Professional Documents
Culture Documents
TOUCH
1) After the monitor has been turned on & is at the main monitoring screen, press the setup
button at the bottom of the display.
2) Once you have pressed the Setup button, a new window will open up.
a. On this screen, you will need to press the Optional Modules button
4) Once you have been supplied the password by DRE, you will need to input this password into the monitor.
a. In order to input the password do the following
i.Once the monitor has been turned on, press the setup button across the bottom of the monitor
ii.Once this menu opens, press the Optional Modules Button
b. On this menu, you will need to touch the White Box next to the parameter that you are trying to unlock
6) On this screen, the greyed out box that previously said “Off” will now be white allowing you to change
the option to:
a. On for IBP
b. Respironics for CO2
c. Phase In for Gas
7) If you get to this screen and the option is still Greyed out, please check that you entered the password correctly
ii. This will open the Waveform Selection box, where you can choice what parameters to display
b. If you are trying to display more than 3 parameters (ECG, Spo2, Co2, IBP), then we need to change the
number of fields that are shown on the display
i. To change the number of fields, on the System Setup screen, change the display mode from 3
Waveforms to 6 Waveforms
ii. With the display set in 6 Waveforms Display Mode, do the same as above in steps 8.a.i-8.a.iii
12) Once the monitor has completed saving the current configuration of the monitor, you will see
“Save Config Data Success”