Professional Documents
Culture Documents
KOLEJ VOKASIONAL
KEMENTERIAN PENDIDIKAN MALAYSIA
OBJEKTIF / OBJECTIVE :
1. Make sure all the cable to the computer are correctly connected.
2. Switch on the computer, start the FluidSIM Pneumatic / Hydraulic. Switch off the
computer correctly after finish the work.
TUGASAN / TASK 1 : SILINDER KAWALAN PNEUMATIK
( 2 Jam )
KAEDAH / PROCEDURE :
1. Open / start FluidSIM Pneumatic.
2. Create a NEW project for the pneumatic circuit diagram (Figure 1).
3. Select the components / materials to be used.
4. Configure and connect equipment.
5. Simulate the pneumatic control circuit. To simulate or RUN the circuit / project, click the
PLAY button on the toolbar.
6. Write down your simulation observation using the space provided.
7. Repeat step 2 – 6 for the other pneumatic circuit diagram (Figure 2, 3 and 4).
1 A1
1 S1
2
1 3
1 V1 2
1 1
1 S2 2
1 S1 2
1 3
1 3
1 A1
1 S1
4 2
5 3
1
Apabila push button ditekan maka acting silinder akan ditolak keluar dan apabila push button
dilepaskan maka acting silinder akan ditarik masuk
Litar ini mempunyai 2 push button dimana jika push button kiri ditekan, udara termampat akan
menolak piston keluar dan masuk semula. Sama juga dengan push button disebelah kanan
Apabila push button ditekan, udara yang mampat akan menolak piston keluar, dan push button
tersebut harus ditekan semula untuk piston tersebut ditarik masuk
Litar ini mempunyai 2 push button dimana apabila push button kiri ditekan,udara termampat akan
keluar dan push button kanan harus ditekan untuk piston tersebut masuk semula.
TUGASAN / TASK 2 : SILINDER KAWALAN HIDRAULIK
(2 jam )
KAEDAH / PROCEDURE :
1. Open / start FluidSIM Hydraulic.
2. Create a NEW project for the hydraulic circuit diagram ( Figure 5).
3. Select the components / materials to be used.
4. Configure and connect equipment.
5. Simulate the hydraulic control circuit. To simulate or RUN the circuit / project, click the
PLAY button on the toolbar.
6. Write down your simulation observation using the space provided.
7. Repeat step 2 – 6 for the other hydraulic circuit diagram (Figure 6,7 and 8).
P T
B
A
P T
Ts
1 V2
X
A
1 V1 A B
P T
0 V2
0 V1
P
P T
0 Z1
Ts
Push button harus ditekan sehingga bendalir menolak piston tersebut keluar dan piston tersebut
akan masuk semula apabila push button dilepaskan.
Apabila push button ditekan, bendalir akan menolak piston keluar dan akan masuk semula apabila
push button dilepaskan
FIGURE 1
FIGURE 2
FIGURE 3
FIGURE 4
FIGURE 6
FIGURE 5
FIGURE 7 FIGURE 8