Professional Documents
Culture Documents
Sep 2008 EE Board Exam Part 5
Sep 2008 EE Board Exam Part 5
____
Republic of the Philippines
PROFESSIONAL REGULATION COMMISION
Manila
R. E. E. Licensure Examination
Monday, September 22, 2008 08:00 a.m - 04:00 p.m.
------------------------------------------------------------------------------------------------------------
INSTRUCTION: Select the correct answer for each of the following questions. Mark only one
answer for each item by marking the box corresponding to the letter of your choice to the answer
sheet provided. STRICTLY NO ERASURES ALLOWED. Use pencil No. 1 only
MULTIPLE CHOICE
29. In a power transmission system, step-up power transformer is usually used in order to;
a. Reduce the voltage from high to low value.
b. Increase the current from low to high value.
c. Increase the magnitude of voltage at the secondary side
d. Reduce the necessary apparent power by the load.
30. The anti-phase current in transformer is directly proportional to;
a. No-load current c. Magnetizing current
b. Primary current d. Load current
31. An induction motor (IM) that is constructed in a manner that the armature coils are housed and is
practically in most fractional HP rating.
a. Wound Rotor IM c. Squirrel Cage IM
b. Synchronous IM d. Universal mototr
32. An autotransformer is rated 50 KVA, 13800 / 7200 volts supplying a load of 50KVA at 70.7%
lagging PF. What is the transformed power when this transformer is operating at full-load condition?
a. 14.88 KW b. 15.65 KW c. 16.91 KW d. 17.63KW
33. A 50 MVA power transformer has a reactance drop of 2.8% and resistance drop of 1.2% , what
percent regulation of this transformer is obtained at 0.8 lagging PF?
a. 2.65% b. 3.02% c. 4.06% d. 5.65%
34. Two distribution transformers are operate in parallel. Unit 1 - 10Kva, 4600:230 V, Ze-s = 0.16 ohm
while
Unit 2 – 7.5 Kva, 4485:230 V, Ze-s = 0.22 ohm, the circulating current at secondary is
approximately___
a. 12.45A b. 15.35 A c. 16.87 A d. 17.30 A
35. A polarity test is performed upon a 1150/115 – volt transformer. If the applied input voltage is 116V,
what would be the subtractive and additive voltage through the voltmeter reading?
a. 127.60V and 104.4V c. 146.50V and 103.50V
b. 137.50V and 114.5V d. 156.60V and 126.50V