Professional Documents
Culture Documents
instruction manual
Installation instructions by the attached
right-opening)
(Door right-opening)
● This time is Thank you for purchasing the Toshiba electric washing dryer, Thank you very much.
● In order to safe and proper this product, please fully understand Please read this manual carefully before use.
● After you have finished reading this, please be sure to keep it in the place of those who are your can be seen at any time.
compressor
If you want to be operated, such as dehydration only (stage another operation) .............. 36 If
you want to washing and drying of their flow ........................... 38 If you want to store the washing
and drying of their flow ............ 40 If you want to adjust the clothing of finish
Cooling Useful
memory
heating Useful ........................... Washing to use the remaining hot water of 42 bath .................................. Reservation
Useful
dehumidification of 44 operation end time (How to set the current time) ................. Guideline of 46 course
.......................................... Drying using the 32 drying cabinet ..................................... 34
content and duration ............................... 48 cold-warm air operation (TW-3000VE / 3000VER
drying
only) and washing
............. .......... 28 Random
50 mold protection operation ..................................... 51Drying
useful to know
Expansion valve ....................................... 52
24 Random laundry .......................................... 26 various washing and
to
to know
know choose how of a course in laundry ........................... 22 Random washing and drying
Heat pump unit
................................................. 67 Warranty and after-sales service .................................. 68 to
(S-DD heat pump hybrid engine) ■ If you want to display the electric bill and water bill ■ When
64
youBraille
want toand
eraseoperation sound
the end buzzer ................................
sound ■ All the settings back67 Specifications
t
Person for the first time you are using a drum-type washing and drying machine such a display out on the 60 display unit ............................... When you wish to use in the 62
I want to know How do I get the washing prior to the clothing of how to
Please refer to the. After
After sales
sales service
service Care .............................................. 54 is not a failure Troubleshooting ........................... When
check the trouble of clothing you want to try the various ways you can use, such
Care,
Care,
Care
know Attaching of the water supply hose Please refer to the installation instructions.
and installat
I want to fix the rattling of the body
installation,
installation,
?
Power plug the power cord
Safety Precautions Please observe without fail Dust adhering to the mounting surface of the blade and
blade power plug wipe well
Not to damage the power cord
Or to damage the power cord, damaged or, processing or, forcibly bend,
When the dust is deposited, it pull, twist, please do not bundled. In addition, or applied to the metal part,
● People and harm to other people you are using, we have described the important information about the safety of the order to prevent damage to property. It made the following
may cause a fire. or place heavy objects, please do not or pinch. Code is damaged, it may
content (signs) well and understand to read the text, please follow the instructions.
cause a fire or electric shock.
It may cause electric shock, short circuit or fire. Do not use prohibited prohibited
* 2: The injury, does not require hospitalization or hospital visits for long-term medical treatment, injuries, burns, sensitive by a picture or text in or near the symbol. injury.
It refers to such power.
* 3: Property damage is involved, such as in a house, household goods and livestock, pets expansion
Keep the fire in the plastic part
Note
It refers to damage. Failure to do so may result in fire.
Care
Installation
Before cleaning disconnect the power plug from the wall outlet Not directly splash water on the body of each unit
Power use the outlet of more than rated 15A in the washing Make sure the ground wire is attached You may want to electric shock, short circuit.
and drying machine alone AC 100V There is a risk of electric shock at the time of failure or leakage. Installation of It may be the risk of electrical shock or
ground wire, make sure you consult your electrician or dealer. injury.
When the voltage and rated different fire, will be the cause of electric shock. Also, it may
Pull the plug Water over ban
branch outlet portion and in combination with other instruments fires and abnormal heat
generation.
Otherwise
Outlet dedicated To verify the connection of the ground wire Someone other than the repair technician who remodeling not is, not If that contains water or foreign objects inside the body, pull out the
Flammable substances are not taken into drum (washing and de-water tank) Edible oil, animal-based oil, machine oil, clothing and
Cold air, warm air operation (TW-3000VE / 3000VER only)
Please do not put such as gasoline, kerosene, benzine, thinner, alcohol the dry cleaners oil, such as adhering, urethane foam of
or those of the deposited laundry. It will cause an explosion or fire.
the laundry is not dry From cold air, warm air blowing port, does not or placed in plugging Not applied directly to the body for a long time cold air and warm air
? (to be continued)
Safety Precautions (Cont.)
detergent
Installation is to ask the dealer or an installation When you waste disposal, remove the door
clothing
professional of purchase There is a risk that the child is confined.
Since the body is heavy, or injury, you may damage the Waterproof sheet, mat, clothing (※) is not the washing and Mats do not do laundry and dehydrated and dried
waist.
dewatering and drying Mat of resin at the time of drying or adhere to the inside of the body, it may contaminate the other
clothing. It becomes the cause of the spontaneous ignition in the self-heating due to chemical
Abnormal vibration during dehydration, or injury, body, wall, damage such as a
changes depending on the material.
floor, there is a risk, such as clothing of damage. ※ sauna suit, rain Gappa,
fishing for the jacket, pants, ski wear, sleeping bags, diaper cover, wet suit, such
Ask the professional Remove
as a bicycle, motorcycle, car cover.
Ban Ban
electrical plug
Do not use the washing machine for a blanket washing net during Doormat, what you want or a thick even foot wipe mat, not
When disconnecting the power plug, do not pull the power Unplug the power plug from the wall outlet when unused for long blanket wash wash even if there is a display of machine-washable
cord periods of time Abnormal vibration during dehydration, or damage the like around
Or climb on top of the body, does not or place objects Do not push your hand from the bottom of the unit When closing the door, not to pinch your clothes Do not use excessive force to Doapakki ring when loading and
There is a risk of injury. Damage or water leakage of clothing, will be the cause of the failure. unloading the clothes
Deformation and breakage or, fall is a thing that was placed by the vibration during Door packing is deformed, it can cause
unexpected damage to water leakage.
operation, there is a risk of injury. Supercargo ban Not pushed Not to pinch your clothes Ban
To make sure that foreign matter such as lint on the door During or immediately after and the end of the drying drying is not touch
Water supply and bath packing surface prior to use is not attached the inside of the drum
Can not be secured in close contact of the door, it can cause Has become a high temperature, there is a
Open the faucet before the operation, to confirm that there are no loose Hot water from the water heater is not used
unexpected damage to water leakage. risk of burns.
or water leakage of the connecting portion of the water supply hose It can cause a failure or unexpected damage of the body.
check NO contact
The bath water for the water supply hose level surface of the tub is not Or it was placed in the bath water for the water supply hose to the Is the place to hit directly, not put plants and animals cool air and In places where cold air hits directly, not I use the combustion
used in the above present body position bathtub or, not remove the water supply fitting for bath water hot air appliances
By the siphon phenomenon, even if the finished pump operation continues out water, By the siphon phenomenon, water is kept out of the hose, floor and likeness get wet, can cause It may cause a negative impact on flora and fauna. By the incomplete combustion of combustion appliances, it may
it can cause unexpected damage to wet the floor. unexpected damage. Bathtub previously issued a bath water for the water supply hose from, cause choking.
Prohibited Ban
sure to disconnect the water supply fitting for bath water after the water has finished out. The
blow-out port
?
■ accessories ※ If you want to newly purchased accessories, please consult your dealer.
Goods supplied and each part of the name Name Number In such a case Part code reference page
Please note that the and washing and drying machines. Used to
Detergent supply case handle Extended drain hose One 42040746
label on safety water supply the bath water. "Eradication
P18
*2 deodorant", use the "shelf dry" course.
Bath water hose hanging
(There is also on the left) One 42040673
fittings
Door (door)
panel P12
P11 Bath water for the water supply P44
One 42040707
One-push open button P11 supply
hose hose(4m)
with filter (0.8m) · hose
P58
Estimated label of the amount of laundry Drying shelf water One 42080042 P34
P16
*3
Drainage hose door Power cord AC supply hose is required in order to prevent water leakage or out.
(installation manual)
Hose cap operation * 3: On cleaning brush
Can be connected to your hand-held vacuum cleaner, you can clean easily. If you can not connect,
sleeve (Installation instructions)
please connect via the included parts of the vacuum cleaner.
(Installation manual)
■ It can be connected vacuum cleaner
Lint filter Intake filters This brush can be used in the table below ○ mark of the vacuum cleaner (a special connection method is excluded).
P54 P55
General type exhaust
Drying filters Cold air warm air blow-out port Floor moving type circulation system, air cycle
(TW-3000VE / 3000VER only)
P55 cordless
P50 P59
Stick handy
Please
?
Optional parts Opening and closing the door lock of the door
When you purchase, please contact your dealer.
In such a case Part Name Parts code type name standard price
Open the door way Closing the door way
If * temperature is high and the water temperature when there is no
waterproof pan to the installation location is low, you may wet the
Open by pressing the one-push open Middle right-hand side of the door
Washing machine tray TZ-20 3,360 yen
with a dew to the body (condensation) floor. button. (TW-3000VER / 2100VER the left side) Press, Before
please securely closed.
When the installation surface is weak The reinforcing plate A (600 × 650 × 71) mm TW-R600 12,600
The reinforcing plate D (890 × 630 × 21) mm TW-R890 8,400 yen yen
When adjusting the body horizontally Leg cap 42006245 735 yen If you want to add the clothes in the washing operation When the door does not open
About 5 minutes from the start of the washing operation is blinking, you ■ When the power supply is "OFF":
extension hose
42040679 1,470 yen can add clothing.
the washing machine is required Length 1.2m The power to "On", and open only the door When I go out. Turn off the
drainage hose attached when the drain port is at the bottom of power during operation, and a power outage, will remain the door is
Length 0.2m THP-2 1,470 yen
1
When further extended hose in addition to the extension
Press, to pause locked.
extension hose beneath the drain pipe
Length 0.4m THP-3 1,470 yen
supply
Height adjustment plate TW-AS3 2,415 yen 2 Once you but turned off, open the door, put the laundry
■ When the power is "ON":
Water Length 0.5m 42040662 1,575 yen Turn on the power, open the door When you goes out.
Please use plus joint to the water supply hose of the ● By the state in the drum, it may also door does not open
Length 1m 42040663 1,785 yen
accessory that you want to extend the water supply hose
paused.
Length 2m 42040664 2,520 yen
■ On the display unit When the display comes out:
Length 5m 42040665 4,095 yen
3 Press the close the door
● We Tsu water and Awagazan in the drum than the water level in which the door is opened.
Free faucets, when attaching the hose fitting to the
Faucet joint CB-J6 2,520 yen ● Or spill foam opened the door during the wash, because the From the waste water according to the instructions below, please open the door.
universal home faucet
foam and water adhering to the door you may drip on the floor,
If you want to install the faucet to the washing and drying 2 If necessary Press, select the "standard" course
Branch faucet JB-11 2,100 yen
machine dedicated
3 Press
When the filter of the bath water for the water supply
When the length of the bath water for the water supply hose is Bath water for the water supply hose ■ So that children do not fall into the drum, you can force the
42040649 1,890 yen 5
not enough in 4m filter with a length 7m door lock. (Settings at any time, you can cancel.) around the drum to push open the door
2 "Pipipi'" and setting complete the buzzer sounds (In drying operation, when the temperature in the drum is high)
When the lint of the drain port is a concern Lint filter box ● Blower operation (10 to 30 minutes) to have to lower the temperature. There
There lighting
Accessories: 1 drainage hose (length 750mm) THB-100 3,675 yen
Once off, you can open the door. If the blowing time is made longer by
Two drainage hose band
● If you open the door (to release), there is no line the same operation,
conditions such as room temperature
supply hose filter for (chlorine)
When the dry filter is damaged (different parts code number by the main body 42044707 when the buzzer as "Pipipi'" sounds, setting is canceled.
Yes you.
color) Drying filters
42044708 2,100 yen
of the procedure.
Washing tank cleaner water
When you clean the washing and de-water tank 90004003 2,100 yen
When but the door does not open even if turned off P64
Ten 11
Ally of the operation panel TW-2100VE / 2100VER does not have Ha button cold air warm
※ This operation panel air,
is TW-3000VE / 3000VER.
but other uses are the same.
Display unit During operation, the display unit will be a little darker. Door lock display
● When you turn on the power ● When you book a driving end time ● Lint filter cleaning display (standard) ● Door when it is on is locked, not open.
※ And then displayed in 24-hour display the current It displays the reservation time. P46 Let you know your cleaning time of the lint filter
time. P46 (standard) in the display and buzzer.
Before
● You can open the door when it is turned
● driving ● When a problem occurs during operation P54 off.
※ Displays this key when detect the clothing of the And a display, such as the right example.
● Drying filter cleaning display (standard)
amount or room temperature. P62 ● When it is flashing
Drying filter and clean timing of the intake filter will be
※ In about 15 seconds after pressing the start Open the Off Once the door
● When the clothing is biased announced in the display and the buzzer (the
The amount of detergent (approximate) It is displayed.
press, you can add clothing.
And a display, such as the right. guideline).
P55
P63
It represents a 1.2 cups. P11
※ And driving the final start the water supply and dry ● Drying over-capacity display (standard)
It displays the remaining time (approximate) up to ● When the door is not open P11 The beeper beeps three times the amount in many cases of the laundry to the drying
completion.
※ When there is still water in the drum. capacity, it will blink. Pause When the display flashes, cycle the power from reducing the / Pause dial
If the "remaining" display is flashing, you have to review amount of laundry, please start again. ( "Blanket", "pollen" course, except when you set
You are viewing the 2 hours
● Used to select the course.
the measure of the time remaining. the drying time)
and 50 minutes. ● Washing time, rinse times, dehydration time, it uses the setting of
※ When the temperature in the drum is high.
● Soft keep Display the dry finish and time. For example increasing time and number
※ Flashes during a soft keep. of times and turn to the right, it reduces the turn to the left.
※ Forcibly when it is door lock.
After drying, it makes the software keep ※ It also displays when the laundry at the time of mold protection operation remains in the drum
driving about 4 hours. P32 (washing and de-water tank). P51 ● Reservation time, it uses to set the current time.
Start / Pause
● Press this button to start operation.
● Such as when you add a laundry, Press this
button to pause the operation.
Power supply
● "ON" of the power supply, and "OFF".
● After the end of the run about 10 minutes, or if allowed to stand
Wash, rinse and dehydration and drying Reserved ● Selected operation contents of the lamp is lit.
● You can book the operation end time. P46 Washing Wash dry Drying Cold / hot air
● Flashing buttons luck ● Operation after the end you can see an indication of the electricity and water bills. ● After pressing the button, the course will choose and turn the dial. (TW-3000VE / 3000VER only)
● Drying will show the current settings. (Except for the "dry" course)
1? 1?
The movement of the washing and drying machine
Washer-dryer has washing and drying in the movement, such as the following.
Here it described as an example the movement of the washing and drying operation of the "standard" course.
Before
When you start putting the laundry sensors measure the amount of laundry, to display the amount of detergent, and water supply to the set level.
■ If you want to change the operation contents during the operation (in the wash)
1
After the start, about 15 seconds drum without water conditions achieve a rotated amount of laundry
You can change the operation contents in the washing. P49
※ And washing the amount of laundry is wet I get to heavier. The washing tub by the balance condition of the laundry is, the front body 1 To pause Press
There is a case falls on the side is not a malfunction.
● Content that can be changed
.Of, your favorite
The contents of the setting.
2
To guide the amount of detergent image Add such as detergent and softener in the detergent supply case
Repeat the beat-washing Drainage to dehydration Rotation water supply drum to Rinse for drainage to Rotation water supply drum to the Drainage to dehydration High-speed rotation Drying drum is ● To let you know at
Tomomi wash the set water level set water level rotated the end buzzer.
Wash wash without damaging the clothing as After repeated low-speed The rinse liquid is circulated While dehumidifying by And then dried using a After drying, sometimes slowly
"beat-washing" in the "fir wash". The washing solution is rotation, and dehydration at and rinse efficiently. using a heat pump Uni Tsu heat pump Uni Tsu drum in order to reduce the sheet
washed with a small amount of water is circulating, and a high speed. (The capacity of the laundry, there are door do the high-speed door. with the sum of the clothing will
check the Desugi of foam in the foam sensor. times when the circulation pump does rotation. rotate.
not work.)
Like washing time is long. Display has changed in the middle? Water supply during the dehydration? Water supply in the dry?
The display of the remaining time The offset of the laundry Foam sensor and is Wobbling rinse The
case and will be turned on.
Display is eye depreciation of the case the water supply amount of tap When the laundry during operation is biased been added process such as the following, Foam sensor Foam sensor Foam sensor
water per minute 12L. In the case of next Ri display time or longer the remaining time will change.
washing time than the display of the remaining time was not reduced, it
may change the display in the middle. from the driver softener-up
Keeping watch bubbles Once Desugi bubbles Discharge the bubble Slowly rotating the drum Melt the foam
● Water supply amount of tap water is less than the per minute 12L.
● Time to waste water is applied. Bubbles out in the wash checked with foam sensor, it discharged When a large Upon detection of the foam, the foam to impose soluble in water
● Laundry was biased. amount of generated, to prevent the Desugi of foam. before dehydration, do the swaying rinse.
Operation stops and to detect Modify the deviation Waste water softener
● Foam has a large amount generated. the deviation water supply to
1? 1?
In front of the washing and drying Clothing that should not be a wash and dry
The amount of laundry
It is washing the amount of time you wash a defined cloth in JIS. wiping mats, not wash even if there is a display of washing and dehydration and drying Before
The amount that can be washing by such as the type, size, thickness of the laundry will change. If the motion of the laundry is bad is put too much laundry. machine-washable Abnormal vibration during dehydration, or injury, body, wall, damage such as a floor, there is a risk, such as
Abnormal vibration during dehydration, or injury, body, wall, clothing of damage. ※ sauna suit, rain Gappa, fishing for the jacket, pants, ski wear, sleeping bags, diaper cover,
● For washing and drying or drying alone........... .6 .0kg less damage such as a floor, there is a risk of damage to the wet suit, such as a bicycle, motorcycle, car cover. Ban
clothing.
● In the case of washing only....................... .9 .0kg below Ban
that can be washing by laundry. For washing and drying or drying only (Example) ● Some of the leather products, leather and feathers, and fur decoration
(No others are using the partially leather)
● Sheets are four (about 2.0kg) below ● Silk, rayon (including polynosic), cupra and blends thereof GOODS
● Bath towel is seven (about 2.1kg) below (No in lining)
● Lace curtains is six (about 4.0kg) below ● Those coating process, was subjected to resin finishing (those using adhesive)
● Bath towel is 14 sheets (about 4.2kg) below
● Embossing (processing to put a pattern of irregularities on the cloth), which was subjected to a wrinkled
* These garments are original shape, shrinkage, discoloration, you may be a problem with clothes and texture becomes worse occurs.
Briefs [about Undershirt [about Shirt [about Sheets [about Socks [about Pajamas up and down Blouse [about Bath towel
50g] 130g] 200g] 500g] 50g] [about 500g] 200g] [about 300g] ● Cushions and pillows, bedding, such as those using the Wataya urethane (sponges)
Or damage to the laundry, cause of failure.
* [] In is the measure of one of the mass.
● Pure wool blankets, blankets electric blankets, long pile (more than haired 10mm), carpet cover
Or damage to, such as laundry to I'm hair, cause of failure.
■ Guide when the clothing (dry cloth) was placed in a drum
● Commercial laundry auxiliary equipment (washing ball, Noise Removal filter, etc.)
Due to deformation and damage, it can cause damage to the body or damage to the laundry.
● Hanging dried, some lay flat, the dry handling picture display ※
■ Put the laundry the way
● Animal hair products, such as wool, the blend products ※
● In order to measure the amount of laundry in as accurate as possible, please be not pushed the laundry well. Hair comes off, shrink, it may damage the like laundry to original shape.
● Bulky clothing (jeans, sheets) in only one etc., in order to reduce the offset cloth at the time of dehydration, or luck rolling along with other clothing, please drive in
● Glued clothing
the "small amount" course.
If you want to glue, please use the "spray glue" after drying.
● When you put the laundry in the washing net, in order to reduce the offset cloth at the time of dehydration, and as much as possible subdivision, please drive to other clothes and one together.
● Other clothing
Tights, some of the lace and embroidery, such as decorations and accessories, clothing of new synthetic fiber (microfiber).
1? 1?
Use of the detergent supply case how
■ Opening and closing of the detergent supply case Powder detergents, powder bleaching agent dispenser unit Liquid detergent, liquid bleach-on part
Opening Closing
You can not be used if there is a lump in soap powder and detergents. Lump It will be automatically inserted at the beginning of the water supply of the washing.
Pull the detergent supply case to the front, pull it out. Slowly push the central part of the detergent supply case. There is a risk that if clogged with internal water leakage. Before
● If you do not close tightly, it may be a problem, use for water 30L)
Detergent supply case handle Oxygen-based liquid bleach
such as detergent remains occurs. ● Please do not use chlorine bleach. When the bleaching agent is attached
P58
● When using the detergent, soap liquid bleach at the same time, Powder bleach It is recommended for your use. Also, when using a liquid detergent and liquid bleach,
At the time of booking, please do not use detergent and liquid of bleaching agent in the liquid. Will soon flow out, it will cause discoloration of clothing. Black mark side:
cap
It is automatically put into the water supply during the final rinse. Softener
water
(stock)
So far Softener
● Diluted with the same amount of water for (for water 30L those of 7ml use) compact type that may be difficult to
enter, please put from the well mixed.
● Because of the input case siphon structure, there is a thin liquid and water remains, but this is not a malfunction.
1? 1?
For laundry agent
■ Measure of laundry agent amount
() Is the case of "speedy" course. Detergent amount of neutral detergent to be used in the "dry" course P31 It is
mentioned in.
Before
1.1 About 41g About 51g About 41g About 51g About 18ml About 20ml About 40ml
since.
● .Indication of the display is not in accordance with the attack (spoon 1 tablespoon about 37g). There is a difference in the size of the spoon on the type of detergent, since one cup of detergent amount spoon
is different, please adjusting the amount of detergent according to your use of the detergent.
. Example: Detergent amount display (spoon) is "1.2 cup", since about 60g of detergent .1 spoon is often the "1.2 cup"
Please ● Please do not overfill the detergent. Or not Susuge well too put, out full of bubbles, get wet on the floor
. Put a "0.7 cups" of about about 60% will be in an appropriate amount.
Such as class, it can cause unexpected damage.
● .Powder Ariel, good detergent foaming such as bold, there is a case where dirty laundry is less foam no longer able to dehydration and a large amount of generated, will be 20
● When I with a detergent in plastic parts such as doors and control panel, please wipe off immediately. It may crack and allowed to
minutes to 30 minutes is added to travel to discharge the bubbles longer.
stand.
. If the washing time is lengthened due to the generation of foam, please in the fewer the amount of detergent.
?0 1
Select how the course was in the laundry
Handling picture display comes with the clothes. Please wash and drying in suits course in clothing in accordance with
the instruction picture display. ■ Meaning the main handling picture display
I want to improve
Bath towel, towel, handkerchief, pajamas, underwear, T-shirts, shirts, Hot P26 hot P24
the removal of stains 40 ℃ a washing net that can
trousers, work clothes, gym clothes, socks, etc.
be washing in the washing
40
Want to quietly dry it wants machine be of use in the
Good night P26 Good night P24 Good night P32
to quietly wash following
bleach
Net use
Powder synthetic detergent
Weak
of kind There is a display of
30
School uniforms, slacks, skirts, blouses, lingerie, sweaters, cardigans, the Dry P30 carefully
amount can be washing, such as fleece clothing: 1.5kg below
Clothing and wash with a dry course, sneakers, the amount can be dried, such as stuffed
?
Random washing and drying
Check the clothing of the amount and dry condition, and automatic operation to dry from washing.
● There are things that can not be washing and drying the clothes. P17
● Stored with the use of the course, the current time and turn on the power from the next time, lamp,
Content that can be of the button and the course and drying setting lights.
.
5
Four 3 1
The amount that
1
course Course Description
*1 Turn on the power
can be washing and drying
● Current time or of the lamp,,
2
Good night
*4*
● It will operate quietly from the washing to dry. 6.0kg below
twenty
Laundry was placed, close the door
Prompt ● And washing and drying in a short period of time a light stain of chemical fiber and chemical fiber blend of clothing.
threeIf necessary Press, to light the lamp
*2
Conscientious ● Firmly wash a dirty clothing, firmly rinsed and dried.
*twenty
● Bath towels, jeans, is best when divided wash, such as fleece and judo, the only one and one
FourTurn the, if necessary, choose a course
Small amount 2.0kg below
towel sheets to wash and dry. ● The current settings It shows.
* 1: Automatic operation washing time, rinse times, dehydration time, but does not display the drying time. the bath water when you set up theP44
finish of
"Measure of the course content and duration." P48 See Because it is listed in. the dry P46
* 2: "Standard", "hot", "careful", "minor amount" You can set the finish dry. P42
* 3: The color faded easy to clothing, perishable clothes, please do not wash contracts easy to clothing.
Five . . .Press Additional laundry P11
Washing of the "hot" course behaves like that shown in the following diagram. If you are or if biased laundry is large, and the operation as shown below to 5 minutes after the
operation from the water supply to. P48 To guide the amount of detergent image Add detergent and the
6 detergent turned to case Measure of laundry agent amount P20
Warm air will warm the drum (washing and de-water ● Water supply will start after about one minute of the amount of detergent is displayed, to display an indication of the
Do the washing and drying operation.
bath) and laundry. remaining time.
?
Random laundry
Check the amount of clothing, and automatic operation from washing to dehydration.
Content that can be of the button and the course setting lights.
. .
5
Four 3 1
*1 The amount that
course Course Description Turn on the power
can be washing and drying
one
Standard ● It will operate automatically from washing to dehydration.
Random
hot
*2 ● Sebum marked with underwear, shirt, terrible work clothes dirty, gym clothes, and washing from
the warm, such as in a hot air thick socks.
9.0kg below two Laundry was placed, close the door
*3
Good night ● From washing to dehydration will operate quietly.
Three
If necessary Press, to light the lamp
Prompt ● And washing in a short period of time a light stain of chemical fiber and chemical fiber blend of clothing. 6.0kg below
Conscientious ● Firmly wash a dirty clothing, and laundry rinse firm. 9.0kg below
FourTurn the, if necessary, choose a course
● Bath towels, jeans, elutriated such as fleece and judo, it is ideal for when you wash the only one
P44
When you book a driving end time when
and towel 1 sheeting. It performs a loosening and blowing operation of about 4 minutes at the
Small amount 2.0kg below
end of dehydration, such as towels so that you finished well fit wind. using the bath water P46
* 1: Automatic operation the washing time, the number of rinsing, but does not display the dehydration time.
"Measure of the course content and duration." P48 See Because it is listed in.
Five . . . . . . . . Press Additional laundry P11
* 2: The color faded easy to clothing, perishable clothes, please do not wash contracts easy to clothing.
6
Washing of the "hot" course behaves like that shown in the following diagram. If you are or if biased laundry is large, and the operation as shown below to 5 minutes after the
operation from the water supply to. P48 To guide the amount of detergent image Add detergent, etc. to
Warm air will warm the drum (washing and de-water ● Water supply will start after about one minute of the amount of detergent is displayed, to display an indication of the
Do the washing operation.
bath) and laundry. remaining time.
* 3: It is stored when you use the "Good night" course, from the next time The initial display is "good night" course when you press the The end of the operation Announce the termination in buzzer
● During the washing after the "clean" flashing is done mildew protection automatic operation.
There will light.
P51
● Close the faucet, please clean the lint filter.
P54
?
Various washing and drying and washing
Blanket course
● Single size
(140cmx200cm below)
● Double size (180cmx230cm below) Four
Five 3 1
size ● Single size (140Cmx200cm or less,
Turn on the power
one
by weight each 2.0 kg)
Rando
Please
Laundry and dry Do not blanket
● Blankets Do not wash with other laundry. two Put the blanket, close the door
● Blankets of pure wool
● Blanket of small size (100cm × 140cm or less) please wash
● electric blanket
with blankets of other single size. Vibration and laundry at the
Press or, if necessary, turn on the lamp
Long blankets of the pile (more than haired 10mm).
Three
●
time of de-water may no longer be able to dehydration large
Or damage the blanket such as fallen hair, cause of failure. with a single.
P44
When you book a driving end time when
① To the shorter folded in two ② To 2-fold in the same direction
using the bath water P46
● Water supply will start after about one minute of the amount of detergent is displayed, to display an indication of the
remaining time.
● Twist, or rounding, please do not put in force the push. Drying time of wrinkles and will be the cause of the unevenness of drying. Also, please do not put in a ● Please tightly closed the detergent supply case. P18
blanket washing net. There is the vibration is offset blankets will no longer be dehydration large.
Please You can pause during the drying operation, please do not open the door. It might have to remain moist in a blanket. P54
? (to be continued)
Various washing and drying and washing (Cont.)
Dry course
Sweater, it is the course to wash blouse, the delicate clothing such as lingerie.
● Please check whether it is a washable clothing. There is no display and materials display picture handling, does not e wash color fall easy thing.
P17
● The remaining hot water in the bath, hot water, please do not use.
5 3 1
●
Four
Liquid neutral detergent, please use the (wool fashionable clothes for washing, one of the fluorescent agent-free formulations).
Weak
Ya Ya Fashionable clothes and delicate clothes that there is a display of
30
(washing and de-water tank), and place on top
Rando
so as to be flat. It is to prevent the deviation of
School uniforms, slacks, skirts acids Blouses, shirts, lingerie such Wool, angora, cashmere sweater, cardigan class, fleece
(wool, linen, polyester, etc.) (Polyester, hemp) clothing
threeIf necessary
● In the case of several sheets in order to prevent the
The press, the lamp
offset of clothing, thickness and put in uniform, such
so that.
To light
Four
Washing can amount: 1.5kg below
The turn, select the "dry"
Washing rule of thumb: sweater (one) about 400g
6
* Guests can yellowed and to the sun, may be discolored. used for water 30L)
Add liquid detergent and softener in the
* If the wrinkle is anxious, please take lightly the dry ironing of medium temperature from the back in a semi-dry state.
Black mark side
detergent case
■ How to shade (dry in the shade) cap
● Please tightly closed the detergent supply case. P18
Stretch out wrinkles by tapping lightly with the palm of the hand, and dried shaping up. Because such as school
uniforms is to prevent the original shape, please refer to the dry hanger sure. Please to Dry flat is like sweaters.
?0 1
Leave it dry
And automatic operation while checking the clothing of the amount and dry condition.
*1 The
course Course Description
amount that can be dried
5 3 1
Standard ● And then dried in automatic operation. Drying of finish can also be set. P42
*2
4.0kg below
1
Hair cloth ● And then drying the blankets.
Turn on the power
● Performs a blower operation while rotating the drum for 10 minutes, it dropped duster was ● "Pollen" course, in order to wash away the drop pollen, please open the faucet. Rando
Pollen attached to dry clothes pollen.
4.5kg below
2
P28and put details on how.
* 2: See Because it is listed in the drying can blankets
Put from to loosen the laundry was dehydrated, close the
door
■ Soft keep ● Please put the dry clothes "pollen" course.
I open the door, the power turns off after about 10 minutes, and exit.
After drying, repeat in order to reduce the with clothes of wrinkles 5-minute pause / 30 seconds operation the (drum rotation). Since the drying is over,
5 Press
Please ● If operated repeatedly the operation of drying alone, 5 to prevent degradation of performance due to the lint accumulation
About once in times, please drive the "dry" course. By flowing a lot of water and rinse the lint adhering to the inside of the main body. ● It detects the amount of clothing, to display an indication of the remaining time.
● You can pause during the drying operation, opened the door, there is a case that moisture in clothing remains.
● Because in the following cases you may moisture remains, set the dried for 30 minutes, please and then dried again.
- When the dry bulk of the increase in clothing (towel, such as synthetic fibers of the shirt) P39 The end of the ●operation Announce the termination in buzzer
After drying, and the soft keep driving.
- Thick place, such as a collar original or pocket ● Please clean the lint filter dry filter air intake filters.
- When you put the wet clothes along with the clothing of the damp-dry
P54
- When the amount of clothing is small (about 500g or less)
?
Drying using the drying cabinet
Drying Rack, please do not use it in other than the course "sterilization deodorant," "shelf dry". Drum rotation (washing
and de-water tank) is, there is a risk of the clothing of the damage and the body of the damage.
1 3
Position of the three baffle, turn the drum by hand so that as Hold the front central portion, fixed so as not rattle
shown below
Baffle
5 4, 5 6 3 1
Exhaust cover
2
Place ledge tip portion of the drying cabinet over the exhaust cover As a drying cabinet and the floor surface is horizontal, turn the drum
Four Rando
two Put put the laundry on the drying rack, close the
door
● There are also things that can not be dried by clothing. P17
Five
Please put out. It shall be dried Drying time
Press,.. The Rotate to set the drying
Thin sweater 90
■ Put the "shelf dry" course of clothing the way
sneakers
time
● In the case of such as sweaters ● Cases, such as sneakers, stuffed toys minutes 90 minutes
● 30 minutes ( "shelf dry" course is 20 minutes) can be selected in units of 10 minutes to 90
6
●
cabinet
again in the upside-down. . . . . . . . Press
2 Placed on the drying cabinet
?
If you want to be operated, such as dehydration only (Strokes another operation)
Five 4, 5 6 3 1 5 5 4, 5 6 3 1
■ Example: operation only dehydration ■ Example: operation
1 Turn on the power
washing and dehydration 1 time
Laundry was placed, close the door Laundry was placed, close the door
2 2
Press If necessary, turn on the lamp If necessary Press, to lightthe
the lamp
3 3 turn the, turn on the power to change dehydration
time
6 . . . . . . . . Press 6 . . . . . . . . Press
The end of the operation Announce the termination in buzzer The end of the operation Announce the termination in buzzer
■ The contents of the setting can stroke ■ Operation of other Operation you want to select Button you press
Please see the contents of your favorite settings for each course. P49 stroke *1
Wash only
* 3 only *twenty
Rinse and dehydration rinse
?
If you want to washing and drying of their flow
The washing time of each course, the number of rinsing, dehydration time, you can set change, such as drying time
finish.
contents turn the each contents turn the contents turn the contents turn the contents turn the
● Up to 5 to 30 minutes can be ● You can choose up to four times. ( ● 1 to 9 minutes to choose in 1 minute ● It will change the contents that can be
selected in 1-minute increments. ( "Dry" course 1 increments. ( "Dry" course 1 set by the course.
"Dry" course is 1 to up to 10 minutes)
● When you select a course, setting that does not include the "dehydration" and "dry" - up to three times) P49
※ "hot" course can not be set without
- up to 6 minutes) ※ "small amount"
Useful
process, it can not be set for dehydration time. a wash. course, "soft Specifications up" setting at
the time can not be set of de-water time.
P44
When you book a driving end time when P43
If you turn to the right If you turn to the right If you turn to the right If you turn to the right
6 3 If necessary
Press
14 minutes Ordinary dirt Twice
dehydration Auto Automatic Iron P42
7
To guide the amount of detergent image Add detergent, off No wash 4 times
5-9 minutes 20 min Up to 20 minutes to 90
? (to be continued)
Washing and drying of their flow (Cont.)
Memory course
Change the operation contents of the "standard" course it can be stored in the "Memory" course.
Five 4, 5 3 6 1
. If you want to store the washing and drying of own way of sto operation contents of the "standard" course . Stores the operation contents of the "standard" course
the door
Four Select the "Memory" by turning the Four The turn to. Select "Memory"
5
● Set that does not include the "dehydration" and "dry" process, can not be set for dehydration
P44
When you book a driving end time when
Press, to change the contents by turning the
time.
using the bath water P46 P44
To book a driving end time when using the
P39 P42
bath water..... When P46
6 6
When you book a driving end time P46
Press Press
The end of the operation Announce the termination in buzzer The end of the operation You end at the buzzer..... News The end of the operation Announce the termination in buzzer
?0 (to be continued)
1
If you want to adjust the clothing of finish
If you want to adjust the finish of the dry If you want, such as the texture well finish towel (soft finish)
Washing and drying the "standard" of the operation, "hot", "careful", "small amount" course, in the "standard" course If you set, such as shown below, during the final dehydration of the washing operation "standard" course, subjected to
of the drying operation .. After pressing the button, you can finish the setting of the drying of your choice and turn loosening and blowing operation of about 4 minutes, and finish soften the towel.
the dial.
2
The buzzer will sound as "Pipipi'", complete set
● When set to a soft finish, when the washing operation is "standard" will
blink.
● It remembers the set once.
cotton - linen blend of clothing, Since the dry condition is set low, and it can be ironing. After Useful
the end, you can add dry.
● If you do not want to add dried, please turn off the power and
remove the clothing.
*1
Eradication Drying Drying can amount: 6.0kg below
Sterilized you want clothes, dry hard
to clothing in the thick cloth such as Compared to the automatic operation, and Yes to set a high dry
Dried while the clothing
jeans condition.
and eradication
● For cooling to the required tap water, faucet, please open.
* 1: For eradication depends on the Japan Food Analysis Center "bacterial liquid absorption method". (Test report: No. 307070618-001)
?
Washing to use the remaining hot water bath
Operation content when using the bath water
Tap water use bath water use
Wash only the bath water use Wash dehydration Rinse for dehydration Rinse for dehydration
Bath water use to rinse Wash dehydration Rinse for dehydration Rinse for dehydration
4 3 Five 2 1
● Free operation of the wash step, in an operation the number of one-time rinse, you can not use the bath water.
Prepare the bath water for the water supply hose, open the faucet
● When the bath water is lost in the water supply, and water supply tap water.
● The remaining hot water of the bath, please use at 40 ℃ or less. Use of bath
course
● The remaining hot water containing the sulfur is, please do not use because it may stainless steel drum (washing and de-water tank) is rust. Or damage the drum (washing and de-water tank) to
2
water
the component for the remaining hot water that contains other bath salts or bathroom cleaners, because there is a possibility to get the color in clothing, the instruction manual of the bathing agent
If necessary Press and run
standard
or bathroom cleaners please read.
Turn on the flop
Speedy hot
Preparing the bath water for the water supply hose In order to properly water
carefully
Please observe the following things.
1 Remove the seal, plug reliably water supply fitting for bath water bath water
6
To guide the amount of detergent image Add detergent,
2 To adjust the length of extending the bath water for the water supply hose
● In the water supply because the hose hangs down due to the weight of water, please ■ Change of bath water use etc. to the detergent supply case
stretched the length Me. Please use the "bath water for the water supply hose (7m)" (sold
● After pressing the can not be changed is the ● And water supply tap water about 15 seconds to 45 seconds in order to confirm the open forgotten in
separately) If short with the supplied hose. content of the bath water use. Please set again
the priming and the water tap to the bath water pump in front of the bath water supply. If or when the
back on the power.
P10
clothing is less used for the first time, you may water supply is stopped before the pump is operating.
■
3 Submerge the bath water for the water supply hose to the tub Cancellation of bath water use
Not pinch From the bath water pump is started the operation, it takes about 3 minutes to suck up
● From the tip of the bath water pump to the highest point of the hose the height
● Press . the bath water.
Please in the 1.5m below.
● And pitting on the hose, you might not be able
Operation of the pump is stopped, tap water is fed
1.5m to supply water.
The water temperature is 40 ℃ or less below
water. The end of the operation Announce the termination in buzzer
● Pinch to the door, forcibly or pulling, you may If
you Fundari hose One department is. If there
is a risk of damaging the hose Please use the Close the faucet, take out the water supply hose for bath water from the bath
"protection sleeve" (sold separately).
● Remove the bath water for the water supply fittings, please remove enough water in the hose. Care of the bath
Not as much as possible slack
?
Reservations operation end time
You can book the operation end time in the reservation button.
● Water temperature, room temperature, water pressure, drainage of the state, such as ■ The end time of the reservation and the shortest time of the
by offset tool case of cloth, you may not end up in the end time as you book.
operation until the end for the (approximate)
● You can book at the time of the later time table below from the current time.
3,5 2 6 1
■ Confirmation of the reservation content course
Four
Reservation during the course shortest time (approximate)
Washing and drying washing 濯 Drying
● Press.
Standard 6 hours 1.5 hours 5 hours
1 Turn on the power, close the door and put the laundry
While you hold down, you will see the reservation contents.
hot 7 hours 2.5 hours Over
2
5.5 hours 1.5 hours Over
● Cancel will turn off the power. Changes to turn the power on, please try
If necessary The press, the lamp
again from the beginning.
Conscientious 7 hours 2.5 hours Over
To light
Small amount 6 hours 1.5 hours Over
■ In your use of the detergent supply case
possibility that the caked detergent to water leakage jammed inside. Pollen
P58
sterilization
deodorant shelf
Four Press
◆ reservation time "6:00" is lit
● Stored operation end time was set to Book operation, from the next time will
Useful
dry clean cold air / be displayed operation end time that was previously set by pressing the
"reservation" button.
warm air ※
6 Press
.
7
To guide the amount of detergent image Add detergent, etc. to the detergent supply cas
◆ leave the clock display is flashing
2 .
Adjust the present time turning the ● The amount of detergent display from the display for about 30 seconds, to display the current time.
● Time goes by turning to the right to return and turn to the left. ● Please tightly closed the detergent supply case. P18
● 24-hour display.
3
◆ clock display lights
Reservations
● After drying, and the soft keep driving. P32
. Press
● The buzzer will sound and the "copy", you begin to move the clock
operation end ● During the washing after the "clean" flashing is done mildew protection automatic operation.
?
Measure of the course content and duration
The contents of the Random washing and drying (Room temperature 20 ° C., if the water temperature 20 ° C.) The contents of your favorite
Operation contents course capacity
Water level Wash (about) rinse Dehydration (about) Drying (about) The required time (about) wash set rinse De-water Drying
*1 8L ~ 21L Auto
standard 6.0kg below 10-14 minutes Twice 5 minutes 190 minutes 135-245 minutes Auto, ironing, sterilization
Setup
dry, 20 to 90 minutes
*1 8L ~ 21L Auto Heating 20-25 minutes (10 minute increments)
hot Twice 5 minutes 80-190 minutes 185-280 minutes Auto, 5 to 30
6.0kg below Setup this wash 18-26 minutes *2
minutes (1 minute
increments)
8L ~ 21L Auto
Good night 6.0kg below 10-14 minutes Twice 5 minutes 95-205 minutes 185-285 minutes With or without
Wash and dry Setup
washing Auto, 1 to 4 times Auto only automatic and
8L ~ 22L Auto
Hair cloth 4.0kg below 35 minutes 3 times 5 minutes 230 minutes 80 to minutes Auto only
Setup
8L ~ 30L Auto
Standard 9.0kg below 10-20 minutes Twice 4 minutes 45-60 minutes
Setup
increments)
8L ~ 30L Auto Auto, 1 to 4 times Auto, 1 to 9 minutes (1
Good night 9.0kg below 10-20 minutes Twice 4 minutes 50-60 minutes With or without
Setup With or minute increments) or
washing
without rinsing without dehydration
Washing 8L ~ 21L Auto
Prompt 6.0kg below 4-6 minutes Twice 4 minutes 35 to 45 minutes 355
Setup ※"hot"
The course Useful
8L ~ 30L Auto
Carefully
small
9.0kg below 16-28 minutes Three to four times 7 minutes 75-95 minutes setting of
Setup
washing Inashi is
11L not can
2.0kg below 12 minutes Twice 15 minutes 60 minutes Auto only
automatic setting
*1
Standard 6.0kg below 105-165 minutes 105-165 minutes * 2 Only the same
By setting
Good night 0.4kg below 20 to 90 minutes (10 minute
* 1 : The dry setting, capacity that can be washing and drying will change. P42 ● The contents of the "clean" course. P56 P57
● The time required contains a drainage time water supply time (12L / min). The type and amount of laundry, water temperature, room temperature, water pressure and drainage of the state, the deviation of the
cloth condition, by the dry condition of the cloth, the remaining time display and the actual time required during operation will change. In addition, by putting the amount of detergent and foaming condition, it may
?
Cold air, warm air operation (TW-3000VE / 3000VER only) Mold protection operation
5
Four 3 2 Four
If you set the "mold protect", complete the "clean"
1 1
Open the faucet (at the time of cold air operation) (tank dry) after washing the end. Since removing Washing Exit
● the moisture of the washing and de-water tank,
When cold air operation uses water for cooling. If you do not open the faucet Out Display ● If the mold protect is set, "clean" has flashing.
Te, it will stop operation. P62 you can suppress the generation of black mold.
P56
2
Turn on the power, close the door
● If you do not open the door power is turned off after one hour. In this
3
Press and cold air hot air the blue lamp to light ● Press before washing for 3 seconds. The buzzer will case, does not the mold protection operation.
3
■ If you have booked a washing end time close the door Useful
● If you do not close the door power is turned off after one hour. In this
Four Turn the, if necessary, to change the operating time ● Reservations operation will make the Kabipuroteku door operation case, does not the mold protection operation.
Five . . .Press ● Press the 3 seconds before washing. The buzzer will
Four
●
sound as "Pipipi'". Stored and then washing operation . Press
This opens the cold air warm air blow-out port. Direction of
without Kabipuroteku door from the next time.
the louver will be down at the time of upward, hot air
● It displays the remaining time of the mold protection operation.
operation at the time of cold air operation.
● Even if you do not press, automatically performs the mold protection operation When
● You can without mold protection even during the
Please you after 30 minutes from close the door.
washing. Please press. Buzzer will sound a "beep". In
● Cold air operation, the room temperature is 17 ℃ or less, hot air
● In front of the cold air warm louver ● When the clothing is remaining display of over-capacity will blink. Please
such a case I do not remember.
air blow-out port Do not
operation at room temperature is 28 ℃ or more, it will be blowing ※ Please do not change the orientation of the louvers. press, remove the clothing if that. If you leave shown table it will turn off after
display.
water droplets in the louver, but this is not a malfunction.
P62 P55 P59
?0 1
Useful to know
If you want to display the electric bill and water bill When you want to erase the end buzzer sound
1
After the end of the operation, it displays the press and the total amount of electricity bill and water bill a.
A turn on the power while holding down
Rather than the amount of the measurement of the actual power consumption and use the amount of water is the amount or we guess the amount of driving time and the laundry when the water supply amount
is 12L / minute.
Press
2
While holding down the The buzzer will sound as "Pipipi'", complete set
● Please go again the same operation To make the end buzzer sounds.
2
● From the completion of the run, until the auto power off after 10 minutes. The buzzer will sound as "Pipipi'", complete set
Washing
after about 5 seconds
● all of the content that is stored will return to its initial state.
Washing and drying ● During soft keep.
Cold / hot air ● From the completion of the run, until the auto power off after 10 minutes. ● Please remove enough drum (washing and de-water tank) • water ■ If yours is frozen if
supply hose water.
● Drainage hose, shaking the hose up and down, please Water supply hose, in the case of a water supply hose for bath water
● If a problem during operation occurs, but does not display the amount of money.
disconnect the water. ● Remove the hose, and give the following hot water 40 ℃.
● Bath water for the water supply hose is out of the tub, remove the Do not forcibly bend the frozen hose. There is a risk of
Amount guess criteria: a measure of the power unit price ..................... 22 yen / kWh (tax included) water rates, bath water supply fittings, please disconnect the water in the damage.
sewerage fee ....... ....... 228 yen / m 3 (Tax included) (Breakdown: water charges 128 yen / m 3 , Sewer use hose is sufficient.
amount of 100 yen / m 3 . ) ● In the interior of the bath water pump always remains water.
Please be kept warm over a etc. blanket the entire washing and
In the case of the body
● Amounts will display up to 95 yen. 40 ℃ or less of hot water
drying machine top. ● Drum put 40 ℃ or less of hot water (washing and de-water
tank), time was allowed to stand for about 30 minutes close the
Such as blankets Bath water pump
door, please make sure that the turn in the hand drum.
※ even if the above treatment, the water from such as detergent supply case at the time of the water supply operation
Since it has frozen water in the internal body hose If the full, please drive after 30 minutes
?
Care
Drying filters
After the operation every time care
Be sure to dry the filter When the "dry filter cleaning" display flashes, please clean the air filter and the drying circulation port.
P13
● Care was not as "lint in the laundry is attached," "take a long time to drainage," "does not dry," "drying time is longer" problems such as will occur. ■ How to remove and care ■ Attaching
Lint filter
Please
P13is hardly damaged because of the
Please be sure to clean the lint filter When the display "filter cleaning" is flashing. . Drum-type washing and drying machine cloth In the case of In the case of ● If you do not attach the dry filter at the time of operation, it will stop
beat-washing, I occurrence of lint is small, and if that was dried, in the case of washing and drying the lint is easy to get clothing, such as a towel that please clean each TW-3000VE / 3000VER TW-2100VE / 2100VER the operation is displayed.
time. Dehydration only the operation before cleaning, please disconnect the water.
P36
● If the display appears on the display unit it is likely that you are full of lint. In this case, because there is a risk that there remains a large amount of water to the
2 The accumulated lint to dry filter and within the body,
Remove, etc. included brush and vacuum cleaner
drum (washing and de-water tank) in, be sure to disconnect the water little by little response to the water or the like tub. It can cause unexpected damage to wet the
floor.
1 The door Put your finger into the finger receiving portion
Open in front door
1 Filter mounting
Align the filterTai凹
is inserted into the Filter mount
1
remove always. If you install
2 Since the residual water comes out, the right figure
Put the water receiving tub as leave lint is attached it can cause Before the intake air filter 1 The central portion of the intake filter
Pulled out Press slowly
water leakage and unexpected
damage.
the drying circulation port with a brush attached, which was connected to the
Drop, please wipe with a soft door
P9 "not dry," "drying time
6
vacuum cleaner and a lint of the back. If you do not a care,
cloth.
Washed with water to remove the lint
Make is long Kunar" problems such as will occur.
and installa
? (to be continued)
Care (Cont.)
sometimes dirty laundry peeled off in the wash, "clean" (tank cleaning, tank cleaning and drying) please drive the course.
P51
Clean (the tank dry) Clean (bath wash, bath cleaning and drying)
2
(※ 1)
Press
2
※ Wash by circulating a cleaning solution in
Low speed About 45 minutes to 75 minutes Close the door directly into the drum of the
the circulation pump every 12 minutes.
Stroke of the tank cleaning and drying (About 235 to 265 minutes)
? (to be continued)
Care (Cont.) Water supply port (when the water supply of out has become worse)
It may waste is packed in water supply port.
Care to be dirty is been noticeable 1 Close the faucet Four To clean the filter, such as with a toothbrush
● Please note in such a way
that a filter is not out.
● A chemically treated cloth, alcohol, benzine, thinner, cleanser, the residential and furniture for synthetic detergent, because the cause of the discoloration and scratches, please do not use 2 Turn on the power
Press
filter
to care.
Water Water supply hose Water supply port
Detergent to the portion of the plastic, such as doors and control panel, please wipe off immediately if such as hair dressing is attached. If left untreated it may
3
●
After remaining time display in, inlet nut
damage the part of the plastic. Turn off the power, remove
1 Pull the detergent supply case to the front, the top has slightly above
Below, remove
1 Attaching the cap (2) to the detergent case
in cloth.
● When operating without mounting ● Please do not push with a sharp pointed object operation panel. This may cause parts of the damage or failure.
3 Wash the detergent supply case and cap, with a dry cloth
wipe
Bath water for the water supply hose Got rust of the drum (washing and de-water tank)
■ How to remove and care ■ Attaching A cream cleanser is attached to a sponge or cloth, please remove the rust.
Filter always larger (green) the net side, the smaller the (black) to
1
Net filter (green) ● Steel wool, etc. damage the drum (washing and de-water tank), please do not use it will be easy to rust.
If the strainer of the "left" Filter (black) set put the strainer side, and attach by turning in the right
Remove by turning it toward
strainer Stainless steel There is a difficult nature of rust, but, in order to prevent the occurrence of the event of rust, please observe the following things.
direction.
● Please do not leave the drum (washing and de-water tank), such as hairpin.
● Water outages after, out-rich water the iron rust, it may iron rust is attached. Please use from so clean water comes out.
3
that marinated for about 1 hour bath water supply hose in it.
Cold air warm air blow-out port (TW-3000VE / 3000VER only)
Dust attached to the net, be cleaned, such as with a toothbrush
● Or broke the net, please do not interest you
removed. Cause a failure. Open the cold air warm air outlet opening in the hand as shown in the right of the picture, or wipe with a
soft, dry cloth the louver, please remove the dirt with the supplied brush.
and installa
When it is very dirty, please wipe impregnated the kitchen detergent diluted in cloth.
louver
?
This is not a malfunction is Troubleshooting
Status reason Status reason
● Display of the amount of detergent is an approximation. The type of laundry, the display changes in the amount of detergent by ● Initial use at the time of the heat, there is a child generates a smell from the door packing and
Even in the laundry of the same weight
the state and movement the way of the laundry in the mix and drum, such as wet clothes (washing and de-water tank). parts. Smell as the use over time will be reduced.
Different detergent amount display
● Because the smell of accumulated dirt in the drain outlet from flowing backward. Please be
Strange smell from the drum
sound from the drain hose is
● If there is still water in the drum (washing and de-water tank) within you may start the operation from the cleaned on a regular basis the drain outlet.
Drained to start
waste water.
Sound of water to turn the drum
and hot-air operation to dry bashed ● Is the sound of liquid contained in order to balance at the time of dehydration.
●
by hand
turbidity in the final rinse water This is because to improve the take water to the front side of the laundry.
Strange smell at the time of drying ● Air and water in the middle drainage may occur in the case was Tsu mixed. This is not abnormal.
● When the water level in the wash is lowered, water is water supply.
To drain in the middle of the
washing of the water supply in the washing middle ● When the foam is a large amount of generated, detected by the foam sensor, it will be drainage and water supply.
Colo sound is when you start It is the sound ●of the initial setting of the heat pump unit. This is not abnormal.
Tap water is supplied to chose the ● Because the front of the bath water supply to check the open forget priming and water faucet to the bath water pump, tap water,
bath water use and the water supply for about 15 seconds to 45 seconds.
■ Driving time
The water supply during the dehydration ● Because the flow of foam in the drum (washing and de-water tank).
For the remaining time ● The rest has been displayed times are approximate. The type and amount of laundry, detergent of the type and amount, water
temperature, room temperature, water pressure, drainage of the state, by the degree of deviation of the cloth, in fact required time will
The long time required
● vary.
Severe foaming When the terrible bubble, etc. put too much detergent, or not well Susuge, you may not be able to luck
You may foam is attached to the door and the door rolling. Please be sure detergent is put in the proper amount.
packing. ● The rest has been displayed times are approximate. The type and amount of laundry, detergent of the type and amount, foaming
P59 ● Kind of detergent, you may foaming by the water temperature becomes severe. The remaining display time
condition, water temperature, room temperature, water pressure, drainage of the state, Ri by the degree of deviation of the cloth, the
It does not decrease the
display remaining time will change. "Remaining" display will flash and we are reviewing the remaining time when the remaining time is
● Zeolite component in the detergent is not the main detergent minutes. Please increase the number of rinse time change on the way
To water supply than on the door there is a stopped.
cycles when anxious. P38
Drying has been completed, but ● For drying after the end of anti-wrinkle, make the software keep driving. Please take P32
When was set boss dehydrated only in the ●
does not stop out the clothes opened the door. Drainage time before dehydration, for the time, such as the balance correction not included in the set time of the
setting of their own flow, dehydration is not
dehydration only, the longer the operation time than the set time.
completed on time
■ door
Door lock is turned off and the door ● Dry operation, the door to such as when you left, you may stick with the door packing. Open and pull
■ Otherwise
does not open when you press the the perimeter of the door of the one-push open button side.
The first time you use
one-push open button
It leaves water from the drain ● It is water remaining when the factory of the performance test.
■ Panel operation
● After the suspension of water supply, please use from waiting for the water is clean. Laundry to wash in many
● There is a button you can not change the operation contents. Turn on the water containing iron rust might turn yellow. When the iron rust is attached to the white laundry, please use a
I can not switching button
power, please try again from the beginning. P38 P49 commercially available reducing bleach (hydro-exclusion chromatography, etc.). It can not be used in the case of Care
■ Lint filter Drying filters lighting flickering ● Please closer than 3m from the television or radio.
Though there is not excessive lint ● Clean display of the filter has announced a measure of cleaning. There is a case to be lit even if
entering noise on TV and radio that
Display is lit "filter cleaning" "dry accumulated lint condition is small. Also, please be sure is not clogged dirt to the drain outlet.
● There is the illumination during operation flicker, but this is caused by the power situation such as the resistance
Filter cleaning" and installa
It is laden water exits the iron rust
of the interior wiring. Lighting flickering is somewhat improved when the inverter fluorescent lamp.
?0 1
If you get such a display on the display unit
If a problem occurs during operation, it will be announced in the display, such as the bottom or the right page.
P11 will not be able to open the door) ● If you want to open the door, turn on the power, please
● Sure that you have installed the dry filter.
● Drying filter is disconnected. drain the water in the drum and the operation of the
dehydration only.
● Do not you close the faucet. ● Please press after the inspection.
● ●
In water supply facilities, or it does not have a water leakage detection function.
● Forced or not the door lock (child lock). If you want to open the door, chai Please cancel the Rudorokku.
● Water Do not water outage or frozen. To the water supply port of the network or does not have
Please You are viewing the child
● accumulated garbage. (Extremely water pressure is low (case per minute about 3L or less), you will be lock. P11
When the trouble can not be rectified even after
※ In the case of the display shown below is a failure. Close the faucet turn off the power, please have it repaired, unplug the
● Do not you close the faucet. power plug.
● Please press after the inspection.
(TW-3000VE / 3000VER ● Do not use the water heater.
only)
● Or bath water pump is not frozen. (Please ask the repair if it is not ● Turn on the power, please drive with tap
frozen) water.
※ in the display shown on the left, so that, the
numbers will be displayed on the 3 digit or 4 digit
● Be sure to driving again opened about 30
of.
minutes. If the error appears again has failed the
●
circulation pump. As it is you can use it, or
You do not have a washing only in continuous operation.
weakened the power to remove the dirt, it's in no
longer well Susuge, please have it repaired.
● Do not pause during operation. ● If you want to open the door, please wait
attached a short period of time in the part needs to be replaced in the It might be. Since this case does not become a target of the warranty period, you will be charged the repair as a general
and installa
(At this time, the display has come out, you will not be able to open the door) until Doaro click display is turned off. rule. On the consultation to your dealer, we recommend that you use in response to the periodic inspection.
P11
?
When Need help of
Troubleshooting Where to find
Water leakage ● The shape of the faucet Do you have suitable. Hose fittings
"When the display of the panel portion is wrong," "stops on the way," "it does not work even if you press the operation button" is, there are times when you are under the influence of
hazardous noise from the outside. Unplug the power cord, please check the operation by inserting again.
● Do Mase screws and nozzle Gayu Rundei of ● Please inspect.
hose fittings.
Troubleshooting Where to find ● Or are inclined water supply port nut, do not Water inlet nut
● Drying operation after the door might be heavy. Display the power supply "ON" You can open the off der Re if ● Do not use accessories and different Drain hose off
door. hose fittings. ● The processing of
● Turn off the power during operation, or does not have or there is a power failure. ● Or shift drainage hose, do not tear. waste water hose
Ya Ri mend go
● Do not come out the display of the Ya the display unit. P62
please.
● Not in the book. ● Has it lint filter is installed in the certainty.
● When the bubble by the detergent within 5 minutes from washing the start of a large amount of generated, even doors will
P54
Packaging bolt
abnormal sound comes out → Please refer to the installation instructions.
1.5m below
longer.
● Matchstick, hairpin, do not wash together with a metal object. ※ For drum-type washing and drying machine is a small amount of water used compared to the washing machine, also reduces the amount of
● Clothing of clothing one or just a small amount (a few pieces), if only the dewatering clothing that was put in the washing ● Do not have too much clothing. In addition, dehydration is sufficient either.
Loose dehydration A long drying time
net, because the cloth is likely to offset, it may that vibration is no longer able to dehydration large. Or to operate in the ● The temperature is either not too low at the installation site (5 ℃ or less).
rotation is forever
"small amount" course, please drive along with other clothing such as adding a 1, 2 sheets bath towel.
● Lint filter or dry filter, air intake filter, or does not have accumulated lint to dry circulation port. and installa
P26 P54
? (to be continued)
When Need help of (Cont.)
After the sun towel is ● Drum-type washing and drying machine, for wash by dropping the clothing of the "beat-washing", the laundry
such as towels you may fluff or loop collapses. Whether you use a softener, after dehydration, and then the
stiff
sun do about 30 minutes dry, you finish better texture. Also, when set to "soft finish", and then wash in so that
it finishes better texture.
P39 P43
● It does not dry the clothes that should not be dry or. P17
Often with wrinkles after drying
● Or amount of clothing is a lot, do not leave without removing the dry after the end of clothing. Clothing the fewer the,
clothes
please immediately take out Once the drying is complete.
● If you are contaminated with thick trousers and trainers also in the "standard" course, there is that moisture
A dry after half-dried wash rinse dehydration Drying Bath
water reservation start Washing Wash and dry Drying Cold / hot air OFF Input
remains.
● Do not have too much clothing.
A la Lee Vinegar vinegar formate
Da Tsu Su Yi Ka Ng, Seo over Yo Ya-click Vinegar data-overSe Ng
Full and Russia Se mosquitoesKa Ng air Ki Li Lee Li
■ Beep
Turn the dial to the buzzer sounds. When you press ● The buzzer sounds a "beep" and the setting is forward.
● After the operation only "washing", or does not have the operation ● Returning to the starting point with the "peak" will be longer of sound.
the button the buzzer sounds.
only "dry". Firmly take out the laundry in front of the "dry" After ● Is, if there is no path, you will hear a "beep".
dehydration, please cycle from loosen well to the drum (washing and
de-water tank). The origin of each button is as follows.
※
● Lint filter or dry filter, air filter, to dry circulation port Do not Itoku Zugatama'.
button
P54
● Until the collar of the cap of the detergent supply case, do not put the liquid washing and softener. It will flow out in
specification
It flows out liquid detergents
the middle of the laundry too put. TW-2100VE / 2100VER
and softener
Standard washing capacity 9.0kg (the mass of the cloth at the time of drying)
seed Kind Drum-type fully automatic electric washing machine
cap Dividing Shimekatachi electric clothes dryer Standard dehydration capacity 9.0kg (the mass of the cloth at the time of drying)
There is not much effect of the
Power source AC 100V 50Hz -60Hz shared Standard Drying capacity 6.0kg (the mass of the cloth at the time of drying)
softener Cap collar
Power consumption of Wash at 110W Standard water amount 30L
?
Warranty and after-sales service Please be sure to read it
Toshiba home appliances repair consultation center time Toshiba Consumer consultation center
0120-1048-41 0120-1048-86
Available from the mobile phone · PHS is East district () 044-543-0220
Hokkaido, Tohoku, Kanto, Koshinetsu, Day
Tokai, Okinawa Prefecture
Available from the mobile phone · PHS is 03-3426-1048
West district () 06-6440-4411
Other than those above FAX 03-3425-2101 (365 days: 8:00 to 20:00 acceptance)
- "Toshiba home appliances repair consultation center", "Toshiba Consumer consultation center", we have operated by Toshiba Techno Network Corporation.
- Personal information provided by customers, the answer to the repair and consultation, will be used to provide information such as catalog shipping.
- Within the scope of the purpose of use, you may want to provide your personal information to Toshiba Group companies and partner companies related to the product.
card. ● The repair performance parts, is the parts necessary to maintain the function of the product.
● Warranty card, after always confirms it out a serial input, such as "date of purchase
and sales shop name", after carefully read the contents will be received from the
dealer.
The warranty period for the repair of after, please consult your dealer. If that can be used if repair, Date of purchase Year Month Day
fired and had to be repaired for a fee upon request. Fault of circumstances As specifically as possible
Technical Rates are to successfully repair the failed product. Date Convenient
It is convenient to be filled in the purchasing dealer name of.
fee cost of price that was used to repair. MEMO
selling the goods for It is properly deliver have been asked to store and municipalities.
Many years use of the washing and drying machine of the inspection!
68