PT.

ANUGERAH SAMUDERA JAYA

GENERAL CONTRACTOR- COUNSTRUCTION & ENGINEERING, MECHANICAL, ELECTRICAL, HYDRAULIC SYSTEM,
PIPING, STEEL WORK, TROUBLE SHOOTING, COMMISSIONING, MAN POWER SUPPLY, HEAVY EQUIPMENT,
MARINE OIL, REWINDING ALTERNATOR
: (Kantor Pusat) Perum. Griya Permai Blok LL No. 4 Sagulung , (Kantor Cabang) Tenggumung Karya Lor 120 Surabaya.
: animanandy@yahoo.co.id – andy.ikhwatin@gmail.com
: 0813 3275 6842 / 0812 1588 80888

Proj.Sup't WIDADI
Trade Sup'v KKM
Vessel FLF. Ratu Mahakam
PT. ANUGERAH
Subcontractor
SAMUDERA JAYA
Main Code Start Date 03-Nov-22
Page 1 of 1 End Date 05-Nov-22

Sub
Description Remark
Code
1 Check wiring system BILGES PCB need to check with Terasaki specialist
2 Check system wiring CO2 OK (done)
3 Check OWS system Need to calibration unit display jowa complate with sensor
4 Check sensor magnetic valve engine stop Must to replace the motherboard (MG01)
5 Check sensor PT 100 Must be replace new sensor PT100 (MG 03)
Note :
1 Bilges system Checked the bilges system on all 4 floating limit units and
found 1 damaged floating limit and the wiring system was
also found damaged at error PCB can not respond to
commands sent from floating limit switch

2 CO2 alarm The work of troubleshooting door limit switch CO2 panel
room has been done, it was found that the 24 volt DC
power supply did not join to the control relay limit switch
cut off fan system

3 OWS system The work of troubleshooting OWS system, cleaning sensor

and checking OWS valve temperature has been done, it
was found ppm reading error and must to re-calibration

4 Engine stop magnetic value (MGE-01)
5 Sensor PT 100(MGE-03)
The work of checking magnetic valve stop engine has been
done, it was found power supplay 24 VDC wire
disconnected on terminal (TB-1). Recommended to replace
new one motherboard ESCU
The work of checking PT-100 has been done, it was found
sensor wire damage and the sensor was broken.
Recommended to replace the sensor and wire sensor with
the new one.

Prepare By :

Andy
(PT. ANUGERAH SAMUDERA JAYA)