13 9.70 9.50 9.30 9.10 8.90
-10 -11 10.10 10.00 9.90 9.70 9.60
-7 -8 10.70 10.60 10.40 10.20 10.00
-5 -6 11.30 11.10 11.00 10.70 10.30
-3 -4 11.90 11.70 11.50 11.10 10.70
042
0 -1 12.40 12.30 12.10 11.60 11.00
3 2 13.00 12.90 12.70 12.20 11.70
5 4 13.60 13.40 13.20 12.40 11.70
7 6 14.20 14.00 13.80 12.70 11.70
9 8 14.60 14.20 13.80 12.70 11.70
11 10 15.10 14.40 13.80 12.70 11.70
13 12 15.50 14.70 13.80 12.70 11.70
15 14 15.90 14.90 13.80 12.70 11.70
-20 -21 9.50 9.50 9.40 9.40 9.30
-17 -18 10.10 9.90 9.60 9.60 9.40
-15 -16 10.70 10.40 10.10 9.80 9.50
-12 -13 11.20 11.00 10.80 10.60 10.30
-10 -11 11.70 11.60 11.40 11.30 11.10
-7 -8 12.40 12.20 12.10 11.80 11.50
-5 -6 13.10 12.90 12.70 12.30 12.00
-3 -4 13.80 13.60 13.40 12.90 12.40
048
0 -1 14.40 14.20 14.00 13.40 12.80
3 2 15.10 14.90 14.70 14.10 13.50
5 4 15.80 15.60 15.30 14.40 13.50
7 6 16.50 16.20 16.00 14.80 13.50
9 8 17.00 16.50 16.00 14.80 13.50
11 10 17.50 16.70 16.00 14.80 13.50
13 12 18.00 17.00 16.00 14.80 13.50
15 14 18.50 17.20 16.00 14.80 13.50
3 Dimensional Drawing
Duct S
AM012/018/024KNHPKH/AZ
3 Dimensional Drawing
Duct S
AM030KNHPKH/AZ
3 Dimensional Drawing
Duct S
AM036/042/048KNHPKH/AZ
4 Electrical Wiring Diagram
Duct S
AM012/018/024/030/036/042/048KNHPKH/AZ
MAIN PBA Printed Circuit Board(MAIN) M[BLDC] Mortor for fan F100 T5A 250V FUSE (MAIN PBA)
BLDC DRIVER PBA Printed Circuit Board(BLDC Mortor) EEV electronic expansion valve F701 T5A 250V FUSE(BLDC DRIVER PBA)
DISCHARGE(10K) Thermistor DISCHARGE(10K) EVA-IN(10K) Thermistor EVA IN(10K) EVA-OUT(10K) Thermistor EVA OUT(10K)
NOTE
1. This wiring diagram applies only to the indoor unit.
2. Symbols show as follow;
BLK : black, RED : red, BLU : blue, WHT:white, YEL : yellow, BRN : brown, SKY : sky-blue, GRN : green
3. For connection wiring indoor-outdoor transmission F1-F2, indoor-wired remotecontroller transmission F3-F4.
4. Protective earth(screw)
5 Sound Pressure Level
Duct S
Unit: dB(A)
Discharge Suction Model High Low
Duct Duct
AM012KNHPKH/AZ 32 26
2m 2m
AM018KNHPKH/AZ 33 27
1.5m AM024KNHPKH/AZ 37 29
Microphone AM030KNHPKH/AZ 38 32
Note
Specifications may be subject to change without prior notice.
Sound pressure level is obtained in an anechoic room.
Sound pressure level is a relative value, depending on the distance and acoustic environment.
Sound pressure level may differ depending on operation condition.
dBA = A-weighted sound pressure level
Reference acoustic pressure 0 dB= 20 uPa
NC curve
1) AM012KNHPKH/AZ 2) AM018KNHPKH/AZ
60 60 60 60
NC 60 NC 60
55 55 55 55
NC 55 NC 55
Sound Pressure Level (dB)
50 50 50 50
NC 50 NC 50
45 45 45 45
NC 45 NC 45
40 High 40 40 40
Mid NC 40 High NC 40
35 Low 35 35 Mid
35
NC 35 NC 35
30 30 30 Low 30
NC 30 NC 30
25 25 25 25
20 NC 25 20 20 NC 25 20
15 NC 20 15 15 NC 20 15
10 NC 15 10 10 NC 15 10
5 5 5 5
0 0 0 0
63 125 250 500 1000 2000 4000 8000 63 125 250 500 1000 2000 4000 8000
Octave Band Center Frequency(Hz) Octave Band Center Frequency(Hz)
3) AM024KNHPKH/AZ 4) AM030KNHPKH/AZ
60 60 60 60
NC 60 NC 60
55 55 55 55
NC 55 NC 55
Sound Pressure Level (dB)
50 50 50 50
NC 50 NC 50
45 45 45 High 45
NC 45 Mid NC 45
40 High 40 40 Low 40
NC 40 NC 40
35 Mid 35 35 35
Low
NC 35 NC 35
30 30 30 30
NC 30 NC 30
25 25 25 25
20 NC 25 20 20 NC 25 20
15 NC 20 15 15 NC 20 15
10 NC 15 10 10 NC 15 10
5 5 5 5
0 0 0 0
63 125 250 500 1000 2000 4000 8000 63 125 250 500 1000 2000 4000 8000
Octave Band Center Frequency(Hz) Octave Band Center Frequency(Hz)
5 Sound Pressure Level
Duct S
Unit: dB(A)
Discharge Suction Model High Low
Duct Duct
AM036KNHPKH/AZ 38 32
2m 2m
AM042KNHPKH/AZ 39 32
1.5m AM048KNHPKH/AZ 40 32
Microphone
Note
Specifications may be subject to change without prior notice.
Sound pressure level is obtained in an anechoic room.
Sound pressure level is a relative value, depending on the distance and acoustic environment.
Sound pressure level may differ depending on operation condition.
dBA = A-weighted sound pressure level
Reference acoustic pressure 0 dB= 20 uPa
NC curve
5) AM036KNHPKH/AZ 6) AM042KNHPKH/AZ
60 60 60 60
NC 60 NC 60
55 55 55 55
NC 55 NC 55
Sound Pressure Level (dB)
50 50 50 50
NC 50 NC 50
45 45 45 45
High NC 45 High NC 45
40 40 40 Mid 40
Mid
Low NC 40 Low NC 40
35 35 35 35
NC 35 NC 35
30 30 30 30
NC 30 NC 30
25 25 25 25
20 NC 25 20 20 NC 25 20
15 NC 20 15 15 NC 20 15
10 NC 15 10 10 NC 15 10
5 5 5 5
0 0 0 0
63 125 250 500 1000 2000 4000 8000 63 125 250 500 1000 2000 4000 8000
Octave Band Center Frequency(Hz) Octave Band Center Frequency(Hz)
7) AM048KNHPKH/AZ
60 60
NC 60
55 55
NC 55
Sound Pressure Level (dB)
50 50
NC 50
45 45
High
NC 45
40 Mid 40
Low NC 40
35 35
NC 35
30 30
NC 30
25 25
20 NC 25 20
15 NC 20 15
10 NC 15 10
5 5
0 0
63 125 250 500 1000 2000 4000 8000
Octave Band Center Frequency(Hz)
6 Fan Characteristics
Duct S
1) AM012KNHPKH/AZ
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
1 2
0≤SP≤2.5 010054-1C5081-202424-331205 2.5<SP≤5 010054-1C50E3-202424-331205
External Static Pressure [mmAq]
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
3 4
5<SP≤7.5 010054-1C5459-202424-331205 7.5<SP≤10 010054-1C54CD-202424-331205
External Static Pressure [mmAq]
18 18
16 16
14 14
Upper limit of
12 12 HIGH external
Upper limit of static pressure
10 external 10
HIGH static pressure MID 4
8 8 Lower limit of
MID 3
6 6 external
Lower limit of LOW static pressure
LOW external
4 4
static pressure
2 2
0 0
0 5 10 15 20 25 30 0 5 10 15 20 25 30
Air Flow Rate [CMM] Air Flow Rate [CMM]
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
5 6
10<SP≤12.5 010054-1C5931-202424-331205 12.5<SP≤15 010054-1C5983-202424-331205
Upper limit of
External Static Pressure [mmAq]
18 18 HIGH
external
16 Upper limit of 16 static pressure
HIGH
external 6
14 static pressure 14
MID Lower limit of
12 5 12 external
MID Lower limit of
10 10 static pressure
external
8 static pressure 8 LOW
LOW
6 6
4 4
2 2
0 0
0 5 10 15 20 25 30 0 5 10 15 20 25 30
Note
Adjust option code according to the actual installation condition (external static pressure).
The graphs display the available external static pressure range of installed indoor units. Therefore, they do notreflect the actual change
of external static pressure and airflow rate according to adjusted airflow (High-Mid-Low) ofinstalled indoor units.
6 Fan Characteristics
Duct S
2) AM018KNHPKH/AZ
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
1 2
0≤SP≤3 010054-1C50F1-203838-331203 3<SP≤6 010054-1C5447-203838-331203
External Static Pressure [mmAq]
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
3 4
6<SP≤9 010054-1C54AB-203838-331203 9<SP≤12 010054-1C581F-203838-331203
External Static Pressure [mmAq]
18 18
16 16 HIGH
Upper limit of
HIGH external
14 14 static pressure
12 Upper limit of 12 MID
MID external 4
10 static pressure 10 Lower limit of
8 3 8 external
LOW static pressure
6 Lower limit of 6 LOW
external
4 static pressure 4
2 2
0 0
5 10 15 20 25 30 35 40 5 10 15 20 25 30 35 40
Air Flow Rate [CMM] Air Flow Rate [CMM]
18 Upper limit of
HIGH external
16 static pressure
14 MID
5
12 Lower limit of
external
10 static pressure
8 LOW
6
4
2
0
5 10 15 20 25 30 35 40
Note
Adjust option code according to the actual installation condition (external static pressure).
The graphs display the available external static pressure range of installed indoor units. Therefore, they do notreflect the actual change
of external static pressure and airflow rate according to adjusted airflow (High-Mid-Low) ofinstalled indoor units.
6 Fan Characteristics
Duct S
3) AM024KNHPKH/AZ
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
1 2
0≤SP≤3 010054-1C548D-204747-331201 3<SP≤6 010054-1C55E1-204747-331201
External Static Pressure [mmAq]
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
3 4
6<SP≤9 010054-1C5935-204747-331201 9<SP≤12 010054-1C5989-204747-331201
External Static Pressure [mmAq]
18 18
HIGH
16 16 Upper limit of
14 HIGH 14 external
MID static pressure
12 Upper limit of 12
external 4
10 MID static pressure 10 Lower limit of
external
8 3 8 LOW static pressure
6 LOW Lower limit of 6
external
4 static pressure 4
2 2
0 0
10 15 20 25 30 35 40 10 15 20 25 30 35 40
Upper limit of
External Static Pressure [mmAq]
18 HIGH external
16 static pressure
MID
14 5
Lower limit of
12 LOW external
10 static pressure
8
6
4
2
0
10 15 20 15 30 35 40
Note
Adjust option code according to the actual installation condition (external static pressure).
The graphs display the available external static pressure range of installed indoor units. Therefore, they do notreflect the actual change
of external static pressure and airflow rate according to adjusted airflow (High-Mid-Low) ofinstalled indoor units.
6 Fan Characteristics
Duct S
4) AM030KNHPKH/AZ
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
1 2
0≤SP≤4 010054-1C546D-205A5A-331212 4<SP≤8 010054-1C55E3-205A5A-331212
External Static Pressure [mmAq]
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
3 4
8<SP≤12 010054-1C5969-205A5A-331212 12<SP≤15 010054-1C59CD-205A5A-331212
Upper limit of
External Static Pressure [mmAq]
18 18 HIGH
external
16 16 static pressure
HIGH Upper limit of MID
14 external 14 4
static pressure Lower limit of
12 MID 12
3 external
LOW static pressure
10 Lower limit of 10
LOW
8 external 8
static pressure
6 6
4 4
2 2
0 0
10 15 20 25 30 35 40 10 15 20 25 30 35 40
Note
Adjust option code according to the actual installation condition (external static pressure).
The graphs display the available external static pressure range of installed indoor units. Therefore, they do notreflect the actual change
of external static pressure and airflow rate according to adjusted airflow (High-Mid-Low) ofinstalled indoor units.
6 Fan Characteristics
Duct S
5) AM036KNHPKH/AZ
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
1 2
3≤SP≤6.2 010054-1C5446-207070-331226 6.2<SP≤9 010054-1C54A7-207070-331226
25 25
External Static Pressure [mmAq]
15 15
HIGH Upper limit of
external
HIGH Upper limit of static pressure
10 external 10
MID 2
static pressure
MID Lower limit of
5 1 Lower limit of 5 LOW external
LOW external static pressure
static pressure
0 0
10 15 20 25 30 35 40 45 50 55 10 15 20 25 30 35 40 45 50 55
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
3 4
9<SP≤11 010054-1C54C9-207070-331226 11<SP≤13 010054-1C580B-207070-331226
25 25
External Static Pressure [mmAq]
20 20
HIGH Upper limit of
external
15 HIGH Upper limit of 15 static pressure
external
static pressure 4
MID
10 MID 3 10
Lower limit of
Lower limit of external
LOW external LOW
5 5 static pressure
static pressure
0 0
10 15 20 25 30 35 40 45 50 55 10 15 20 25 30 35 40 45 50 55
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
5 6
13<SP≤15 010054-1C584D-207070-331226 15<SP≤17 010054-1C587F-207070-331226
25 25
External Static Pressure [mmAq]
Upper limit of
HIGH external
20 Upper limit of 20
HIGH external static pressure
static pressure 6
15 5 15 MID
MID
Lower limit of
10 Lower limit of 10 external
external LOW static pressure
LOW static pressure
5 5
0 0
10 15 20 25 30 35 40 45 50 55 10 15 20 25 30 35 40 45 50 55
Note
Adjust option code according to the actual installation condition (external static pressure).
The graphs display the available external static pressure range of installed indoor units. Therefore, they do notreflect the actual change
of external static pressure and airflow rate according to adjusted airflow (High-Mid-Low) ofinstalled indoor units.
6 Fan Characteristics
Duct S
5) AM036KNHPKH/AZ
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
7 8
17<SP≤19 010054-1C59A1-207070-331226 19<SP≤20 010054-1C59B2-207070-331226
25 25 Upper limit of
External Static Pressure [mmAq]
5 5
0 0
10 15 20 25 30 35 40 45 50 55 10 15 20 25 30 35 40 45 50 55
Note
Adjust option code according to the actual installation condition (external static pressure).
The graphs display the available external static pressure range of installed indoor units. Therefore, they do notreflect the actual change
of external static pressure and airflow rate according to adjusted airflow (High-Mid-Low) ofinstalled indoor units.
6 Fan Characteristics
Duct S
6) AM042KNHPKH/AZ
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
1 2
3≤SP≤6.2 010054-1C5466-208080-331225 6.2<SP≤9 010054-1C54B9-208080-331225
25 25
External Static Pressure [mmAq]
15 15
Upper limit of
HIGH external
Upper limit of static pressure
10 HIGH external 10 MID 2
static pressure
MID
1
5 LOW Lower limit of 5 LOW
Lower limit of
external external
static pressure static pressure
0 0
10 15 20 25 30 35 40 45 50 55 10 15 20 25 30 35 40 45 50 55
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
3 4
9<SP≤11 010054-1C54EC-208080-331225 11<SP≤13 010054-1C581E-208080-331225
25 25
External Static Pressure [mmAq]
20 20
Upper limit of
Upper limit of HIGH external
15 external 15 static pressure
HIGH
static pressure 4
MID
MID 3
10 10
Lower limit of
Lower limit of LOW external
LOW static pressure
5 external 5
static pressure
0 0
10 15 20 25 30 35 40 45 50 55 10 15 20 25 30 35 40 45 50 55
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
5 6
13<SP≤15 010054-1C5940-208080-331225 15<SP≤17 010054-1C5982-208080-331225
25 25
External Static Pressure [mmAq]
Upper limit of
20 Upper limit of 20 external
HIGH static pressure
HIGH external
static pressure 6
15 5 15 MID
MID Lower limit of
Lower limit of external
10 external 10 static pressure
LOW static pressure LOW
5 5
0 0
10 15 20 25 30 35 40 45 50 55 10 15 20 25 30 35 40 45 50 55
Note
Adjust option code according to the actual installation condition (external static pressure).
The graphs display the available external static pressure range of installed indoor units. Therefore, they do notreflect the actual change
of external static pressure and airflow rate according to adjusted airflow (High-Mid-Low) ofinstalled indoor units.
6 Fan Characteristics
Duct S
7) AM048KNHPKH/AZ
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
1 2
3≤SP≤6.2 010054-1C5486-208C8C-331224 6.2<SP≤9 010054-1C54D7-208C8C-331224
25 25
External Static Pressure [mmAq]
15 15
HIGH Upper limit of
Upper limit of external
HIGH external static pressure
10
static pressure 10
MID MID 2
1 Lower limit of
5 Lower limit of
LOW external 5 external
LOW static pressure
static pressure
0
10 15 20 25 30 35 40 45 50 55 0
10 15 20 25 30 35 40 45 50 55
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
3 4
9<SP≤11 010054-1C5809-208C8C-331224 11<SP≤13 010054-1C583B-208C8C-331224
25 25
External Static Pressure [mmAq]
20 20
Upper limit of
HIGH external
Upper limit of
15 HIGH external 15 static pressure
static pressure 4
3 MID
10 MID 10
Lower limit of
LOW external
5 LOW Lower limit of 5 static pressure
external
static pressure
0 0
10 15 20 25 30 35 40 45 50 55 10 15 20 25 30 35 40 45 50 55
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
5 6
13<SP≤15 010054-1C586D-208C8C-331224 15<SP≤17 010054-1C588F-208C8C-331224
25 25
External Static Pressure [mmAq]
Upper limit of
HIGH external
20 Upper limit of 20 static pressure
HIGH external
static pressure 6
15 5 15 MID
MID Lower limit of
Lower limit of external
10 external 10 static pressure
static pressure LOW
LOW
5 5
0 0
10 15 20 25 30 35 40 45 50 55 10 15 20 25 30 35 40 45 50 55
Note
Adjust option code according to the actual installation condition (external static pressure).
The graphs display the available external static pressure range of installed indoor units. Therefore, they do notreflect the actual change
of external static pressure and airflow rate according to adjusted airflow (High-Mid-Low) ofinstalled indoor units.
6 Fan Characteristics
Duct S
7) AM048KNHPKH/AZ
External Static Pressure(mmAq) Option Code External Static Pressure(mmAq) Option Code
7 8
17<SP≤19 010054-1C59C0-208C8C-331224 19<SP≤20 010054-1C59D1-208C8C-331224
25 25 Upper limit of
Upper limit of external
External Static Pressure [mmAq]
5 5
0 0
0 15 20 25 30 35 40 45 50 55 10 15 20 25 30 35 40 45 50 55
Note
Adjust option code according to the actual installation condition (external static pressure).
The graphs display the available external static pressure range of installed indoor units. Therefore, they do notreflect the actual change
of external static pressure and airflow rate according to adjusted airflow (High-Mid-Low) ofinstalled indoor units.