You are on page 1of 3

Historical comments and current status

Introduction to CFD

CFD Applications

Unsteady flows

Rotorcraft flows

Numerical and engineering aspects of computational fluid dynamics

Recent developments in CFD

Biofluid mechanics

Computational aerodynamics

Concept of a generalized CFD-model for multiphase flows

Acoustics and fluid-structure interaction

Poly-dispersed bubbly flows in vertical pipes

Poly-dispersed bubbly flows in complex geometries

Bubble entrainment caused by a liquid jet

Stratified flows in horizontal channels

Phase transfer at free surfaces

Application of innovative two-phase flow measurement techniques

Continuum Hypothesis in the Computation of Gas-Solid Flows

Numerical Modeling of Two- and Three- Dimensional External and Internal Unsteady
Incompressible Flow Problems

Numerical Experiments in Double-Diffusive Convection

General Balance Equations for a Fluid-Fluid Interface in Magnetofluid dynamics

New Potentialities of Computational Experiment in Tsunami Problem


HVAC Capability of the Proposed Airport Design Considering Real Heat Loading

Structural Assessment of Tower Subjected to Hydrodynamic Wind and Wave Loads

Measuring Lift & Drag Forces for a Flow Over Formula1 Car’s Rear Wing

Simulating Air and Fuel Flow Inside the Modified Inlet Duct to Visualize Flow

CFD Simulation of Exhaust Gas Dispersion into Atmosphere from Industrial Stack

Aerodynamics of the New concept & Helps in Reducing the Design Cycle

CFD Flow Analysis Through Diffuser Project for One of the Top Air Conditioner Company in
USA

Modelling and simulation on boiling processes in pressurized water reactors

Modelling and simulation of boiling flows in modules with large vertical dimensions

Modelling of churn-turbulent flows

CFD-model development and validation related to the transport, deposition and re-suspension of
aerosol particles

CFD simulation of fibre material transport in a PWR core under loss of coolant conditions

Modelling and simulation of two-phase flows in bubble columns

CFD models for two-phase flows Ceramic solid foam packing

Modelling and simulation of threephase flow in flotation equipment

In close co-operation with the department of Experimental Thermal Fluid Dynamics the
following topics aiming on the generation of experimental data for two-phase flows suitable for
CFD code qualification are done:

Gas-liquid flows in vertical pipes

Flow around an obstacle in a vertical DN200 pipe

Hot leg model of a Pressurized Water Reactor (PWR)


Pressurized Thermal Shock (PTS) in case of Emergency Core Cooling in a PWR

Experiments on boiling processes in pressurized water reactors

Experiments related to the transport, deposition and re-suspension of aerosol particles

You might also like