Professional Documents
Culture Documents
2’
2. Concrete pavement subdrainage shall be constructed adjacent to
s) (
Outlet Pipe For Counter Drain 1:4 Slope
the low edge of the roadway pavement and under travel lanes,
¡ Outlet Pipe(
In Sag Vertical Curves Varies (To Exist. Shldr. Pavt.) 2’ 1:6 Slope
auxiliary pavement and shoulders, as called for in the plans.
When the low edge shifts between outside and inside edges of
Existing Shoulder pavement the concrete pavement subdrainage shall extend 50’
1
’
R
Pavement (Varies) beyond and begin 50’ before the flat point (100’ overlap).
4" Dia. Minimum Outlet Pipe 2’ Single Pipe 1:2 Pipe Bevel For 1:4 Slope
Exist. 1’
(Nonperforated) Length Varies 3’ Double Pipe
1:2 Pipe Bevel For 1:6 Slope
Concrete Edgedrain B B Concrete pavement subdrainage shall be placed on the low side
3’
Type SP
Asphaltic Elbow Or Bend As Required 3. Concrete pavement subdrainage shall be constructed on a grade
Sod
Trough For 1:6 Slope
R
Concrete (See Note No. 7)
’
parallel with the edge of pavement profile, except on profiles
1
Type SP
Trough For 1:4 Slope flatter than one-tenth percent (0.10%) the concrete pavement
Asphaltic Perimeter Sod
subdrainage shall be constructed on a grade of one-tenth
2’
Concrete 4.7 SF For 1:4 Slope
percent (0.10%).
1 2’
’ 5.5 SF For 1:6 Slope
4" Dia. Outlet Pipe Class NS Concrete
For 1:6 Slope
(Nonperforated) Length Varies 6" Thick (0.19 CY-1:4 Slope) 2’ 4. Immediately prior to placing the filter fabric the entire vertical
2’
(0.25 CY-1:6 Slope) For 1:4 Slope face of the concrete pavement shall be cleaned to remove
45 Elbow Or
1
8 Bend PLAN - OUTLET PIPE APRON procedure must be approved by the Engineer prior to placement
of the draincrete.
Perforated Pipe
Sod 6. The upper end of each separate run of the concrete pavement
A A
2’S subdrainage pipe shall be capped.
od
)
ies
2’S
in.
1:2 Bevel od be of the same material as the outlet pipe but compatible with
ALIGNMENT OF OUTLET PIPE
Var
1’M
21" the pipe.
dgn
5" Min. 1
Mi 2"Galvanized Hardware Cloth
n.
\d\projects\standards\roadway\00200-s\00287-01.
(
Cover Trough Slope Shall Match Outlet Pipe Slope
NOTE: For Section AA see following Sheets. When directed by the Engineer, outlet pipes shall be stubbed into
6"
existing inlets or into existing ditch pavements at an elevation 6"
d
6"
bordering sod are not required for stubbed outlets,but
(Nonperforated) Class NS Concrete (6" Thick)
replacement sodding will be required at trenches for pipes
6 2’Mi
n draincrete will not be permitted.
Varies (1’ Min.) . 1
2"Galvanized Hardware Cloth
(See 1:4 Detail Above) 4" Min. Cover Trough Slope Shall Match Outlet Pipe Slope
8. Existing paved shoulder that is removed for the construction of
6"
outlet pipes shall be replaced with Type SP asphaltic concrete at
rd960rh
d
1:
6
4" Dia. Minimum Outlet Pipe 6"
9. The contract unit price for Edgedrain Outlet Pipe (4") LF, shall
(Nonperforated) Class NS Concrete (6" Thick) Ditch Bottom be full compensation for removal of existing shoulder pavement,
33 AM
d = 1.75’ std. for grassed ditches; 0.5’ std. for paved ditches restoration of ditch pavement, backfill in place, and disposal of
With The Standard Specifications SECTIONS BB [less is acceptable to provide minimum 0.1% outlet pipe slope] excess materials.
4" EDGEDRAIN
SUBDRAINAGE PIPE
6/28/2012
EDGEDRAIN OUTLET
REVISIO N
Stabilized Subbase. To Be Paid For Under Contract Tied Longitudinal Joint Full Depth Concrete
Optional Base
Concrete Pavement
(Depth Varies)
Draincrete Draincrete
10" M in.
10" M in.
Filter Fabric Type D-3 (See Index No. 199) Filter Fabric Type D-3 (See Index No. 199)
12" 12"
NEW CONSTRUCTION
Cut To A Neat Line Before
1. The edgedrain sections for DRAINCRETE SUBDRAINAGE are applicable to pavement construction
dgn
the plans, with sufficient time allowed for the draincrete to set before placement of pavement.
METHOD OF PAYMENT
NEW CONSTRUCTION:
1. The contract unit price for Edgedrain (Draincrete) LF shall be full compensation for trench excavation,
Top Of Filter Fabric: Draincrete
disposal of excess material, filter fabric, draincrete edgedrain pipe and fittings and draincrete.
2" Below Bottom Of Pavement For
10" M in.
Cement Stabilized, Soil Cement And Filter Fabric Type D-3 (See Index No. 199) Payment for outlet pipe shall be in accordance with General Note 9, Sheet 1 of 4.
C:
(See Sheet 1)
existing shoulder pavement, trench excavation, disposal of excess materials, filter fabric, draincrete
4" 4" edgedrain pipe and fittings, and draincrete, necessary for edgedrain construction.
12"
Payment for outlet pipe shall be in accordance with General Note 9, Sheet 1 of 4.
35 AM
30:
Shoulder pavement shall be paid for under the contract unit price for Type SP, Asphaltic Concrete.
9:
REHABILITATION
Shoulder joint seal shall be paid for under the contract unit price for Pavement Joint, LF.
DRAINCRETE SUBDRAINAGE
6/28/2012
REVISIO N
2"
Draincrete
10" M in.
4" Dia. Special Perforated Pipe
4" 4"
12"
12"
1. The edgedrain sections for DRAINCRETE SUBDRAINAGE are applicable to pavement construction
2. The contractor shall confine the construction of draincrete edgedrain to an area in which the entire
Optional Base Group 1 Optional Base
operation can be carried out in five (5) work days, unless another construction period is called for in
Type B-12.5 Only
Draincrete the plans, with sufficient time allowed for the draincrete to set before placement of pavement.
2"
METHOD OF PAYMENT
Filter Fabric Type D-3 (See Index No. 199)
10" M in.
NEW CONSTRUCTION:
C:
Payment for outlet pipe shall be in accordance with General Note 9, Sheet 1 of 4.
4" 4"
2. Type B-12.5 shall be paid for under the contract unit price for Optional Base.
12"
3. Shoulder pavement shall be paid for under the contract unit price for Type SP, Asphaltic Concrete.
37 AM
ASPHALT SHOULDERS
30:
9:
REVISIO N
METHOD OF PAYMENT
4" ATPB or CTPB
Filter Fabric
NEW CONSTRUCTION
Stabilization
Stabilization
1. Payment shall be full compensation for trench
Separation Layer 2" Type SP
6" CTPB excavation, disposal of excess materials, filter
Joint for ATPB Construction Optional joint
12" Stabilization
for CTPB. Cover with Type D-3 Filter fabric, pipe and fittings, necessary for concrete
Fabric If left exposed for over 5 days. pavement subdrainage construction. Payment
Base, CY.
10" M in.
Payment for outlet pipe shall be in accordance
Concrete Pavement
\d\projects\standards\roadway\00200-s\00287-04.
6"
6"
Optional Base
6"
10" M in.
12"
REVISIO N