You are on page 1of 28

SAB 157 HR

Screw compressor unit

S pa re p ar t s m an ual

en
 
Contents

1. Spare part list SAB 157 2


1.1.1 How to use the spare parts list 2
1.1.2 Recommended spare parts 5
1.1.3 General arrangement SAB 157 6
1.1.4 Screw compressor, typical 8
1.1.5 Oil separator, typical 10
1.1.6 Oil filter - single, typical 12
1.1.7 Oil cooler piping, typical 14
1.1.8 Suction/discharge/service/stop valve, typical 16
1.1.9 Spare parts list for all suction/discharge/service/stop
valves 17
1.1.10 Discharge stop/check valve 18
1.1.11 Coupling assembly 20
1.1.12 Piping and instrumentation, typical 21
1.1.13 Compressor port locations 24

2. Numerical parts list 26

Spare parts manual - SAB 157


010105 - en 2013.09 1/26
Spare part list SAB 157

1. Spare part list SAB 157


1.1.1 How to use the spare parts list
SAB Rotary screw compressor unit
This spare parts list applies to standard Sabroe rotary screw compressor units,
models SAB 157.
Units built with special options, modifications or conversions are not considered.
Item numbers only apply to units with PED (Pressure Equipment Directive 97/23/EC) approval
when this is relevant.
Concerning rotary screw compressors (models SGC) and Unisab control systems, please refer
to the specific spare parts lists.
The spare parts list provides identification for detail parts by Figure and Index number (Fig-
Index column), Item number and Description.
To find the correct replacement item, locate the item in Figure 1, 2, etc. Note the Index num-
ber and refer to the corresponding Fig-Index in the spare parts list to see Item number and
Description.
Consider that some parts depend on voltage, set pressure etc. and that your unit may have a
special modification.
Some figure numbers are not applicable for this spare parts list, eg figures 11 and 15 and are
therefore excluded.
Quantity per assembly or item is stated in the Qty. column and always applies to each unit
unless otherwise specified. If the quantity is 0 (zero) this either means that the Item number
is included as information only or it may be that the actual quantity is stated elsewhere eg
under Description or in a footnote.
Some of the Item Numbers are included for information purposes only and are not usually
considered spare parts.
If the word “Assembly” (not the abbreviation “Ass.”) is included in Description, the Item num-
ber may be included for information purposes only and is not necessarily a spare part. Please
contact Refrigeration Parts Centre for more information.
The P&I Ref. column contains the connection designation of the item as shown in a typical P&I
diagram (see fig. 16) as well as the P&I diagram of your particular unit when this is relevant.
A reference like P128 means item no. 128 and can only be seen in your specific P&I diagram.
Unit of measure in the Description column etc. is always stated in SI-units unless otherwise
specified, eg subfixed “ if in inches.
American drawing standards, third angle projection method, are used in all figures.
The Numerical parts list at the end of the manual can be used to locate a specific item in
the spare parts list. Look for the part by Item number and it will refer to the Figure and Index
number (Fig-Index column) where it is located.
Abbreviations for more than one item or model eg:
SAB 157
LG-1/2/3 means LG-1 + LG-2 + LG-3 on P&I diagram

Spare parts manual - SAB 157


2/26 010105 - en 2013.09
Spare part list SAB 157

Abbreviations in this manual include:


Ang. angle OD= outside diameter equal to

Ass. assembly Rc. cooling medium refrigerant

Cp. compressor Reg regulating

DN (+space) nominal diameter Sc. seal cap

f. for Ser. service

g gauge Str. straight

Hex. hexagon Wc. cooling medium water

ID= inside diameter equal to ø diameter (ISO-standard)

L= length equal to

N/A not applicable or


not available

The unit pipe system name plate (example below) listing unit pipe system type, year and
identification number etc., is attached to the frame below the compressor.
Note: Please provide Sabroe unit pipe system type, year and identification number
when requesting a quotation or placing an order. Failure to include this information
may delay the processing of your request.

Spare parts manual - SAB 157


010105 - en 2013.09 3/26
Spare part list SAB 157

Spare parts manual - SAB 157


4/26 010105 - en 2013.09
Spare part list SAB 157

1.1.2 Recommended spare parts


Note: There is no specific drawing for this figure. This list is based on one typical unit.
Consider that your unit may have special modifications. When stocking for more than one
unit, the quantity should be adjusted to meet your individual requirements.

40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR
Item
P&I Ref. Description Qty.
number

531B0099H01 Coalescer filter 34" (A) 3 X X


531B0099H01-
Coalescer filter 34" (A) 3 X X X
PA
O-ring ø380,37 x 5,33,
1331.605 1 X X X X X
Manway
0355606 Gasket 1 X X X X X
959A0053H01 Gasket 7 13/16" x 1/8" 1 X X X X X
195 531A0218H02 Element, SuperFilter II 1 X X
531A0218H02-
195 Element, SuperFilter II 1 X X X
PA
Temperature sensor incl.
TE-1/2/3 1373.346 1 X X X X X
pocket, L=130
Temperature sensor,
TE-1/2/3 1377.441 1 X X X X X
L=130 (I)
Temperature sensor incl.
TE-4 1373.345 1 X X X X X
pocket, L=95
Temperature sensor,
TE-4 1377.442 1 X X X X X
L=95 (I)
Seal ring,
TE-1/2/3/4 1349.135 bonded for G 1/4 A (H) 1 X X X X X
(for pocket sealing purpose)
Pressure transducer
PE-1/2/3 1373.333 1 X X X X X
-1 to 59 bar
Pressure transducer
PE-4 1373.338 1 X X X X X
-1 to 25 bar
HTR-1/2 1555.097 Oil heater, 1000W/240V 1 X X X X X
HTR-1/2 1555.095 Oil heater, 1000W/120V 1 X X X X X
1349.135 Seal ring, bonded, for G1/4 A 1 X X X X X
1372.404 Control Valve Block 240V 1 X X X X X
1372.409 Control Valve Block 120V 1 X X X X X
534C2342H01 Gasket, subplate 1 X X X X X
1336.045 Gasket 3”, 600lb 2 X X X X X
1336.081 Spiral Gasket 3”, 600lb 1 X X X X X
1336.080 Spiral Gasket 4”, 400lb 1 X X X X X
1336.082 Spiral Gasket 4”, 600lb 2 X X X X X
2356.265 Gasket 82/42x2 3 X X X X X
Kit, Disc pack including all
720C0078H11 1 X X X X X
fasteners
LG-1/2/3 1226.036 Sight glass 1" 3 X X X X X
LG-1/2/3 0357696 Dowty-ring 42,8/33,89x3,4 3 X X X X X

I) Repair kit complete (sensor insert with connector) excluding pocket

Spare parts manual - SAB 157


010105 - en 2013.09 5/26
Spare part list SAB 157

1.1.3 General arrangement SAB 157

3 NOT SHOWN: 2, 7
6
1

8
9
Fig. 1: Drawing for list 01

Spare parts manual - SAB 157


6/26 010105 - en 2013.09
Spare part list SAB 157

List 01

40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR
Fig - Item
P&I Ref. Description Qty.
Index number

See further information f.


01-1 INF compressor in Fig. 2 or serv- 1 X X X X X
ice part list f. SGC Cp
See further information for
01-2 INF 1 X X X X X
coupling in Fig. 8
See further information for
01-3 INF 1 X X X X X
motor in operating manual
01-04 200 3447.649 Oil return valve 1 X X X X X
See further information in the
01-5 INF 0 X X X X X
Unisab manual
Fig. 6 concerns suction stop
01-6 SUC
and check valves (J)
01-06 114/NV-3 1361.117 Stop valve 1 X X X X
01-06 114/NV-3 1361.182 Stop valve 1 X
01-06 115 1364.022 Check valve 1 X X X X X
01-06 158/PE-4 1373.338 Pressure transducer 1 X X X X X
01-06 101 1361.234 Suction stop valve 1 X X X X x
01-06 151/TE-1 1373.346 Temperature sensor 1 X X X X X
01-06 129/CV-1 1364.508 Non-return valve, suction 1 X X X X X
01-06 129 1336.082 Spiral Gasket 4" 600 LB 2 X X X X X
Fig. 7 concerns discharge
01-07 DIS
stop and check valves (J) (Q)
01-07 107 1361.133 Purge valve 1 X X X X
01-07 107 1361.182 Purge valve 1 X
01-07 126 1372.601 Pressure control valve 1 X X
01-07 126 1364.509 Discharge check valve 1 X X X X X
Gasket 3" 300/600 LB,
01-07 126 1336.045 1.5 mm plane bearing 2 X X X X X
surface
01-07 102 1361.195 Discharge stop valve 1 X X X X
01-07 102 1361.183 Discharge stop valve 1 X
See further information for
01-8 INF 1 X X X X X
single oil filter in Fig. 4
See further information for
01-9 INF 1 X X X X X
oil separator in Fig. 3
J) Spare parts kits and sets for stop valve in Fig. 6
Q) Spare parts kits sets for check valve in Fig. 7

Spare parts manual - SAB 157


010105 - en 2013.09 7/26
Spare part list SAB 157

1.1.4 Screw compressor, typical

3
2

10 7 9
8

4 5 6
Fig. 2: Drawing for list 02

Spare parts manual - SAB 157


8/26 010105 - en 2013.09
Spare part list SAB 157

List 02

40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR
Fig - Item
P&I Ref. Description Qty.
Index number

Compressor HPSH 1510


02- 191 534E1232G01 1 X X X X X
VI 1.7
Compressor HPSH 1510
02- 191 534E1232G02 1 X X X X X
VI 2.2
Compressor HPSH 1510
02- 191 534E1232G03 1 X X X X X
VI 2.9
Compressor HPSH 1510
02- 191 534E1232G04 1 X X X X X
VI 4.0
02-01 INF Pos. 13 from (P) 0 X X X X X
02-02 INF Pos. 58 from (P) 0 X X X X X
02-03 INF Pos. 74 from (P) 0 X X X X X
02-04 1336.081 Spiral Gasket 3", 600lb 1 X X X X X
02-05 INF Pos. 67 from (P) 0 X X X X X
02-06 INF Pos. 70 from (P) 0 X X X X X
02-07 1336.080 Spiral Gasket 4", 600lb 1 X X X X X
02-08 INF Pos. 39 from (P) 0 X X X X X
02-09 INF Pos. 68 from (P) 0 X X X X X
02-10 1372.404 Control Valve Block 240V 1 X X X X X
02-10 1372.409 Control Valve Block 120V 1 X X X X X
02-10 534C2342H01 Gasket, subplate 1 X X X X X
P) See further information in Service Part List for SGC compressor (070.750-SPL1 Oct '12)

Spare parts manual - SAB 157


010105 - en 2013.09 9/26
Spare part list SAB 157

1.1.5 Oil separator, typical

10, 13, 14, 15

SECTION A--A
11
10 8
1213
1

7
6

A 2

2 5 4 3 4 16

Fig. 3: Drawing for list 03

List 03
40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR

Fig - Item
P&I Ref. Description Qty.
Index number

Assembly,
03- PV-1 0357677.PED 1 X X X X X
Oil separator OHU 06026
O-ring ø380,37 x 5,33,
03-01 1331.605 1 X X X X X
Manway
03-02 LG-1/2/3 1226.036 Sight glass 1" 3 X X X X X
03-02 LG-1/2/3 0357696 Dowty-ring 42,8/33,89x3,4 3 X X X X X
03-03 154/TE-4 1373.345 Temperature sensor, L=95 1 X X X X X
03-04 161/162 1555.097 Oil heater, 1000W/240V 2 X X X X X
03-04 HTR-1/2 1555.095 Oil heater, 1000W/120V 2 X X X X X
03-05 1349.135 Seal ring, bonded, for G1/4 A 2 X X X X X
Oil level switch low,
03-05 160 1553.422 1 X X
standard

Spare parts manual - SAB 157


10/26 010105 - en 2013.09
Spare part list SAB 157

40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR
Fig - Item
P&I Ref. Description Qty.
Index number

03-05 160 1553.439 Oil level switch low, 120°C 1 X X X


Oil level switch high, stand-
03-05 163 1553.423 1 X X
ard
03-05 163 1553.440 Oil level switch high, 120°C 1 X X X
Seal ring, bonded,
03-06 1349.216 1 X X X X X
for G3/4 A (H)
03-06 TE-2 1373.346 Temperature sensor, L=130 1 X X X X X
03-07 103 1364.499 Double Stop Valve (F) 1 X
03-07 103 1364.500 Double Stop Valve (F) 1 X X
03-07 103 1364.501 Double Stop Valve (F) 1 X
03-07 103 1364.502 Double Stop Valve (F) 1 X
03-07 2356.265 Gasket 82/42x2 1 X X X X X
03-07 104/105 1364.503 Unit Safety Valve 2 X
03-07 104/105 1364.504 Unit Safety Valve 2 X
03-07 104/105 1364.505 Unit Safety Valve 2 X
03-07 104/105 1364.506 Unit Safety Valve 2 X
03-07 104/105 1364.507 Unit Safety Valve 2 X
03-07 2356.265 Gasket 82/42x2 2 X X X X X
03-08 531B0099H01 Coalescer filter 34" (A) 1 X X
531B0099H01-
03-08 Coalescer filter 34" (A) 1 X X X
PA
03-09 UI Unused Index 0
540D0217G02 Retainer, filter end plate
03-10 1 X X X X X
EU (B) or (C)
540D0217G03 Stud bolt, double 1/2-13
03-11 1 X X X X X
EU UNC x 918 (B)
Nut, hexagon 1/2-13
03-12 902A0021H01 1 X X X X X
UNC (B)
Washer, plain, hardened
03-13 1436.075 1 X X X X X
ID=13 (B) or ( C)
Screw, hexagon 1/2-13
03-14 1423.014 1 X X X X X
UNC x 32 (C)
03-15 2356.272 Gasket ø225/169 x 2 (C) 1 X X X X X
03-16 108 1361.189 Service valve evacuation (J) 1 X X X X
03-16 108 1361.184 Service valve evacuation (J) 1 X
03-16 3446.518 Oil container 0.5l 1 X X X X X
03-16 1345.146 Hose Union 1/8"-27 1 X X X X X
A) Quantity depends on operating conditions of the unit
B) Quantity is for each coalescer filter
C) Quantity is for each unused filter opening
F) Set pressure depends on operating conditions
H) Quantity is for each sealing purpose
J) Spare parts kits and sets for stop valve in Fig. 6

Spare parts manual - SAB 157


010105 - en 2013.09 11/26
Spare part list SAB 157

1.1.6 Oil filter - single, typical

18 16 20 21 17 19

14 1

10 6, 7

2, 3

12

9, 13, 15 11 8 4, 5

Fig. 4: Drawing for list 04

Spare parts manual - SAB 157


12/26 010105 - en 2013.09
Spare part list SAB 157

List 04

40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR
Fig - Item
P&I Ref. Description Qty.
Index number

04-01 0355645.PED Oil Filter OF 2111HP (D) 1 X X X X X


04.02 0355606 Gasket 1 X X X X X
04-03 0355647 Cover, end 1 X X X X X
04-04 1424.120 Screw M20x110 12 X X X X X
04-05 1432.048 Nut, hexagon M20 12 X X X X X
04-06 535A0144H01 Plate, clamping 1 X X X X X
04-07 195 959A0053H01 Gasket 7 13/16" x 1/8" 1 X X X X X
Screw, hex. Socket cap
04-08 1413.356 6 X X X X X
M8 x 21
04-08 1434.034 Washer, plain ID=8,4 6 X X X X X
Rod, treaded 1/2-13
04-09 333Q0001268 1 X X X X X
UNC x 31-1/2"1
04-10 195 531A0218H02 Element, SuperFilter II 2 X X
531A0218H02-
04-10 195 Element, SuperFilter II 2 X X X
PA
04-11 900A0007H01 Seal center 1 X X X X X
04-12 900A0008H01 Yoke, bottom 1 X X X X X
04-13 1436.075 Washer 2 X X X X X
04-14 121 1361.117 Stop valve (J) 1 X X X X
04-14 121 1361.182 Stop valve (J) 1 X
04-15 902A0021H01 Nut, hexagon 1/2-13 UNC 2 X X X X X
04-16 201 1364.258 Check valve 1 X X X X X
04-17 123 1361.193 Stop valve (J) 1 X X X X
04-17 123 1361.185 Stop valve (J) 1 X
04-18 124/HV 1364.546 Control valve (Q) 1 X X X X
04-18 124/HV 1364.498 Control valve (Q) 1 X
04-19 153/TE-3 1373.346 Temperature sensor 1 X X X X X
04-19 155/PE-1 1373.333 Pressure transducer 1 X X X X X
04-21 156/PE-2 1373.333 Pressure transducer 1 X X X X X
D) See cross-sectional view in Fig. 4
J) Spare parts kits and sets for stop valve in Fig. 6
Q) Spare parts kits and sets for check valve in Fig. 7

Spare parts manual - SAB 157


010105 - en 2013.09 13/26
Spare part list SAB 157

1.1.7 Oil cooler piping, typical

TOP VIEW

6
BOTTOM VIEW

1 5

2 3 4

Fig. 5: Drawing for list 05

Spare parts manual - SAB 157


14/26 010105 - en 2013.09
Spare part list SAB 157

List 05

40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR
Fig - Item
P&I Ref. Description Qty.
Index number

05 194 1952.115 PSHE 3HH 34/2/1 1 X X X X X


05 194 1952.116 PSHE 3HH 66/2/1 1 X X X X X
05 194 1952.117 PSHE 3HH 116/2/1 1 X X X X X
05 194 1952.118 PSHE 4HH 120/2/1 1 X X X X X
05-01 119 1361.193 Stop Valve 1 X X X X
05-01 119 1361.185 Stop Valve 1 X
05-02 120 1375.117 Thermo valve ORV40 H1 1 X X
05-02 120 1375.144 Thermo valve (AMOT) 1 X X X
05-02 120 3084.831 Kit gasket and O-ring (AMOT) 1 X X X
Thermostatic element,
05-02 120 1365.085 1 X X X
60C, (AMOT)
Kit, Thermostatic element
05-02 120 148H3243
+ gasket, ORV40 H1
05-03 2356.266 Gasket ø92/49 x 2 3 X X X X X
05-04 1344.043 Flange 48,3 3 X X X X X
05-05 106 1361.189 Service valve evacuation (J) 1 X X X X
05-05 106 1361.184 Service valve evacuation (J) 1 X
05-06 108 1361.189 Service valve evacuation (J) 1 X X X X
05-06 108 1361.184 Service valve evacuation (J) 1 X
J) Spare parts kits and sets for stop valve in Fig. 6.

Spare parts manual - SAB 157


010105 - en 2013.09 15/26
Spare part list SAB 157

1.1.8 Suction/discharge/service/stop valve, typical

Fig. 6: Drawing for list 06

List 06

40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR
Fig - Item
P&I Ref. Description Qty.
Index number

06- - Suction/discharge/service 1 X X X X X
stop valve
(See chart below)
06-01 - Cone and cone seal (k) X X X X X
06-02 - Packing gland (k) X X X X X
06-03 - Packing washer (k) X X X X X
06-04 - O-ring (k) X X X X X
06-05 - O-ring (k) X X X X X
06-06 - Gasket (k) X X X X X
06-07 UI Unused index
06-08 - Washer (k) X X X X X
06-09 UI Unused index
06-10 - Cap (k) X X X X X
06-11 - Gasket for cap (k) X X X X X
06-12 - Soft backseat (k) X X X X X
06-13 - Wear ring (k) X X X X X

k) Quantity as required for one valve in the actual kit

Spare parts manual - SAB 157


16/26 010105 - en 2013.09
Spare part list SAB 157

1.1.9 Spare parts list for all suction/discharge/service/stop valves

Kit, Kit,
Item Repair kit
Description Packing gland Cap including
Number (a)
(b) gasket (c)

1364.325 Reg. valve, Ang., Sc., REG 40 #10 2453.044 1377.249 1365.098
1361.117 Stop valve, Ang., Sc., SNV-ST CD10 (d) (d) (d)
1361.052 Stop valve, Ang., Sc., SVA-ST 15 1377.417 1377.273 1365.096
1361.078 Stop valve, Str., Sc., SVA-ST 15 1377.417 1377.273 1365.096
1361.053 Stop valve, Ang., Sc., SVA-ST 20 1377.417 1377.273 1365.097
1361.079 Stop valve, Str., Sc., SVA-ST 20 1377.417 1377.273 1365.097
1361.054 Stop valve, Ang., Sc., SVA-ST 25 1377.418 1377.249 1365.098
1361.067 Stop valve, Str., Sc., SVA-ST 25 1377.418 1377.249 1365.098
1361.055 Stop valve, Ang., Sc., SVA-ST 32 1377.418 1377.249 1365.098
1361.064 Stop valve, Str., Sc., SVA-ST 32 1377.418 1377.249 1365.098
1361.056 Stop valve, Ang., Sc., SVA-ST 40 1377.418 1377.249 1365.098
1361.065 Stop valve, Str., Sc., SVA-ST 40 1377.418 1377.249 1365.098
1361.057 Stop valve, Ang., Sc., SVA-ST 50 1377.419 1377.274 1365.098
1361.066 Stop valve, Str., Sc., SVA-ST 50 1377.419 1377.274 1365.098
1361.063 Stop valve, Ang., Sc., SVA-ST 65 1377.420 1377.274 1365.098
1361.068 Stop valve, Str., Sc., SVA-ST 65 1377.420 1377.274 1365.098
1361.073 Stop valve, Ang., Sc., SVA-ST 80 1377.421 1377.279 1365.099
1361.074 Stop valve, Ang., Sc., SVA-ST 100 1377.422 1377.279 1365.099
1361.075 Stop valve, Ang., Sc., SVA-ST 125 1377.423 1377.282 1365.100
1361.076 Stop valve, Ang., Sc., SVA-ST 150 1377.424 1377.282 1365.100
1361.077 Stop valve, Ang., Sc., SVA-ST 200 1377.425 1377.283 1365.101
1361.108 Stop valve, Ang., Sc., SVA-DH 250 1377.285 1377.284 1365.115
1361.135 Stop valve, Ang., Sc., SVA-DH 300 1377.286 1377.284 1365.115

a) SVA-ST consists of: Cone complete including screw and steel balls, packing gland including gaskets
and all other necessary gaskets (Index 1-6/11-12)
SVA-DH consists of: Cone wear ring including gaskets, packing gland including gaskets
and all other necessary gaskets (Index 1-6/11-12)
b) Consists of packing gland including gaskets (Index 2-5)
c) Consists of cap with gasket (Index 10/11).
d) No spare parts available (tighten packing gland or replace all with a new valve)

Spare parts manual - SAB 157


010105 - en 2013.09 17/26
Spare part list SAB 157

1.1.10 Discharge stop/check valve

Fig. 7: Drawing for list 07

Spare parts list for check valve

Item Bonnet Spring kit Spring kit


Description Seal kit (e)
number gasket 0.5 bar (f) 2 bar (f)

1372.589 Check valve, Ang., GVD 100 (T) 956A0045H11 956A0045H12 N/A 956A0045H14
1372.591 Check valve, Ang., GVD 125 (T) 956A0046H11 956A0046H12 N/A 956A0046H14
1372.593 Check valve, Ang., GVD 150 (T) 956A0047H11 956A0047H12 N/A 956A0047H14
1372.595 Check valve, Ang., GVD 200 (T) 956A0048H11 956A0048H12 N/A 956A0048H14
956A0045H02 Check valve, Ang., GVD 100 (U) 956A0045H11 956A0045H12 956A0045H15 N/A
956A0046H02 Check valve, Ang., GVD 125 (U) 956A0046H11 956A0046H12 956A0046H15 N/A
956A0047H02 Check valve, Ang., GVD 150 (U) 956A0047H11 956A0047H12 956A0047H15 N/A
956A0048H02 Check valve, Ang., GVD 200 (U) 956A0048H11 956A0048H12 956A0048H15 N/A

T) Only at high stage operating mode


U) Only at booster operating mode
e) Consists of gasket and various rings (Index 16-22)
f) Consists of plate, rivet and spring (Index 14/28-29)

Spare parts manual - SAB 157


18/26 010105 - en 2013.09
Spare part list SAB 157

List 07

40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR
Fig - Item

Qty.
P&I Ref. Description
Index number

07- - Assembly, Discharge stop/


check valve
(Item No.
see Fig-Index 01-07)
1 X X X X X
Spare parts for:
- stop valve, see fig.9
- check valve, see chart
previous page
07-01 - Housing 1 X X X X X
07-02 - Bonnet 1 X X X X X
07-03 - Piston cylinder 1 X X X X X
07-04 - Piston rod 1 X X X X X
07-05 - Piston 1 X X X X X
07-06 - Cone 1 X X X X X
07-07 - Spring screw 1 X X X X X
07-08 - Spring bushing 1 X X X X X
07-09 - Cone plate 1 X X X X X
07-10 - Cone rod 1 X X X X X
07-11 - Rear bushing 1 X X X X X
07-12 - Front bushing 1 X X X X X
07-13 - Spring 1 X X X X X
07-14 - Spring (f) 1 X X X X X
07-15 - Plug (not shown) 1 X X X X X
07-16 - Teflon ring (e) 1 X X X X X
07-17 - Bonnet gasket (e) 1 X X X X X
07-18 - Nylon washer (e) 1 X X X X X
07-19 - Glyde ring (e) 1 X X X X X
07-20 - O-ring (e) 1 X X X X X
07-21 - O-ring (e) 1 X X X X X
07-22 - O-ring (e) 1 X X X X X
07-23 - Spring ring 1 X X X X X
07-24 - Spring ring 1 X X X X X
07-25 - Spring ring 1 X X X X X
07-26 - Nut 1 X X X X X
07-27 - Set screw (O) 0 X X X X X
07-28 - Marking plate (f) 1 X X X X X
07-29 - Rivet (f) 1 X X X X X
07-30 - Washer 1 X X X X X
07-31 - Nut 1 X X X X X
07-32 - Screw 1 X X X X X
07-33 1361.117 Stop valve, Ang., Sc., 1 X X X X X
SNV-ST CD10 (J)
J) Spare parts kits and sets for stop valve in Fig. 6.
O) Quantity as required (may be suggested)
e) Consists of gasket and various rings (Index 16-22)
f) Consists of plate, rivet and spring (Index 14/28-29)

Spare parts manual - SAB 157


010105 - en 2013.09 19/26
Spare part list SAB 157

1.1.11 Coupling assembly

Fig. 8: Drawing for list 08

List 08

40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR
Fig - Item
P&I Ref. Description Qty.
Index number

08 1524.451 Ass., Coupling ø65 & ø2" (g) 1 X X X X X


Kit, Disc pack including all
720C0078H11 1 X X X X X
fasteners
g) Motor and compressor bore respectively

Spare parts manual - SAB 157


20/26 010105 - en 2013.09
Spare part list SAB 157

1.1.12 Piping and instrumentation, typical

158

114 115
SUCTION GAS
TO COMPR

101
129
151
191

192

159
157
124

152 201
DISCHARGE GAS

104 105
108
FROM UNIT

103
107
126 102
116 163
160
193 117

161 162 154


106
155

153 119
195

121 120
123 194
156

200

Fig. 9: Principle P&I diagram

Note: See customer specific P&I diagram for details

Spare parts manual - SAB 157


010105 - en 2013.09 21/26
Spare part list SAB 157

List for principle P&I diagram

40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR
Item
P&I Ref. Description Qty.
number

101 1361.234 Suction stop valve 1 X X X X X


102 1361.195 Discharge stop valve 1 X X X X
102 1361.183 Discharge stop valve 1 X
103 1364.499 Double stop valve 1 X
103 1364.500 Double stop valve 1 X X
103 1364.501 Double stop valve 1 X
103 1364.502 Double stop valve 1 X
104/105 1364.503 Unit safety valve 1 X
104/105 1364.504 Unit safety valve 1 X
104/105 1364.505 Unit safety valve 1 X
104/105 1364.506 Unit safety valve 1 X
104/105 1364.507 Unit safety valve 1 X
106 1361.189 Service valve drain 1 X X X X
106 1361.184 Service valve drain 1 X
107 1361.133 Purge valve 1 X X X X
107 1361.182 Purge valve 1 X
108 1361.189 Service valve evacuation 1 X X X X
108 1361.184 Service valve evacuation 1 X
114/NV-3 1361.117 Stop valve 1 X X X X
114/NV-3 1361.182 Stop valve 1 X
115 1364.022 Check valve 1 X X X X X
116/117 1226.036 Sight glass 3 X X X X X
119 1361.193 Stop valve 1 X X X X
119 1361.185 Stop valve 1 X
120 1375.117 Thermo valve 1 X X
120 1375.144 Thermo valve (AMOT) 1 X X X
121 1361.117 Stop valve 1 X X X X
121 1361.182 Stop valve 1 X
123 1361.193 Stop valve 1 X X X X
123 1361.185 Stop valve 1 X
124/HV 1364.546 Control valve 1 X X X X
124/HV 1364.498 Control valve 1 X
126 1372.601 Pressure control valve 1 X X
126 1364.509 Discharge check valve 1 X X X X X
Gasket 3" 300/600 LB,
126 1336.045 2 X X X X X
1.5 mm plane bearing surface
129/CV-1 1364.508 Non-return valve, suction 1 X X X X X
Gasket 4" 600 LB,
129 1336.046 2 X X X X X
1.5 mm plane bearing surface
151/TE-1 1373.346 Temperature sensor 1 X X X X X
152/TE-2 1373.346 Temperature sensor 1 X x X X X
153/TE-3 1373.346 Temperature sensor 1 X X X X X
154/TE-4 1373.345 Temperature element 1 X X X X X
155/PE-1 1373.333 Pressure transducer 1 X X X X X
156/PE-2 1373.333 Pressure transducer 1 X X X X X

Spare parts manual - SAB 157


22/26 010105 - en 2013.09
Spare part list SAB 157

40 BAR R717

52 BAR R717

60 BAR R717
40 BAR CO2

52 BAR CO2
SAB157HR

SAB157HR

SAB157HR

SAB157HR

SAB157HR
Item
P&I Ref. Description Qty.
number

157/PE-3 1373.333 Pressure transducer 1 X X X X X


158/PE-4 1373.338 Pressure transducer 1 X X X X X
159/PS 1373.087 Pressure switch 1 X X X X X
160 1553.422 Oil level switch low, standard 1 X X
160 1553.439 Oil level switch low, 120°C 1 X X X
161 / 162 1555.097 Heating element 2 X X X X X
Oil level switch high,
163 1553.423 1 X X
standard
163 1553.440 Oil level switch high, 120°C 1 X X X
191 534E1232G01 Compressor HPSH 1510 VI 1.7 1 X X X X X
191 534E1232G02 Compressor HPSH 1510 VI 2.2 1 X X X X X
191 534E1232G03 Compressor HPSH 1510 VI 2.9 1 X X X X X
191 534E1232G04 Compressor HPSH 1510 VI 4.0 1 X X X X X
192 Electric motor xx kW Schorch 1 X X X X X
192 Electric motor xx kW ABB 1 X X X X X
193 357677-PED Oil separator 1 X X X X X
194 1952.115 Oil cooler PSHE 3HH 34/2/1 1 X X X X X
194 1952.116 Oil cooler PSHE 3HH 66/2/1 1 X X X X X
194 1952.117 Oil cooler PSHE 3HH 116/2/1 1 X X X X X
194 1952.118 Oil cooler PSHE 3HH 120/2/1 1 X X X X X
195 0355645-PED Oil filter 1 X X X X X
195 531A0218H02 Oil filter element, standard 1 X X
195 531A0218H02-PA Oil filter element, high temp. 1 X X X
Gasket 7-13/16 OD 1/8 THK
195 959A0053H01 1 X X X X X
3300
200 3447.526 Oil return valve 1 X X
200 3447.649 Oil return valve 1 X X X X X
201/CV-2 1364.258 Check valve 1 X X X X X

Spare parts manual - SAB 157


010105 - en 2013.09 23/26
Fig. 10
4 ” Cla s s 4 0 0 Su c t io n Fla n g e
1.1.13 Compressor port locations

24/26
SM- 2 Ma in Oil In je c t io n SC- 6 Dis c h a r g e Pr e s s u re SC- 7 Se a l We e p a g e
Vi = 1.0 5 SV- 1 Ec o n o m ize r
SM- 1 Ma in Oil In je c t io n
SC- 8 Clo s e d Th re a d Dr a in

010105 - en 2013.09
Spare part list SAB 157

Spare parts manual - SAB 157


Fig. 11
SB- 3 Dis c h a rg e Be a r in g s , Sh a ft Se a l, & Un lo a d e r Plu g Oil Fe e d
SD- 2 Liq u id In je c t io n Ble e d

010105 - en 2013.09
SC- 5 In le t Pre s s u re
Spare part list SAB 157

Spare parts manual - SAB 157


A

TRANSDUCER MOUNTING

SD- 1 Co a le s c e r Ble e d SB- 2 Ba la n c e Pis t o n & In le t Be a r in g Oil Fe e d


BP- 1 Dis ch a rg e Byp a s s SL- 0 Liq u id In je c t io n

25/26
12.75 (.50 2)
12.70 (.50 0 )
KEYWAY

VIEW A- A

Dis c h a rg e Fla n g e
3” Cla s s 60 0
Numerical parts list

2. Numerical parts list


Item number Fig-Index Item number Fig-Index
0355606 04-02 1373.333 04-20
0355645.PED 04-01 1373.333 04-21
0355647 04-03 1373.345 03-03
0357677.PED 03- 1373.346 04-19
0357696 03-02 1373.346 01-06
1226.036 03-02 1373.346 03-06
1331.605 03-01 1375.117 05-02
1336.045 01-07 1375.144 05-02
1336.081 02-04 1413.356 04-08
1336.082 01-06 1423.014 03-14
1336.080 02-07 1424.120 04-04
1344.043 05-04 1432.048 04-05
1345.146 03-16 1434.034 04-08
1349.135 03-05 1436.075 04-13
1349.216 03-06 1436.075 03-13
1361.117 04-14 1524.451 08-
1361.117 01-06 1553.422 03-05
1361.133 01-07 1553.423 03-05
1361.182 04-14 1553.439 03-05
1361.182 01-06 1553.440 03-05
1361.182 01-07 1555.097 03-04
1361.183 01-07 1952.115 05
1361.184 05-05 1952.116 05
1361.184 05-06 1952.117 05
1361.185 04-17 1952.118 05
1361.185 05-01 2356.265 03-07
1361.189 05-05 2356.265 03-07
1361.189 05-06 2356.266 05-03
1361.193 04-17 2356.272 03-15
1361.193 05-01 3084.831 05-02
1361.195 01-07 333Q0001268 04-09
1361.234 01-06 3446.518 03-16
1364.022 01-06 3447.649 01-04
1364.258 04-16 531A0218H02 04-10
1364.498 04-18 531A0218H02-PA 04-10
1364.500 03-07 531B0099H01 03-08
1364.501 03-07 531B0099H01-PA 03-08
1364.502 03-07 534E1232G01 02-
1364.503 03-07 534E1232G02 02-
1364.504 03-07 534E1232G03 02-
1364.505 03-07 534E1232G04 02-
1364.506 03-07 535A0144H01 04-06
1364.507 03-07 540D0217G02EU 03-10
1364.508 01-06 540D0217G03EU 03-11
1364.509 01-07 900A0007H01 04-11
1364.546 04-18 900A0008H01 04-12
1365.085 05-02 902A0021H01 04-15
1372.601 01-07 902A0021H01 03-12
1373.338 01-06 959A0053H01 04-07

Spare parts manual - SAB 157


26/26 010105 - en 2013.09

You might also like